®
GARDENA
3 l
Art. 867
5 l
Art. 869
5 l
Art. 875
5 l
Art. 879/880
D
Gebrauchsanweisung
Drucksprüher
GB Operating Instructions
Pressure Sprayer
F
Mode d’emploi
Pulvérisateur à pression préalable / Pulvérisateur
NL Gebruiksaanwijzing
Drukspuit
S
I
Bruksanvisning
Tryckspruta
Istruzioni per l’uso
Irroratore a pressione
E
P
Manual de instrucciones
Pulverizador a presión
Instruções de utilização
Pulverizador de Pressão
DK Brugsanvisning
Tryksprøjte
Download from Www.Somanuals.com. All Manuals Search And Download.
2. For Your Safety
V Never open the Pressure Sprayer or unscrew the nozzle
Danger of
physical injuries:
when the Pressure Sprayer is still pressurised.
V To prevent injury, never connect the Pressure Sprayer
to an air-compressor.
V Before pulling out the safety valve, the sprayer always
has to be placed vertically.
V Before opening the sprayer, always release pressure
completely by pulling out the safety valve.
V Release the pressure after each use (ensuring that the
Pressure Sprayer is always vertical), empty the container,
clean it carefully and rinse with clear water. Then leave
the pressure sprayer open and allow it to dry.
Cleaning:
Do not dispose of residual fluids in the sewerage system
(v local disposal systems).
v Always clean the Pressure Sprayer before using a different
product to avoid chemical reactions.
For cleaning the valves, the spray pipe and nozzle, operate the
unit with clear water (if necessary, by adding some washing-up
liquid).
v To prevent reactions with the products you are using, never
use aggressive cleaning agents that contain solvent or
petrol.
v When there is dirt on the container cap or the container,
clean the container carefully around the thread and the
thread O-ring.
Take care not to mix up the tanks and tank caps if you are
using several Pressure Sprayers at the same time.
v Inspect the Pressure Sprayer visually before each use.
Operation:
Never leave your Pressure Sprayer unattended or for long
periods when full and pressurised.
v Keep the unit out of the reach of children.
You are responsible for the safety of others.
v Operate the safety valve only when the sprayer is placed
vertically.
v Keep your Pressure Sprayer away from heat sources and
hot environments.
We recommend that you have your Pressure Sprayer thoroughly
inspected (preferably at a GARDENA Service Centre) after
using it for 5 years.
Before storing, loosen the tank cap and always empty your
Pressure Sprayer completely (also after cleaning with water).
Store away from frost.
Storage:
v If you use the permanent lock pay attention that you work
very carefully. Never store your pressure sprayer with
permanent lock.
11
Download from Www.Somanuals.com. All Manuals Search And Download.
3. Assembly
3.1. General Assembly Instructions for all Pressure Sprayers
(Art. No. 867/869/ 875/ 879/ 880)
Mounting the spray tube
in the hand valve:
1. Unscrew the union nut
on the hand valve
.
2
1
2. Push the spray tube
all the way into the hand valve
.
2
3
2
3. Tighten the union nut
(do not use pliers).
on the hand valve
by hand
Art. 880
1
2
The sprayer tube of art. 880 is telescopic (min. / max. sprayer
tube length 60/100 mm).
1
3
Attaching the spray hose
to the hand valve:
1. Push the long union nut
over the spray hose
.
5
4
2. Push the spray hose
with connection nipple
into the
5
6
hand valve
.
2
2 6 4 5
3. Tighten the long union nut
(do not use pliers).
on the hand valve
by hand
4
2
3.2. Assembly Instructions for Pressure Sprayer Art. No. 869
1. Shut the filter
and press firmly
Installing the filter
and suction pipe:
7
into the suction pipe
.
8
8
2. Guide the suction pipe
through
9
8
9
8
the eyelet at the pump tube
and press firmly into the opening in
the container cap.
7
1. Push the short union nut
over the spray hose
.
5
Attaching the spray hose
to the container cap:
0
2. Push on the spray hose
beginning of the thread
so that it covers at least the
5
.
