Exhaust Type Tumble Dryer
User's manual
Model: GDZ5.0-1
Please read this manual carefully before using.
Retain it for future reference.
Download from Www.Somanuals.com. All Manuals Search And Download.
Names Of The Parts
Drum
Door
Exhaust shroud
Air Intake shroud
Timer selector knob
Window
Heat selector knob
Door gasket
Power cord
Casing
Exhaust vent
Back cover
Please check if the power receptacle has good earthing
Condition before using to guarantee your safety.
The manufacturer will not take responsibility for those
Risks occurred from not obeying this manual.
1
Download from Www.Somanuals.com. All Manuals Search And Download.
Important Safety Instructions
Warning-To reduce the risk of fire ,electric shock, or injury to
persons when using your appliance, follow basic precautions,
including the following:
1.Read all instructions before using the appliance.
2.The tumble dryer is not to be used if chemicals have been used for cleaning.
3.The tumble dryer is intended only for drying textile material washed in water.
4.There has to be adequate ventilation to avoid the back flow of gases into the
room from appliances burning other fuels including open fires, when operating
the tumble dryer.
5.The lint trap is to be cleaned frequently.
6.Lint is not to be allowed to accumulate around the tumble dryer.
7.For appliances with ventilation openings in the base, that a carpet must not
obstruct the openings.
8.Exhaust air must not be discharged into a flue which is used for exhausting
fumes from appliances burning gas or other fuels.
9.Do not dry articles that have been previously cleaned in, washed in, socked
in, or spotted with gasoline, dry-cleaning solvents, or other flammable or
explosive substances, as they give off vapors that could ignite or explode.
10.Do not place items exposed to cooking oils in your dryer. Items contaminated
with cooking oils may contribute to a chemical reaction that could cause a
load to catch fire.
11. Fabric softeners or similar products should not be used in a tumble dryer to
eliminate the effects of static electricity unless this practice is specifically
recommended by the manufacturer of the fabric softener or product.
12.Do not use heat to dry articles containing foam rubber or similarly textured
rubber-like materials.
13.Do not allow children to play on, climb on or in the appliance. Close supervision
of children is necessary when the appliance is used near children.
14.Before the appliance is removed from service or discarded, remove the door to
the drying compartment.
15.Keep your dryer away from combustible materials (such as gasoline) during
operation to prevent the risk of fire.
16.Do not use or place stove, gas device, water heater, tinder or similarities close to
your dryer. Do not install or store this appliance where it will be exposed to water
and/or to the weather.
2
Download from Www.Somanuals.com. All Manuals Search And Download.
Important Safety Instructions
17.Do not tamper with controls.
18.Do not repair or replace any part of the appliance or attempt any servicing unless
specifically recommended in the user-maintenance instructions or in published
user-repair instructions that you understand and have skills to carry out.
19.Keep area around the exhaust opening and adjacent surrounding areas free from
the accumulation of lint, dust and dirt.
20.If material has been used with any flammable liquids or solids it should not be
used in the dryer until all traces of the flammable liquids and its fumes have
been removed.
21.This dryer shall be connected to a three-wire, single phase, 230V AC
power receptacle more than 10A, which must be reliably grounded. A leakage
protector shall be used, if possible.
22.Do not share a receptacle with other appliances. Do not use it when a plug
loosely inserted into a receptacle.
23.Do not excessively bend, stretch, twist, bind power cord or put heavy stuff on
it. Keep the terminator of power cord clean. Carefully clean it with dry cloth if
dusts accumulated. If damaged, power cord or plug must be replaced by our
service agent or qualified after-sale service person to avoid the risk of danger.
24.When normally using, the power cord of dryer shall be easily plugged or
unplugged by hand. It must be unplugged during power blackout, moving, not
in use or cleaning. Do not plug or unplug the power cord with wet hands.
25.Always disconnect dryer from electrical supply before attempting any service.
Disconnect power cord by grasping the plug, not the cord.
26.Do not block the exhaust vent when dryer operating to prevent it from
overheating or other dangers.
27.Do not let your dryer operate on packing foam. Otherwise it maybe cause fire
since heat accumulation or other external factors.
28.Only place sufficiently dehydrated clothes into your dryer for drying to prevent
leakage and longer drying time.
29.Do not place washed wet clothes in your dryer for a long time not drying them
(which may result in water leakage).
30.Don't touch the intake for the high temperature during the drying cycle.
31.Do not exceed dryer rated Max. Capacity.
32.The appliance must not be installed behind a lockable door, a sliding door
or a door with a hinge on the opposite side to that of the tumble dryer.
