NOTE:
Please read all instructions
carefully before using this
product
Table of Contents
Safety Notice
Hardware Pack
Assembly Instruction
Parts List
Deluxe Fan Bike
AIR-1
Warranty
Ordering Parts
Model
AIR-1
Retain This
Manual for
Reference
121209
ASSEMBLY &
OWNER'S
IMPEX® INC.
2801 S. Towne Ave, Pomona, CA 91766
Tel: (800) 999-8899 Fax: (626) 961-9966
MANUAL
Download from Www.Somanuals.com. All Manuals Search And Download.
IMPORTANT SAFETY NOTICE
PRECAUTIONS
This exercise machine is built for optimum safety. However, certain precautions apply
whenever you operate a piece of exercise equipment. Be sure to read the entire manual
before you assemble or operate your machine. In particular, note the following safety
precautions:
1. Keep children and pets away from the machine at all times. DO NOT leave
children unattended in the same room with the machine.
2. Only one person at a time should use the machine.
3. If the user experiences dizziness, nausea, chest pain, or any other abnormal symptoms,
STOP the workout at once. CONSULT A PHYSICIAN IMMEDIATELY.
4. Position the machine on a clear, leveled surface. DO NOT use the machine near water
or outdoors.
5. Keep hands away from all moving parts.
6. Always wear appropriate workout clothing when exercising. DO NOT wear robes or
other clothing that could become caught in the machine. Running or aerobic shoes are
also required when using the machine.
7. Use the machine only for its intended use as described in this manual. DO NOT use
attachments not recommended by the manufacturer.
8. Do not place any sharp object around the machine.
9. Disabled person should not use the machine without a qualified person or physician in
attendance.
10. Before using the machine to exercise, always do stretching exercises to properly warm
up.
11. Never operate the machine if the machine is not functioning properly.
12. Read all warnings posted on the exercise bike.
13. Inspect the exercise bike for worn or loose component prior to use. Tighten/replace any
loose or wore components prior to use.
14. Care should be taken in mounting or dismounting the exercise bike.
15. This exercise bike is for consumer and home use only.
WARNING: BEFORE BEGINNING ANY EXERCISE PROGRAM, CONSULT YOUR
PHYSICIAN. THIS IS ESPECIALLY IMPORTANT FOR INDIVIDUALS OVER THE AGE
OF 35 OR PERSONS WITH PRE-EXISTING HEALTH PROBLEMS. READ ALL
INSTRUCTIONS BEFORE USING ANY FITNESS EQUIPMENT. IMPEX INC. ASSUMES
NO RESPONSIBILITY FOR PERSONAL INJURY OR PROPERTY DAMAGE
SUSTAINED BY OR THROUGH THE USE OF THIS PRODUCT.
SAVE THESE INSTRUCTIONS.
© IMPEX INC.
2
Download from Www.Somanuals.com. All Manuals Search And Download.
WARNING LABEL PLACEMENT
The Warning Labels and Caution Label shown here have been placed on the Rear Stabilizer, Main Frame.
If the labels are missing or illegible, please call customer service at 1-800-999-8899 for replacement. Apply the
labels in location shown.
© IMPEX INC.
3
Download from Www.Somanuals.com. All Manuals Search And Download.
HARDWARE PACK
NOTE: The following parts are not drawn to scale. Please use your own ruler to measure the size.
© IMPEX INC.
4
Download from Www.Somanuals.com. All Manuals Search And Download.
COMPONENTS FOR ASSEMBLY
© IMPEX INC.
5
Download from Www.Somanuals.com. All Manuals Search And Download.
ASSEMBLY INSTRUCTION
Tools Required For Assembling the Machine: One Crossing Wrench and Allen Wrench,
provided by manufacturer.
NOTE: It is strongly recommended that two or more people assemble this machine to
avoid possible injury.
STEP-1
A.) Do not tighten Bolts until instructed to do so.
B.) Attach the Front Stabilizer (#39) to the Main Frame (#35). Secure it with four M8 x 5/8” Allen Bolts (#5)
and four 5/8” Washers (#6).