A
5
0
3. Screw the short union nut
onto the container cap
0
B
and tighten by hand (do not use pliers).
A
B
1. Unscrew the screw
using a screwdriver and remove the
Attaching the shoulder strap:
C
.
spray tube holder
D
2. Put the shoulder strap
with the elongated hole over the
E
C
E
plastic tube
.
F
3. Reattach the spray tube holder
using a screwdriver.
and screw in the screw
D
C
D
1.
2.
F
12
Download from Www.Somanuals.com. All Manuals Search And Download.
3.3. Assembly Instructions for Pressure Sprayer Art. No. 875 /879/ 880
Attaching the spray hose
to the container cap:
1. Push the short union nut
over the spray hose
.
5
G
2. Push on the spray hose
beginning of the thread
so that it covers at least the
5
.
H
G H
I
3. Screw the short union nut
onto the container cap
G
I
and tighten by hand (do not use pliers).
5
Attaching the shoulder strap:
1. Remove the spray tube holder
the arrow).
from above (direction of
J
K
2. Guide the shoulder strap
through the elongated hole
and attach it into the holder
K
J
of the spray tube holder
of the container.
J
L
L
3. Press the spray tube holder back on until you hear it click
into place.
4. Attach the shoulder strap on the other side of the holder
.
L
L
4. Operation
4.1. Operating Instructions for Pressure Sprayer Art. No. 867/869
1. Mix the fluid well.
Filling the container:
2. Unscrew the container cap
.
B
N
3. Pour the fluid into the container up to the maximum mark
(3 litres or 5 litres).
Please observe the safety and proportioning instructions provid-
ed by the manufacturer of the product you are going to spray.
O
4. Screw the container cap
(do not use pliers).
back on and tighten by hand
B
A Risk of injury!
V Never connect your Pressure Sprayer to an air
compressor.
B
5. Pull the pump lever
repeatedly (approx. 30 to 40 times)
N
until the operating pressure has been reached.
Any excess pressure escapes through the safety valve
.
O
13
Download from Www.Somanuals.com. All Manuals Search And Download.
4.2. Operating Instructions for Pressure Sprayer Art. No. 875/ 879/ 880
Filling the container:
1. Mix the fluid well.
2. Press the pump handle
down slightly, turn to the left and
P
remove the pump
.
Q
3. Pour the fluid into the container up to the maximum mark
(5 litres).
P
R
Q
Please observe the safety and proportioning instructions
provided by the manufacturer of the product you are going
to spray.
4. Tighten the pump again with the pump handle
(do not use pliers).
by hand
P
A Risk of injury!
V Never connect your Pressure Sprayer to an air
compressor.
5. Unlock the pump handle
by turning slightly to the left and
P
pump the pump repeatedly (approx. 30-40 times) until the
operating pressure is reached.
Any excess pressure escapes through the safety valve
.
R
The Pressure Sprayer Art. No. 879/880 features a window with
a scale to help you measure out the appropriate dosage of
S
fertilisers. The window also allows you to see how much fluid is
left in the container.
S
4.3. General Operating Instructions for all Pressure Sprayers
(Art. No. 867/869/ 875 /879/ 880)
1. Press the operating switch
on the handle.
Spraying:
T
The Pressure Sprayer begins spraying.
U
T
2. Release the operating switch on the handle.
T
The Pressure Sprayer stops spraying.
Setting the permanent lock:
v Press the permanent lock
.
U
The operating switch
is pressed down and stays down.
T
The spray tube can be swivelled 360° in the hand valve.
Adjusting the spray tube:
1. Unscrew the union nut
on the hand valve
.
2
1
3
1
2
2. Turn the spray tube
to the correct position.
3
3. Tighten the union nut
(do not use pliers).
on the hand valve
by hand
1
2
You can adjust the spray jet from full jet (nozzle closed) to a fine
mist spray (nozzle open).
Setting the spray jet:
V
v Open or close the spray nozzle
according to the spray jet
V
you require.
14
Download from Www.Somanuals.com. All Manuals Search And Download.
