Evaporative
Humidifier
Owner’s Guide
Model
33116
Form# 44062-01
20100608
©2010 Hunter Fan Co.
Download from Www.Somanuals.com. All Manuals Search And Download.
At A Glance
1
Warnings and Introduction
ReAD AND SAve THeSe INSTRUCTIONS
Important Safety Instructions: Read all instructions before using this humidifier.
• This humidifier may not work properly on an uneven surface. ALWAYS place this humidifier on a firm, level and water
resistant surface. ALWAYS place the humidifier at least six (6) inches away from walls and heat sources such as stoves,
radiators or heaters.
• ALWAYS place the humidifier in an area that is out of the reach of children.
• Before using the humidifier, extend the cord and inspect for any sign of damage. DO NOT use the product if the cord
has been damaged.
• This product has a polarized plug as a safety feature (one blade is wider than the other). This plug will fit into a polarized
outlet only one way. If the plug does not fully fit into the outlet, reverse the plug. If it still does not fit, contact a qualified
electrician. DO NOT attempt to defeat or override this feature.
• ALWAYS unplug and empty the humidifier when it is not in operation or while it is being cleaned.
• DO NOT tilt or move the humidifier while it is in operation. Never move the humidifier while there is water in the tank.
Empty the water tank, turn the unit off, and unplug the unit before moving.
• In addition to routine maintenance which may be required, this humidifier requires seasonal cleaning. Refer to and follow
the instructions for “Cleaning and Storage” on page 6.
• This unit was designed to be used with distilled and/or tap water. DO NOT add scented oils, perfumes or fragrance
additives to the water.
• Never fill the humidifier tank with hot water. Always use clean, cool tap water.
• The warnings and cautions in this owner’s manual cannot cover all situations, or events that may arise. Common sense
and caution should be used by the operator in using this device to prevent injury or accident.
The Hunter® evaporative Humidifier has a unique, patented design with several innovative features:
• Built-in Antimicrobial Properties – We use Microban® on many of the plastic parts and wick. This helps inhibit the growth
of bacteria, mold and fungi that may affect these parts.
NOTe: This product contains antimicrobial properties which are built-in to inhibit the growth of bacteria which may affect
the plastic and wick in the humidifier. These properties do not extend to the water, humidified air, or users. Conduct routine
cleaning and maintenance based upon use and individual conditions.
• No White Dust – The Hunter® Evaporative Humidifier produces no white dust that can settle on furniture or be inhaled.
NOTe: You may notice mineral deposits accumulating in the tank Tray. This is normal and does not affect performance. If
you would like to clean these deposits away, please see “Cleaning and Storage” on page 6.
3
©2010 Hunter Fan Company
Download from Www.Somanuals.com. All Manuals Search And Download.
Using Your Humidifier
2
Initial Setup and Operation
Initial Setup
1. Remove the Hunter® Evaporative Humidifier from its packaging.
2. Place the humidifier on a hard, flat, water resistant surface. Always place the
humidifier at least six (6) inches away from walls and sources of heat.
3. Make sure the power/speed control is in the ‘OFF’ position.
Wick
NOTe: The power/speed control should always be off before unplugging the
humidifier, moving the humidifier, or refilling the water tank.
4. Lift the housing to ensure the wick is properly seated, resting on the bottom of
housing back on the water tray.
Figure 1.
Figure 2.
Figure 3.
Tank Handle
5. Grasp the water tank by the tank handle and remove it from the water tray.
6. Turn the water tank upside-down and remove the tank cap by turning counter-
7. Fill the water tank with clean, cool water and return the tank cap to its position.
Tighten it by turning clockwise, and return the water tank to the water tray.
8. Plug the humidifier’s power cord into a standard household power outlet.
9. Turn the power/speed control to your desired humidifier fan speed.
Operation
Off
Turns the unit off.
Low: Extends the time between refills by running the fan on low.
Lowest noise setting recommended for nighttime use.
High: Average refill rate and optimal for day use. Minimal noise
level.
To turn on or off the Niteglo™ Nitelight, just press the Niteglo™ Button on the top
of the unit.
If you choose to use vapor pads in your humidifier:
Remove 1 vapor pad from the packaging, and insert it lengthwise into the vapor
pad tray on the top of the exhaust grill. Vapor pads will typically last for 24 hours
before needing replacement.
Niteglo™
Nitelight
Control
Knob
Vapor Pad Tray
Figure 4.
5
©2010 Hunter Fan Company
Download from Www.Somanuals.com. All Manuals Search And Download.