3
Download from Www.Somanuals.com. All Manuals Search And Download.
Operation Cautions
Avoid to dry starched clothes in
your dryer to prevent link filter
from clogging, which may lead
to bad exhaust performance.
Clothes with ribbon or lace
should be dried in a nylon net
Put chemical fiber and/or clothes
with ribbon or lace
into a nylon net
before drying.
Put rumpled clothes in order
Put all clothes in order after
dehydrated
Clothes with zipper
Dry this kindof clothes with zipper
zipped or fastener
buckled and inside
before drying
them.
out (to reducethe
impact noise between
metal and the drum)
Anti-wrinkle method for clothes
crumpled easily
Decrease capacity to get good anti-
wrinkle result (the capacity shall be
4/5 of that of normal clothes).
Do not load your dryer when
it is running.
Loading the dryer when it is running
shall be avoided
to prevent the
Capacity reduced
clothes over dried
or incompletely
dried.
•
Remove the clothes out of your dryer
as early as possible
to reduce rumples.
Please flip clothes over manually
from time to time, if necessary,
when drying large ones.
It is not easy to flip over large clothes
(such as overcoat) in the drum, uneven
drying therefore happens sometimes.
If necessary, flip them over manually
from time to time to make them dried
completely.
Please hang the easily crumpled clothes
up with a hanger after dried
Flip over clothes
4
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation Instructions
For your safety and correct using your dryer, please observe all the instructions
in this manual toinstall and adjust your dryer.
Location of your dryer
Dryer should be located in a dry and well-vented place, not filled with moisture and
vapors and where rain cannot reach (like bathroom,open balcony and water faucet).
Do not locate your dryer in a place where sunlight directly shines.
Do not use stove, gas etc. near your dryer to avoid dangers.
Locate your dryer on horizontal solid ground, floor or a
special bracket to prevent vibration and noise. Keep a dista
nce of 10cm-15cm away from the rear wall when installing.
The dryer has air intake and exhaust cycles,which
(10-15)cm
needs good air-exhaust vent in the rear and well-vented
room. If used in a small space, air exchange fan or
exhaust duct can be installed at the vent to exhaust
hot wet air outdoors.
The length of exhaust duct shall not exceed 2m.
Install and use the fixed legs of your dryer
Leg
If the dryer is not used with bracket, take fixed
legs out of the accessory bag and screw them
into the assembly hole of the dryer to ensure
it be placed stable.
Soft items
5
Download from Www.Somanuals.com. All Manuals Search And Download.
Wall Mounting Instructions
1. Determine the location of the dryer on the wall
and mark the bracket position.
2. Fix the wall hanging brackets(2 supplied) to the
wall securely (eg. into the stud.) Fit a timber slat
between the studs to mount the brackets onto
If the stud position is too wide. The distance
between each bracket is 155mm as per diagram.
* A minimum 50mm is needed between the top of
the dryer and the ceiling for ease of installation.
* If mounting above a washing machine, allow s
ufficient room to open the lid of the washer.
Tools reequired
Drill & 3mm Bit
Philips Head Screw
Driver
Expansile Screws,M5X
50mm
Tools &parts
required
for Plaster/
wooden wall
Helper to lift dryer
onto wall
Wall Mounting Kit Includes
Description
Wall Hanging Brackets
Hanging hook
Plastic Spacers
Exhaust pipe
6
Download from Www.Somanuals.com. All Manuals Search And Download.
Wall Mounting Instructions
3. To install the hook to the dryer, remove
screws 1, 2, 3 & 4 as indicated in Fig. 2.
4. Align bracket as shown in Fig. 3 and fasten
screws tightly.
5. Remove lower side screws and install the
spacers provided as per Fig. 2.
6. Install exhaust duct: for upwards discharge, join
sections 1 and 3, for downwards discharge, join
sections 1, 2, 2 & 3 as per Fig. 4.
7. With assistance, mount dryer on wall brackets.
See Fig. 5.
7
Download from Www.Somanuals.com. All Manuals Search And Download.
Using Method
1. Plug the power cord
The appliance shall be supplied with230V,50Hz,
connected to a special receptacle more than
10A (reliably grounded).
2. Place the dehydrated clothes in your dryer
Check the following items before putting clothes in.
They shall be loaded in such a way that 2-3 pieces
each time and not in a group to avoid tangling, which
is not easy to turn it over resulting in uneven drying
since the clothes were wrapped.
Please put clothes into the drum. Avoid clothes being
pressed by the door due to exposure out of the port,
which will cause clothes entangle and door gasket
release and consequently poor drying effect.