5. Cleaning
Always clean your Pressure Sprayer after spraying.
v Fill the Pressure Sprayer with clean water (the water may
contain some washing-up liquid if necessary) and empty out
the water by spraying it through the spray tube in the same
way as when spraying a product.
Cleaning the Pressure
Sprayer:
This cleans the valves, the spray tube and the nozzles.
We recommend that you have your Pressure Sprayer thoroughly
inspected (preferably at a GARDENA Service Centre) after
using it for 5 years.
6. Trouble-Shooting
If the spray jet from the Pressure Sprayer is very weak you
should clean the filter in the container.
Cleaning the filter:
Pressure Sprayer Art. No. 867/869
1. Unscrew the container cap.
2. Flip up the filter
and rinse under running water.
7
7
3. Close the filter
and screw the container cap back on.
7
3
Pressure Sprayer Art. No. 875 /879/880
Remove the filter
from the spray tube
and clean it.
W
3
W
Problem
Possible Cause
Remedy
Pump does not build up
pressure.
Container cap is not airtight.
v Fasten the container cap
as tight as it will go
(Art. 867/ 869).
Safety valve is loose.
v Tighten the safety valve.
Hose connection at the container v Tighten the hose connec-
and hand valve is not tight.
tions at the container and
hand valve.
Continuous lock enabled on
handle.
v Take off the permanent lock
at the hand valve.
Pressure Sprayer does not
spray although there is
sufficient pressure or only
sprays with a weak spray jet.
Nozzle is blocked.
Filter is blocked.
v Clean the nozzle.
v Clean the filter in the
container (Art. 867/869).
Clean the filter in the spray
tube (Art. 875/ 879/ 880).
It is difficult to open and
close the container.
Container pressure too high.
v Release the container pres-
sure completely by means
of the safety valve.
Grease the container O-ring
with acid-free grease
(Art. 867/869).
If you have any other problems with your Pressure Sprayer please contact GARDENA Customer
Service.
15
Download from Www.Somanuals.com. All Manuals Search And Download.
7. Storage
1. Clean the Pressure Sprayer (refer to 5. Cleaning).
Storing your
Pressure Sprayer:
2. Keep your Pressure Sprayer in a place protected from frost.
8. Accessories
GARDENA Weedkiller Cone
Prevents spray mist from
blowing away.
Art. No. 894
GARDENA Extension Lance
GARDENA Telescopic Tube
For extending the spray tube.
Art. No. 897
Art. No. 899
Telescopic extension for
the spray tube
9. Technical data
Art. No. 867
Art. No. 869 / 875 / 879 Art. No. 880
Max. capacity
Spray tube length
Hose length
3 l (5 pints approx.) 5 l (8 pints approx.)
5 l (8 pints approx.)
60/100 cm
150 cm
36 cm
36 cm
150 cm
3 bar
150 cm
Permissible working pressure 3 bar
3 bar
Permissible operating
temperature
40°C
40°C
40°C
10. Service
Warranty
GARDENA guarantees this product for 2 years (from date of
purchase). This guarantee covers all serious defects of the unit
that can be proved to be material or manufacturing faults. Under
warranty we will either replace the unit or repair it free of charge
if the following conditions apply:
• The unit must have been handled properly and in keeping with
the requirements of the operating instructions.
• Neither the purchaser or a non-authorised third party have
attempted to repair the unit.
This manufacturer’s guarantee does not affect the user’s existing
warranty claims against the dealer/seller.
If you have any problems with your Pressure Sprayer, please
contact our Customer Service or return the defective unit to-
gether with a short description of the problem directly to one of
the GARDENA Service Centres listed on the back of this leaflet.
Product Liability
We expressly point out that, in accordance with the product
liability law, we are not liable for any damage caused by our units
if it is due to improper repair or if parts exchanged are not original
GARDENA parts or parts approved by us, and, if the repairs were
not carried out by a GARDENA Service Centre or an authorised
specialist. The same applies to spare parts and accessories.
16
Download from Www.Somanuals.com. All Manuals Search And Download.
