NOTE:
Please read all instructions
carefully before using this
product
Table of Contents
Safety Notice
APEX
POWER STATION
TC-3502
Hardware Identifier
Assembly Instruction
Parts List
Warranty
Ordering Parts
Model
TC-3502
Retain This
Manual for
Reference
06-23-08
OWNER'S
MANUAL
IMPEX® INC.
14777 DON JULIAN RD., CITY OF INDUSTRY, CA 91746
Tel: (800) 999-8899 Fax: (626) 961-9966
Download from Www.Somanuals.com. All Manuals Search And Download.
IMPORTANT SAFETY NOTICE
PRECAUTIONS
This exercise machine is built for optimum safety. However, certain precautions apply whenever
you operate a piece of exercise equipment. Be sure to read the entire manual before you
assemble or operate your machine. In particular, note the following safety precautions:
1. Keep children and pets away from the machine at all times. DO NOT
leave children unattended in the same room with the machine.
2. Only one person at a time should use the machine.
3. If the user experiences dizziness, nausea, chest pain, or any other abnormal
symptoms, STOP the workout at once. CONSULT A PHYSICIAN IMMEDIATELY.
4. Position the machine on a clear, leveled surface. DO NOT use the machine
near water or outdoors.
5. Keep hands away from all moving parts.
6. Always wear appropriate workout clothing when exercising. DO NOT wear
robes or other clothing that could become caught in the machine. Running
or aerobic shoes are also required when using the machine.
7. Use the machine only for its intended use as described in this manual. DO
NOT use attachments not recommended by the manufacturer.
8. Do not place any sharp object around the machine.
9. Disabled person should not use the machine without a qualified person or
physician in attendance.
10. Before using the machine to exercise, always do stretching exercises to
properly warm up.
11. Never operate the machine if the machine is not functioning properly.
CARE AND MAINTENANCE
1. Inspect and tighten all parts before using the machine.
2. The machine can be cleaned using a damp cloth and mild non-abrasive detergent.
DO NOT use solvents.
3. Maximum user’s weight: 300 lbs.
WARNING: BEFORE BEGINNING ANY EXERCISE PROGRAM, CONSULT YOUR
PHYSICIAN. THIS IS ESPECIALLY IMPORTANT FOR INDIVIDUALS OVER THE AGE OF 35
OR PERSONS WITH PRE-EXISTING HEALTH PROBLEMS. READ ALL INSTRUCTIONS
BEFORE USING ANY FITNESS EQUIPMENT. IMPEX INC. ASSUMES NO RESPONSIBILITY
FOR PERSONAL INJURY OR PROPERTY DAMAGE SUSTAINED BY OR THROUGH THE
USE OF THIS PRODUCT.
SAVE THESE INSTRUCTIONS.
2
Download from Www.Somanuals.com. All Manuals Search And Download.
WARNING LABEL REPLACEMENT
The warning label shown here has been placed on the Rear Base. If the labels are missing or illegible, please
call customer service at 1-800-888-8899 for replacements. Apply the labels in the location shown.
3
Download from Www.Somanuals.com. All Manuals Search And Download.
HARDWARE PACK
4
Download from Www.Somanuals.com. All Manuals Search And Download.
ASSEMBLY INSTRUCTION
Tools Required Assembling the Machine: Two Adjustable Wrenches and Allen Wrenches
NOTE: It is strongly recommended two or more people assembling this machine to avoid
possible injury.
STEP 1 (See Diagram 1)
A.) Attach the Lower Vertical Frame (#2) to the Rear Base (#4). Secure it with two M10 x 3 ½”
Carriage Bolts (#32), one U-shaped Bracket (#14), two Ø ¾” Washers (#35), and two M10
Aircraft Nuts (#33).
B.) Attach the Right & Left Stabilizers (#5 & #6) to the Lower Vertical Frame. Align the holes and
secure them with four M10 x 3 5/8” Carriage Bolts (#30), Ø ¾” Washers (#35), and M10 Aircraft
Nuts (#33).
C.) Attach the Push-up Handles (#40) to the Right & Left Stabilizers. Secure each Handle with two
M10 x 3 1/8” Allen Bolt (#41), Ø ¾” Washers (#35), and M10 Aircraft Nuts (#33).
5
Download from Www.Somanuals.com. All Manuals Search And Download.
STEP-2 (See Diagram 2)
Download from Www.Somanuals.com. All Manuals Search And Download.
A.) Attach the Upper Vertical Frame (#1) onto the Lower Vertical Frame (#2). Secure it with two
L-shaped Brackets (#9), two M10 x 3” Carriage Bolts (#31) from the front, two M10 x 3 5/8”
Carriage Bolts (#30) from the side, four ∅ ¾” Washers (#35), and four M10 Aircraft Nuts
(#33).
B.) Attach the Chin-up Bar (#3) to the front of Upper Vertical Frame. Secure it with two M10 x 2”
Allen Bolts (#25) and ∅ ¾” Washers (#35). Cover the Bolts with a 2” x 2 ¾” Plastic Cover
(#16).
Download from Www.Somanuals.com. All Manuals Search And Download.
6
STEP 3 (See Diagram 3)
A.) Attach the Left & Right Dip Supports (#7 & #8) to the Upper Vertical Frame (#1). Secure
them to the Upper Vertical Frame with one M12 x 3 ¾” Allan Bolt (#26), two ∅ ¾”
Washers (#37), and one M10 Aircraft Nut (#34). Do NOT over tighten the nut and bolt.