C.) Attach the Rear Stabilizer (#55) to the Main Frame. Secure it with four M8 x 5/8” Allen Bolts (#5), and
four Ø 5/8” Washers (#6).
D.) Securely tighten all Bolts.
E.) Use the four Floor Level Adjustment Knobs (#38) to stabilize the Bike on floor.
© IMPEX INC.
6
Download from Www.Somanuals.com. All Manuals Search And Download.
STEP 2
A.) Connect the Upper Computer Wire (#2) from the Front Post to the Computer Wire from the
Computer (#1).
B.) Attach the Computer to the Front Post (#4). Secure it with four Computer Philips Screws (#3).
© IMPEX INC.
7
Download from Www.Somanuals.com. All Manuals Search And Download.
STEP 3
A.) Connect the Lower Computer Wire (#37) from Main Frame (#35) to the Upper Computer Wire (#2)
from Front Post (#4).
B.) Attach the Front Post to the Main Frame. Secure it with four M8 x 5/8” Allen Bolts (#5).
© IMPEX INC.
8
Download from Www.Somanuals.com. All Manuals Search And Download.
STEP 4
A.) Attach the pivot on Left Swing Handle (#30L) to the pivot on Main Frame (#35).
B.) Thread the Swing Handle Shaft (#28) though Left Swing Handle into Main Frame, and
firmly secure them together.
© IMPEX INC.
9
Download from Www.Somanuals.com. All Manuals Search And Download.
STEP 5
A.) Attach the Swing Handle Connecting Rod (#48) to the open bracket on the bottom of the
Left Swing Handle (#30L).
B.) Secure them together with one M8 x 1 ¾” Allen Bolt (#49) and one M8 Aircraft Nut (#50).
© IMPEX INC.
10
Download from Www.Somanuals.com. All Manuals Search And Download.
STEP 6
A.) Attach the pivot on Right Swing Handle (#30R) to the pivot on Main Frame (#35).
B.) Thread the Swing Handle Shaft (#28) through Right Swing Handle into Main Frame,
and firmly secure them together.
© IMPEX INC.
11
Download from Www.Somanuals.com. All Manuals Search And Download.
STEP-7
A.) Attach the Swing Handle Connecting Rod (#48) to the open bracket on bottom of the Right
Swing Handle (#30R).
B.) Secure them together with one M8 x 1 ¾” Allen Bolt (#49) and one M8 Aircraft Nut (#50).
© IMPEX INC.
12
Download from Www.Somanuals.com. All Manuals Search And Download.
STEP-8
A.) Thread the Left Pedal (#41L) counter clockwise into Left Crank (#44L).
B.) Thread the Right Pedal (41R) clockwise into Right Crank (#44R).
© IMPEX INC.
13
Download from Www.Somanuals.com. All Manuals Search And Download.
STEP-9
A.) Remove the three Ø 5/8” Seat Flat Washers (#32) and M8 Seat Aircraft Nut (#33) from the
Seat Pad (#31).
B.) Attach the Seat Pad to the Seat Post (#34). Secure it with the three Ø 5/8” Seat Flat
Washers (#32) and M8 Seat Aircraft Nut (#33) from the Seat Pad (#31).
© IMPEX INC.
14
Download from Www.Somanuals.com. All Manuals Search And Download.
STEP-10
A.) Insert the Seat Post (#34) into the opening one Main Frame (#35).
B.) Thread the Lock Knob (#63) through the hole on Seat Post to securely hold it at desired
height.
© IMPEX INC.
15
Download from Www.Somanuals.com. All Manuals Search And Download.
EXPLODED DIAGRAM
© IMPEX INC.
16
Download from Www.Somanuals.com. All Manuals Search And Download.
PARTS LIST
PART
NO.
DESCRIPTION
SPEC.