Maintenance
3
Cleaning and Storage
Many regions have hard water with high concentrations of minerals. When water
evaporates from the Hunter® evaporative humidifier, minerals may be left behind.
These minerals can form a hard white scale which can be removed by following
the cleaning instructions. The frequency of cleaning due to mineral build up can
1. Turn the humidifier off and unplug the unit.
2. Lift the main housing and remove the water dispersion tray and the wick. The
motor is attached to the main housing. Do not place the motor near water. Do
not use a wet towel on the motor or motor housing as electrical shock may
occur.
Figure 5.
3. Replace the humidifier’s wick every 4 weeks or when it has turned brown.
4. Remove the water tank from the base and empty any water that is left in the
tank. Soak the base in a mixture of one (1) gallon of water and eight (8)
ounces of vinegar for 20 minutes. The base is dishwasher safe.
5. After soaking, wipe the base with a soft cloth or sponge to remove any
mineral build up. Rinse with clean water several times. If you are planning on
storing the humidifier, be sure the base is completely dry.
Figure 6.
6. Fill the water tank with one (1) gallon of water and eight ounces of undiluted
until all interior surfaces of the tank have been exposed to the water/vinegar
mixture.
7. Empty the tank of the water/vinegar mixture. Rinse it several times with clean
water and then replace the tank cap. If you are planning to store the humidifier,
dry it inside and out, leaving the cap off to allow the tank to completely dry.
Continue to clean the other parts of your humidifier.
Setup and Operation” on page 5 to continue use. If you are storing the
humidifier, make sure all parts are completely dry before reassembling, and
storing in a dry location.
6
44062-01 • 06/08/2010
Download from Www.Somanuals.com. All Manuals Search And Download.
Maintenance
3
Replacing the Wick
NOTe: The humidifier’s wick is made of paper and is NOT washable.
Over time, minerals in your water will build up in the humidifier’s wick, degrading
its ability to absorb water and reducing the humidifier’s output. Therefore, you
should replace the humidifier’s wick every season, depending on the hardness of
your water.
1. Turn the humidifier off and unplug the unit.
3. Grasp the humidifier wick, hold it over the base, and squeeze the water from
want to wrap the wick in a towel to keep it from dripping while you transport
it to disposal.
Figure 7.
4. Replace the old wick with a new Hunter humidifier wick. New wicks are
5. Ensure the wick is properly seated, resting on the bottom of the base and not
tilted or otherwise out of position.
6. Return the main housing to its position on the base. Make certain the main
housing is properly seated on the base.
7. Plug the humidifier’s power cord into a standard household power outlet and
turn the power/speed control to your desired setting.
Figure 8.
7
©2010 Hunter Fan Company
Download from Www.Somanuals.com. All Manuals Search And Download.
Humidifier Assistance
4
Troubleshooting
Problem:
Excessive noise.
Solution:
1. Check the water tank to make sure it is properly seated on the base.
2. Check the water tank to make sure there are no bubbles when the water tank
is full and running. If there are bubbles, turn the unit OFF until the bubbling
stops. When the bubbling has stopped, set the unit to the desired speed.
Problem:
Humidifier not working.
Solution:
1. Make sure the power knob is not set to OFF and the unit is plugged into a
working wall outlet.
Problem:
Mineral build-up on the water tank or water tray.
Solution:
Problem:
Humidity output and water usage decreased.
Solution:
1. Check the power knob to make sure it is set to the desired speed.
2. Check the water tank to make sure there are no bubbles when the water tank
is full and running. If there are bubbles, turn the unit OFF until the bubbling
stops. When the bubbling has stopped, set the unit to the desired speed.
3. Clean any components that have mineral build-up. Refer to the section
8
44062-01 • 06/08/2010
Download from Www.Somanuals.com. All Manuals Search And Download.
Humidifier Assistance
4
Service Parts and Support
Service Parts
Part #
Part Name
Part
Replace
89754-01-326
Water Tank
Tank Assembly
Cap
G0841-01-679
31951
1 per month or
as needed
Wick
99940-01-679
Water Tray
Technical Support
If you need any assistance with setup, operation, or parts for your new Hunter
Humidifier, please call us, our technical support staff is ready to help!
USA: 1-888-830-1326
Canada: 1-866-268-1936
Hours of operation are from 7:00 am to 7:00 pm Monday - Friday and 8:00 am
to 5:00 pm on Saturday, Central Time. You may also contact us over the Internet
at www.hunterfan.com or register your product at www.hunterfan.
com/register and select your product under product registration.