Make sure the arms are able to move freely.
B.) Secure the Left & Right Dip Supports together with one Four-hole Bracket (# 15) and four
M8 x 3/8” Allen Bolts (#29).
C.) Insert a Vertical Handle (#13) into the hole on each Dip Support. Secure each Handle
with one M10 x 1” Allen Bolt (#27) and Ø ¾” Curved Washer (#38).
D.) Flip the Dip Supports up to a vertical position when doing Chin-up exercises.
Download from Www.Somanuals.com. All Manuals Search And Download.
7
STEP 4 (See Diagram 4)
A.) Attach the Backrest Pad (#12) to the Upper Vertical Frame (#1). Secure it with two M8 x 2 ¾”
Allen Bolts (#28) and ∅ 5/8” Washers (#36).
B.) Attach the Arm Pads (#11) to the Left & Right Dip Supports (#7 & #8). Secure each Arm Pad
with two M8 x 2 ¾” Allen Bolts (#28) and Ø 5/8” Curved Washers (#39).
C.) Insert a Foam Tube (#10) halfway through the holes on the Lower Vertical Frame (#2). Push
two Foam Rolls (#24) onto the Tube from both ends. Plug two Foam Roll End Caps (#22) to the
end of the tube.
D.) Firmly thread each end of the Cable (#23) into the Upper and Lower Vertical Frames.
E.) Securely tighten all nuts and bolts pervious installed.
Download from Www.Somanuals.com. All Manuals Search And Download.
8
EXPLODED DIAGRAM
Download from Www.Somanuals.com. All Manuals Search And Download.
9
Download from Www.Somanuals.com. All Manuals Search And Download.
Parts list
KEY NO. DESCRIPTION
Q’ty
1
2
3
4
5
6
7
8
Upper Vertical Frame
Lower Vertical Frame
Chin-up Bar
Rear Base
Right Stabilizer
1
1
1
1
1
1
1
1
2
1
2
1
2
1
1
1
2
2
2
4
1
2
1
2
2
1
2
6
4
6
2
2
14
1
16
2
2
2
4
2
4
Left Stabilizer
Left Dip Support
Right Dip Support
L-shaped Bracket
Foam Tube
Arm Pad
Backrest Pad
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
Vertical Handle
U-shaped Bracket
Four-hole Bracket
2” x 2 ¾” Plastic Cover
Sleeve
Push-up Handle Grip
Chin-up Handle Grip
Dip Handle Grip
2” x 2 ¾” End Cap
Foam Roll End Cap
Cable
Foam Roll
M10 x 2” Allen Bolt
M12 x 3 ¾” Allen Bolt
M10 x 1” Allen Bolt
M8 x 2 ¾” Allen Bolt
M8 x 3/8” Allen Bolt
M10 x 3 5/8” Carriage Bolt
M10 x 3” Carriage Bolt
M10 x 3 ½” Carriage Bolt
M10 Aircraft Nut
M12 Aircraft Nut
Ø ¾” Washer
Ø 5/8” Washer
Ø 1” Washer
Ø ¾” Curved Washer
Ø 5/8” Curved Washer
Push-up Handle
M10 x 3 1/8” Allen Bolt
10
Download from Www.Somanuals.com. All Manuals Search And Download.
IMPEX® INC.
LIMITED WARRANTY
®
IMPEX Inc. ("IMPEX ") warrants this product to be free from defects in workmanship and
material, under normal use and service conditions, for a period of two years on the Frame from
the date of purchase. This warranty extends only to the original purchaser. IMPEX's obligation
under this Warranty is limited to replacing or repairing, at IMPEX's option.
All returns must be pre-authorized by IMPEX. Pre-authorization may be obtained by calling
IMPEX Customer Service Department at 1-800-999-8899. All freights on products returned to
IMPEX must be prepaid by the customer. This warranty does not extend to any product or
damage to a product caused by or attributable to freight damage, abuse, misuse, improper or
abnormal usage or repairs not provided by an IMPEX authorized service center or for products
used for commercial or rental purposes. No other warranty beyond that specifically set forth
above is authorized by IMPEX.
IMPEX is not responsible or liable for indirect, special or consequential damages arising out of or
in connection with the use or performance of the product or other damages with respect to any
economic loss, loss of property, loss of revenues or profits, loss of enjoyments or use, costs of
removal, installation or other consequential damages or whatsoever natures. Some states do not
allow the exclusion or limitation of incidental or consequential damages. Accordingly, the above
limitation may not apply to you.
The warranty extended hereunder is in lieu of any and all other warranties and any implied
warranties of merchantability or fitness for a particular purpose is limited in its scope and duration
to the terms set forth herein. Some states do not allow limitations on how long an implied
warranty lasts. Accordingly, the above limitation may not apply to you.
This warranty gives you specific legal right. You may also have other rights which vary from state
®
IMPEX INC.
14777 Don Julian
City of Industry, CA 91746
ORDERING REPLACEMENT PARTS
Replacement parts can be ordered by calling our Customer Service Department toll-free at 1-800-
999-8899 during our regular business hours: Monday through Friday, 9 am until 5 pm Pacific
standard time.
When ordering replacement parts, always give the following information.
1.
2.
3.
4.
Model
Description of Parts
Part Number
Date of Purchase
11
Download from Www.Somanuals.com. All Manuals Search And Download.
|