Before drying your clothes
Make sure if clothes have any special requirements and suitable for drying.
Do not dry your clothes in your dryer if the materials of which cannot be dried
in a dryer or they bear the following labels:
Hang tto dry
Do not tuumble dry
Drip dry
Dry flat
Dry in the shhaaddee
Carefully check the clothes to be dried and remove combustible
material such as lighter and match as well as sharp metal items
like coin, hair clip and safety pin maybe mixed with the clothes
and in pockets.
Clothes with zipper or fastener shall be put into your dryer inside
out with zipper zipped and fastener buckled.
Separate dark and light colored items, like you do for washing.
Check for stains that may not have been removed in washing.
Dryer heat may permanently set some stains. Properly dried clothes
will need minimum of care when removed from dryer.
For optimum results,use dryer load of similar fabric, weight and construction. Place
small items in a mesh bag prevent from tangling.Do not overload the dryer. An
average load will fill up half the drum.
8
Download from Www.Somanuals.com. All Manuals Search And Download.
3. Control panel and its functions
Heat Selector Knob
Select drying level according to the material, quantity and drying
requirements of the clothes to be dried as shown in the figure
Select ' Strong Dry' for clothes particularly thick and in large
quantities or in lower room temperature.
Soft
Select ' Soft Dry ' for clothes not resistant to heat (like nylon
and chemical fibre ).
Strong
Heat Selector Knob
Drying Timer Knob
Select dry program according to clothes materials and quantity, turn the timer knob to
relative position.
Air drying
OFF
Cooling
For down, sweater,
mohair, cotton sweater
and cotton-padded
clothes needing
freshening, tumbles
without heat. Also can
be individually used for
clothes long time in
closet with the
Power off whenthe
timer knob in
'OFF' position.
The dryer starts
when turn theknob
clockwise.
Motor keeps runningafter dryer time
heating finished whileheater stops
working and coldair into thedrum to
cool laundry.The whole coolingwill
be finished oncethe timer knobgets
to ‘OFF 'position.
OFF
0
Cooling
same results.
Heating
For clothes resistantto heat,
(Check the labelon the article
60
20
40
40
OFF
to be dried, to make sureit
can be safely tumble dried) ,
the heater is working.
20
Power off whenthe
timer knob in
'OFF' position.
The dryer starts
when turn theknob
clockwise.
60
80
0
OFF
According to clothes
materials and quantity, turn
the timer knobto relative
position. Select 'Strong Dry'
for clothes particularlythick
and in largequantities.Refer to
'Dry Time ReferenceTable'.
220
100
120
200
140
180
160
DryTimeReferenceTable
Approx.5.0kg
Approx.200min
Approx.1kg
Strong Approx.50min Approx.90min
Soft
Approx.90min Approx.150min
Approx.2kg
Approx.3.5kg
Dry Capacity
Approx.160min
Dry time
Suggest use 'strong'
Suggest use 'strong'
Dry time affected by many factors, such as material, weight, thickness and the hydrated
ratio of clothes , the above listed dry time is only for reference.
9
Download from Www.Somanuals.com. All Manuals Search And Download.
4. Set ' heat selector knob' to select 'Strong
dry' or 'Soft dry' level.
'Strong dry ' level for large quantity and low room temperature.
Soft
Strong
'Soft dry' for non heat-resistant clothes.
Heat selector knob
Do not point the
cursor to blank.
5. Dry time settings
OFF
0
Select dry program according to clothes materials and
quantity, turn the timer knob to relative position. The
dryer starts running.
Cooling
60
20
40
40
20
Caution: Dry timing knob cursor
shouldn't be set at the blank area,
as indicated in the right figure.
60
80
0
OFF
Do not
point the
cursor to
blank
220
100
120
200
140
180
160
6. Do not take the laundry out until drying process is done
The last 20 minutes of hot air drying is cooling
to reduce the temperature of laundry inside
the drum.
To take the laundry out during drying, please
run cooling operation first since the temperature
inside the drum must be high.
Static electricity, due to friction, will be
generated on clothes made of chemical fibre
after dried. You can feel it when taking them out,
which is normal and shall not to be worried about.
7. Unplug the power cord
Please hold plug to unplug power cord from
a receptacle. Do not pull electrical wire directly
to prevent internal breakage or bad connection.
8. Clean filters
Clean the lint filter after every load and before each use. A clean filter ensures
sufficient drying. A layer of lint on the filter reduces airflow through the clothes
and prolongs drying time
Refer to the instructions on page 11.
10
Download from Www.Somanuals.com. All Manuals Search And Download.