QUANTITY
1
2
3
4
5
6
7
8
9
Computer
TZ-2119
1
1
4
1
12
8
4
3
3
4
4
5
4
1
4
3
4
1
1
1
3
2
2
1
2
2
2
2
4
1
1
1
3
3
1
1
2
Upper Computer Wire
Computer Philips Screw
Front Post
Allen Bolt
Washer
Hex Flange Nut
Locking Bolt
U-shaped Plate
Lock Washer
Hex Nut
Philips Screw
Hex Thin Nut
Fly Wheel Shaft
Axle Locking Ring
Aircraft Nut
M8 x 5/8”
Ø 5/8”
M10 Zinc Plated
M6 x 2 3/8”
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30L
30R
31
32
33
34
35
36
Ø ½”
M6
M6 x ½”
M10
Ø ¾”
M5
6000Z
Bearing
Left Cover Net
Plastic Wheel
Right Cover Net
Philips Screw
C Ring
Transportation Roller Wheel
Roller Wheel Shaft
Foam Grip
M5 x 3/8”
Ø 5/8”
9” Foam Grip
Ø 1 ¼”
4 ¾”
End Cap
Handle Bar Grip
Swing Handle Shaft
Bearing
Left Swing Handle
Right Swing Handle
Seat Pad
Seat Flat Washer
Seat Aircraft Nut
Seat Post
6903ZZ
Ø 5/8”
M8
Main Frame
Computer Wire Connector
© IMPEX INC.
17
Download from Www.Somanuals.com. All Manuals Search And Download.
37
38
39
40
41L
41R
42
43
44L
44R
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
Lower Computer Wire
Floor Level Adjustment Knob
Front Stabilizer
Stabilizer End Cap
Left Pedal
Right Pedal
Nut Cap
Hex Flange Nut
Left Crank
Right Crank
Nylon Washer
Stabilizer Leverage Knob
Leverage Knob Plastic Pad
Swing Handle Connecting Rod
Allen Bolt
Aircraft Nut
Plastic Bushing
Sleeve
1
2
1
4
1
1
4
4
1
1
2
4
4
2
2
2
4
2
1
2
1
1
3
1
1
1
16
1
1
1
2
1
4
1
1
1
1
1
1
2
M10
Ø 1 1/8” x ¼”
M8 x 1 ¾”
M8
Ø 5/8” x ½”
Ø 7/8” x 7/8”
2 3/8” x 1 1/8”
Sleeve
Crank Connector
Rear Stabilizer
Locking Bolt
Philips Tapping Screw
Chain Wheel Axle
Chain
Pan Head Tapping Screw
Pan Head Tapping Screw
Left Shroud
M6
ST4.2 x ¾”
ST4.2 x 2 3/8”
ST4.2 x ¾”
Lock Knob
Sensor Holder
Axle Lock Ring
Arc Washer
Bearing
Chain Plate Axle
Crank Wheel
Shroud Sleeve
Right Shroud
U-shaped Stopper
Belt
Ø ¾”
Ø ¾”
6004ZZ
Locking Clip
© IMPEX INC.
18
Download from Www.Somanuals.com. All Manuals Search And Download.
CARE, MAINTENANCE AND STORAGE
1. Inspect and tighten all parts each time you use the machine. Replace any worn parts
immediately.
2. The bike can be cleaned using a damp cloth and mild non-abrasive detergent. Do not use
solvents.
3. Store the bike IN-DOOR. Excess moisture and water would cause rust on the frame.
4. The Bike shall be placed at least 24 inches away from the wall or/and any other object such as
furniture to provide safe access to and passage around the machine.
5. To avoid possible injury, the help of two or more people are needed when moving the machine
around.
6. Disposal Instructions – The equipment can be safely disassembled and disposed without
unreasonable hazards. Call your local recycle agency regarding details of recycling.
7. The maximum user weight is 300 lbs.
8. Assembled Dimension: 45” x 25” x 47.5”
OPERATING NOTES
SEAT ADJUSTMENT
The seat height ranges from 29” to 41”.
Loosen and pull out the Lock Knob. Slide the Seat Post to selected scale marked on the Seat
Post, then release the Lock Knob and securely fasten the Knob to lock the Seat Post.
The seat height adjustment is in approximately 1 ½” increment.
TRANSPORT
The Bike has a pair of transport Roller Wheels on Front Stabilizer. To move, carefully tilt and
roll.