Deutschland / Germany
GARDENA
Manufacturing GmbH
Service Center
Hans-Lorenser-Straße 40
D-89079 Ulm
Produktfragen:
Croatia
Italy
Singapore
KLIS d.o.o.
GARDENA Italia S.p.A.
Via Donizetti 22
Hy - Ray PRIVATE LIMITED
40 Jalan Pemimpin
#02-08 Tat Ann Building
Singapore 577185
Stanciceva 79
10419 Vukovina
Phone: (+385) 1 6227770
20020 Lainate (Mi)
Phone: (+39) 02.93.94.79.1
gardena klis-trgovina.hr
info gardenaitalia.it
Phone: (+65) 6253 2277
@
@
hyray singnet.com.sg
@
Cyprus
FARMOKIPIKI LTD
P.O. Box 7098
74, Digeni Akrita Ave.
1641 Nicosia
Phone: (+357) 22754762
condam spidernet.com.cy
Japan
(+49) 731 490-123
Reparaturen:
KAKUICHI Co. Ltd.
Sumitomo Realty &
Development Kojimachi
BLDG., 8F
Slovak Republic
GARDENA Slovensko, s.r.o.
Panónska cesta 17
(+49) 731 490-290
service gardena.com
@
85104 Bratislava
5-1 Nibanncyo, Chiyoda-ku
Tokyo 102-0084
Phone: (+81) 33 264 4721
m_ishihara kaku-ichi.co.jp
Argentina
Phone: (+421) 263453722
Argensem® S.A.
@
info gardena.sk
@
Calle Colonia Japonesa s/n
(1625) Loma Verde
Czech Republic
Slovenia
@
GARDENA spol. s r.o.
Шнpskб 20a, и.p. 1153
627 00 Brno
Silk d.o.o.
Escobar, Buenos Aires
Phone: (+54) 3488494040
Luxembourg
Brodiљиe 15
Magasins Jules Neuberg
Grand Rue 30
1236 Trzin
info argensem.com.ar
@
Phone: (+420) 800 100 425
gardena gardenabrno.cz
Phone: (+386) 1 5809300
Boîte postale 12
@
Australia
gardena silk.si
@
L-2010 Luxembourg
Phone: (+352) 401401
Nylex Consumer Products
50-70 Stanley Drive
Somerton, Victoria, 3062
Phone: (+61) 1800 658 276
Denmark
South Africa
GARDENA
South Africa (Pty.) Ltd.
P.O. Box 11534
GARDENA Norden AB
Salgsafdeling Danmark
Box 9003
info neuberg.lu
@
Netherlands
GARDENA Nederland B.V.
Postbus 50176
spare.parts nylex.com.au
@
S-200 39 Malmö
Vorna Valley 1686
Phone: (+27) 11 315 02 23
info gardena.dk
@
Austria / Österreich
GARDENA
1305 AD ALMERE
Phone: (+31) 36 5210000
sales gardena.co.za
@
Finland
Habitec Oy
Martinkyläntie 52
01720 Vantaa
Österreich Ges.m.b.H.
Stettnerweg 11-15
2100 Korneuburg
Spain
info gardena.nl
@
GARDENA IBÉRICA S.L.U.
C/ Basauri, nº 6
La Florida
Neth. Antilles
Tel.: (+43) 2262 7454536
Jonka Enterprises N.V.
Sta. Rosa Weg 196
P.O. Box 8200
France
GARDENA
PARIS NORD 2
69, rue de la Belle Etoile
BP 57080
ROISSY EN FRANCE
95948 ROISSY CDG CEDEX New Zealand
Tél. (+33) 0826101455
service.consommateurs
gardena.fr
kundendienst gardena.at
@
28023 Madrid
Belgium
Phone: (+34) 91 7080500
Curaçao
GARDENA Belgium NV/SA
Sterrebeekstraat 163
1930 Zaventem
atencioncliente gardena.es
@
Phone: (+599) 9 7676655
Sweden
pgm jonka.com
@
GARDENA Norden AB
Försäljningskontor Sverige
Box 9003
Phone: (+32) 2 7209212
Mail: info gardena.be
@
NYLEX New Zealand Limited
Building 2, 118 Savill Drive
Mangere, Auckland
Phone: (+64) 9 2701806
lena.chapman nylex.com.au
@
Brazil
Palash Comércio e
Importação Ltda.