Care And Cleaning
Clean the buildup such as lints on filters in time after each use, otherwise it will affect
the performance of your dryer.
Please unplug the power cord first when cleaning it.
Cleaning of filters
The lint filter must be used for drying.
It must be cleaned in time befor and after each use.
The filter fixed in the
bottom of the drum
1. Remove the filters
Remove by pulling straight up with hands inserted
into the four holes around the exhaust vent shroud
in the sequence of
- Exhaust filter , as shown in figure 1.
2. Clean the lints
Separate exhaust vent shroud
filter and clean the lints on the filter and exhaust filter
'Exhaust vent shroud - Lint filter
'
Lint
filter
Exhaust
Filter
Exhaust
vent shroud
Figure 1
'
',
'
lint filter
'
and 'exhaust
'
with a soft brush or vacuum cleaner. Can also clean the
filters with water.
Do not damage the filters (as shown in figure 2)
Lint Filter
Lints
Exhaust Filter
Dust Cleaner
Figure 2
3. Install the filters
After cleaning, assemble in the sequence of 'exhaust filter
-filter-exhaust vent shroud',align the recesses in the center
of filter with the projection in the center of drum and make
sure that it is firmly inserted (as shown in figure 3).
Note: The filter fixed in the bottom of the drum shall also
be cleaned with a soft brush.
Figure 3
DO NOT USE YOUR DRYER WITHOUT THE LINT FILTER.
Clean the interiordrum or dryer
housing, with wetsoft cloth, ifstained.
Do not wash directly with water.
Do not use thinner, gasolene or alcohol.
Do not use any type of spray cleaner when
cleaning the interior. Hazardous fumes or electric
shock could occur. If dryer drum becomes stained,
clean the drum with a damp cloth. Remove any
residue before drying the next load.
Clean cabinet with mild soap and water. Donot use
harsh or abrasive cleaners, this could damage the
dryer.
11
Download from Www.Somanuals.com. All Manuals Search And Download.
Trouble Shooting
(If your dryer exhibits problems, please unplug the power cord before checking) The following maybe
unrelated to a malfunction of the dryer itself, please reconfirm before calling a serviceman. If it does
relate to a malfunction, please contact our service agent or after-sales service and do not repair it
by yourself.
Problem
Possible Cause
What to do
Insert the powercord firmly
Timer knob does not Is the powercord inserted
firmly?
turn
Drum does not turn Is the doorclosed?
Is the powercord inserted?
Close the door.
Insert the powercord firmly.
Check the power cord receptacle.
Does the receptaclehave
power?
Set to hotair
No hot air blown
out
Is the timerincorrectly
set up incold air?
Clean the filter.
The laundry is not
throughly dried
(some of the clothes
still wet after dryer
stops)
Is the back filter
clogged?
Dehydrate the laundry
completely.
Have the clothes
been fully dehydrated?
Reduce the laundryquantity.
Dry the undried laundry again.
Is the laundrytoo much?
Have the dryer have been
added during operation?
Loose the twisted laundry and
dry again.
Does the laundry twist?
Dry the undried laundry again.
Have any clothes dry easily and
hardly been dried together?
Place the dryer in a well-vented
place.
Is the dryer placed in a small
and badly-vented space?
Try again after power recovered
Is power failure?
Insert the power cord firmly
Is the power cord inserted
firmly?
Dryer does not start
Close the door
Set dry time
Is the doorclosed?
Is the timer in OFF position?
12
Download from Www.Somanuals.com. All Manuals Search And Download.
Packing Notes
Location
Designation
Quantity
One
User's Manual
Legs of the dryer
File packet
Accessory bag
Four
Wall mounting kit
One
One
Exhaust type tumble dryer
Electrical Safety Tips
Please be careful when using your dryer since this product is class appliance.
1.Reliably grounded power supply must be used with the earth wire buried
underground. Do not connect with public utilities such as water pipe.
Separate earth wire from zero line and do not connect them together.
2. An individual special receptacle must be used, which shall be a product
have been qualified by national compulsive product certification.
For your and your family's safety, please improve as soon as possible if any
discrepancies with the above-mentioned requirements existed.
13
Download from Www.Somanuals.com. All Manuals Search And Download.
Specification
Model
GDZ5.0-1
Rated Voltage Frequency
Rated Input Power
~
230V
50Hz
Extra 1070W
Light 700W
10A
Rated Fuse Current
Rated Max. Capacity
Overall Dimension
Net Weight
5.0kg
630mm 515mm 685mm
26.5kg
the first edition
Parts Code:0030801264
VC 532236
Download from Www.Somanuals.com. All Manuals Search And Download.
|