© IMPEX INC.
19
Download from Www.Somanuals.com. All Manuals Search And Download.
COMPUTER
MODE
Press “MODE” button, will automatically scan Time, Speed, RPM, Distance, and Calories, for every
6 seconds.
Time
Speed
RPM
Display the elapsed time. Max value is up to 99:59.
Display the current speed in miles per hour.
Display repetition/min, Speed and RPM display will switch to each other every
6 seconds.
Distance
Calories
Display the distance traveled in Miles. Max value is 99.99 miles.
Display the calorie consumption in cal. Increment by 10 cal. Max value is 999
calories.
SET
1. To set up the hour, minute, year, month and date.
2. To set up the target value of Time, Distance and Calories.
RESET
1. Press the button to reset function value from previous setting.
2. Press the button and hold for 2 seconds to reset all value to zero.
When computer is in idle mode, the screen will display Calendar, Clock, and Temperature.
CALENDAR
CLOCK
Display date, month, and year.
Display current clock time.
TEMPERATURE Displays current room temperature from 50°F to 140°F.
To set up time and date; remove batteries for few seconds, and then place batteries back.
The computer will beep and display “8888” and display Time/Date field.
Press “SET” key to enter the Time or Date field. Press “MODE” key to enter time/Date data.
REPLACE BATTERY:
1. Remove the battery cover on the back of the computer.
2. Replace two 1.5V (AA) batteries.
3. Make sure the batteries are installed correctly and the polarities are correct.
4. If the display is not clear or only partial segments appeared, remove the batteries and wait for
15 seconds before re-install them.
5. The battery life is approx. 3 months under normal usage.
6. When the batteries are removed, all the functional values will reset to zero.
Note:
Please note all values on this computer are approximate and they are for comparison
purpose only. Do not use these values for any medical or rehabilitation purpose.
© IMPEX INC.
20
Download from Www.Somanuals.com. All Manuals Search And Download.
IMPEX® INC.
LIMITED WARRANTY
IMPEX Inc. ("IMPEX®") warrants this product to be free from defects in workmanship and material, under normal use
and service conditions, for a period of two years on the Frame from the date of purchase. This warranty extends only
to the original purchaser. IMPEX's obligation under this Warranty is limited to replacing or repairing, at IMPEX's
option.
All returns must be pre-authorized by IMPEX. Pre-authorization may be obtained by calling IMPEX Customer Service
Department at 1-800-999-8899. All freights for products return to IMPEX must be prepaid by the customer. This
warranty does not extend to any product or damage to a product caused by or attributable to freight damage, abuse,
misuse, improper or abnormal usage or repairs not provided by an IMPEX authorized service center or for products
used for commercial or rental purposes. No other warranty beyond that specifically set forth above is authorized by
IMPEX.
IMPEX is not responsible or liable for indirect, special or consequential damages arising out of or in connection with
the use or performance of the product or other damages with respect to any economic loss, loss of property, loss of
revenues or profits, loss of enjoyments or use, costs of removal, installation or other consequential damages or
whatsoever natures. Some states do not allow the exclusion or limitation of incidental or consequential damages.
Accordingly, the above limitation may not apply to you.
The warranty extended hereunder is in lieu of any and all other warranties and any implied warranties of
merchantability or fitness for a particular purpose is limited in its scope and duration to the terms set forth herein.
Some states do not allow limitations on how long an implied warranty lasts. Accordingly, the above limitation may not
apply to you.
This warranty gives you specific legal right.
You may also have other rights which vary from state to state.
IMPEX® INC.
2801 S. Towne Ave.
Pomona, CA 91766
ORDERING REPLACEMENT PARTS
Replacement parts can be ordered by calling our Customer Service Department toll-free at 1-800-999-8899 during our
regular business hours: Monday through Friday, 9 am until 5 pm Pacific standard time.
When ordering replacement part, always give the following information.
1.
2.
3.
4.
Model
Description of Parts
Part Number
Date of Purchase
© IMPEX INC.
21
Download from Www.Somanuals.com. All Manuals Search And Download.
|