9
©2010 Hunter Fan Company
Download from Www.Somanuals.com. All Manuals Search And Download.
Humidifier Accessories
Treatments
5
Model
Product
evaporative
Ultrasonic
vaporizer
Warm Mist
31955
Silver Ion Cartridge
31954
31961
Demineralization Cartridge
Vapor Steam
31956
31960
Vapor Pads
Water Treatment Tablets
Notes
10
44062-01 • 06/08/2010
Download from Www.Somanuals.com. All Manuals Search And Download.
Warranty
6
3 Year Guarantee
The Hunter Fan Company, Inc. makes the following warranty to the original
residential user or consumer purchaser of the evaporative humidifier:
If any part of the evaporative humidifier fails during the first 3 (three) years from
the date of purchase due to a defect in material or workmanship, we will provide
a replacement part free of charge.
If no replacement part can be provided, we will replace your humidifier.
IF THE ORIGINAL RESIDENTIAL USER OR CONSUMER PURCHASER CEASES
TO OWN THE HUMIDIFIER, THIS WARRANTY AND ANY IMPLIED WARRANTY
WHICH THEN REMAINS IN EFFECT, INCLUDING BUT NOT LIMITED TO ANY
IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR
PURPOSE, ARE VOIDED. THIS WARRANTY IS IN LIEU OF ALL OTHER EXPRESS
WARRANTIES. THE DURATION OF ANY IMPLIED WARRANTY, INCLUDING
BUT NOT LIMITED TO ANY IMPLIED WARRANTY OF MERCHANTABILITY OR
FITNESS FOR A PARTICULAR PURPOSE IS EXPRESSLY LIMITED TO THE PERIOD
OF THE EXPRESS WARRANTY SET FORTH ABOVE.
This warranty is voided if your humidifier is not purchased and used in the USA
or Canada.
This warranty excludes and does not cover defects, malfunctions, or failures of
the humidifier which were caused by repairs by persons not authorized by us,
use of parts, or accessories not authorized by us, mishandling, modifications, or
damage to the humidifier while in your possession, or unreasonable use, including
failure to provide reasonable and necessary maintenance. This warranty does
not cover humidifiers used in commercial applications. There are no express or
implied warranties as to commercial purchasers or users.
To obtain service, contact the nearest Hunter authorized service center or the
Hunter Fan Company Service Department, 7130 Goodlett Farms Pkwy., Suite
400, Memphis, TN 38016, 1-888-830-1326. You will be responsible for
insurance and freight or other transportation to our factory service center. We
will return the Vaporizer freight prepaid to you. The humidifier should be properly
packaged to avoid damage in transit since we will not be responsible for any
such damage. Proof of purchase is required when requesting warranty service.
The purchaser must present the sales receipt or other document that establishes
proof of purchase.
IN NO EVENT SHALL HUNTER FAN COMPANY BE LIABLE FOR DIRECT,
INDIRECT, SPECIAL, CONSEQUENTIAL OR INCIDENTAL DAMAGES IN EXCESS
OF THE PURCHASE PRICE OF THE VAPORIZER. YOUR SOLE REMEDY WILL BE
REPAIR OR REPLACEMENT AS PROVIDED ABOVE. SOME AMERICAN STATES
AND CANADIAN PROVINCES DO NOT ALLOW:
• LIMITATIONS ON HOW LONG AN IMPLIED WARRANTY LASTS;
• THE EXCLUSION OR LIMITATION OF DIRECT, INDIRECT, SPECIAL, INCIDENTAL
OR CONSEQUENTIAL DAMAGES;
• THE EXCLUSION OR INVALIDITY OF EXPRESS OR IMPLIED WARRANTIES IF
THE USER CEASES TO OWN THE HUMIDIFIER;
• THE LIMITATION OF THE REMEDIES AND RECOURSES AVAILABLE TO THE
PURCHASER; OR THE INVALIDITY OF AN EXPRESS WARRANTY WHEN A
PRODUCT IDENTIFIED BY BRAND NAME IS NOT USED (UNLESS SPECIFIC
CONDITIONS ARE FULFILLED);
SO THE ABOVE LIMITATIONS OR EXCLUSIONS MAY NOT APPLY TO YOU.
THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS AND YOU MAY ALSO
HAVE OTHER RIGHTS WHICH VARY FROM STATE TO STATE OR PROVINCE TO
PROVINCE.
Printed in china and Taiwan
11
©2010 Hunter Fan Company
Download from Www.Somanuals.com. All Manuals Search And Download.
|