20039 Malmö
info gardena.se
@
Great Britain
Switzerland / Schweiz
GARDENA (Schweiz) AG
Bitziberg 1
@
Rua Américo Brasiliense,
2414 - Chácara Sto Antonio
São Paulo - SP - Brasil -
CEP 04715-005
GARDENA UK Ltd.
27-28 Brenkley Way
Blezard Business Park
Seaton Burn
Norway
GARDENA Norden AB
Salgskontor Norge
Karihaugveien 89
1086 Oslo
8184 Bachenbülach
Phone: (+41) 848 800 464
Phone: (+55) 11 5181-0909
Newcastle upon Tyne
NE13 6DS
info gardena.ch
@
eduardo palash.com.br
@
Turkey
info gardena.co.uk
info gardena.no
@
@
Bulgaria
DENEX LTD.
GARDENA / Dost Diþ Ticaret
Mümessillik A.Þ. Sanayi
Çad. Adil Sokak No.1
Kartal - Ýstanbul
Greece
Agrokip
Psomadopoulos S.A.
Ifaistou 33A
Poland
2 Luis Ahalier Str. - 7th floor
Sofia 1404
GARDENA Polska Sp. z o.o.
Szymanów 9 d
Phone: (+359) 2 9581821
05-532 Baniocha
Phone: (+90) 216 3893939
office denex-bg.com
@
Industrial Area Koropi
194 00 Athens Greece
V.A.T. EL093474846
Phone: (+48) 2272756 90
info gardena-dost.com.tr
@
gardena gardena.pl
@
Canada
Ukraine / Украина
ALTSEST JSC
4 Petropavlivska Street
Petropavlivska
GARDENA Canada Ltd.
100 Summerlea Road
Brampton, Ontario L6T 4X3
Phone: (+1) 9057929330
Portugal
Phone: (+30) 210 6620225
GARDENA Portugal Lda.
Recta da Granja do Marquês
Edif. GARDENA Algueirão
2725-596 Mem Martins
Phone: (+351) 21 922 85 30
service agrokip.gr
@
Hungary
GARDENA
Borschahivka Town
Kyivo Svyatoshyn Region
08130, Ukraine
info gardenacanada.com
@
Magyarország Kft.
Késmárk utca 22
1158 Budapest
Phone: (+36) 80204033
Chile
info gardena.pt
@
Antonio Martinic y Cia Ltda.
Cassillas 272
Phone: (+380) 44 4595703
upyr altsest.kiev.ua
Romania
@
Centro de Cassillas
Santiago de Chile
Phone: (+56) 2 2010708
MADEX INTERNATIONAL SRL
Soseaua Odaii 117-123,
Sector 1,
USA
Melnor Inc.
gardena gardena.hu
@
Iceland
3085 Shawnee Drive
Winchester, VA 22604
Phone: (+1) 540 722-9080
garfar_cl yahoo.com
@
Ó. Johnson & Kaaber
Tunguhalsi 1
Bucureєti, RO 013603
Phone: (+40) 21 352 76 03
madex ines.ro
Costa Rica
Compania Exim
Euroiberoamericana S.A.
Los Colegios, Moravia,
200 metros al Sur del Colegio Michael McLoughlin & Sons
110 Reykjavik
@
service_us melnor.com
@
ooj ojk.is
@
Russia / Россия
АО АМИДА ТТЦ
ул. Моcфилмовcкая 66
117330 Моcква
Phone: (+7) 095 9569900
amida col.ru
879-20.960.05/0706
Ireland
GARDENA
©
Manufacturing GmbH
D-89070 Ulm
Saint Francis - San José
Phone: (+506) 297 6883
Hardware Limited
Long Mile Road
Dublin 12
http://www.gardena.com
exim_euro racsa.co.cr
@
@
72
Download from Www.Somanuals.com. All Manuals Search And Download.
|