INSTALLATION INSTRUCTIONS FOR
UNDER HEARTH WOOD NOOK
FIREPLACE ACCESSORY
MODELS DHS-36, DHS-42, DHS-50, DHS-36I, DHS-42I AND DHS-50I
WARNING: Improper installation, adjustment, alteration, service
or maintenance can cause injury or property damage. Refer to these
instructions for correct installation procedures. For assistance or
additional information consult a qualified installer and/or service
agency.
WARNING: This is not a fireplace. It is not intended for burning
wood.
Thisappliancemaybeinstalledinanaftermarket*,permanetlylocated,
manufactured (mobile) home, where not prohibited by local codes.
*Aftermarket: Completion of sale, not for purpose of resale from manufacturer
Save this manual for future reference
Download from Www.Somanuals.com. All Manuals Search And Download.
BRICK INSTALLATION
IMPORTANT: Installation of brick should Eachbrickhousingisstampedwithaletter(full
be done before wood nook is placed in a size bricks are not stamped). These will help
permanent location. Top panel and front face identify brick when installing. It is important
must be removed prior to installing bricks to install these bricks exactly as instructed.
(see Figure 2). Bricks are packaged in three Installbricksonesectionatatimestartingwith
separate boxes. These boxes are labeled by hearth (bottom) panel followed by rear panel
sections of firebox.
and lastly sides panel (see Figure 3, Figure
4, page 4, or Figure 5, page 5, depending on
your model). It is important to install bricks in
this sequence.
Press Brick firmly into brick housing until it
snaps. Groove line on side of brick will come
in contact with flange on brick housing. This
secures brick into housing (see Figure 3).
HDS-36
Box # 1 - Left and Right Panel
Box # 2 - Bottom Panel
Box # 5 - Rear Panel
DHS-42
Box # 1 - Left and Right Panel
Box # 3 - Bottom Panel
Box # 6 - Rear Panel
DHS-50
Stamped Letter
Brick
Location
Box # 1 - Left and Right Panel
Box # 4 - Bottom Panel
Box # 7 - Rear Panel
Flanges
Top Panel
Brick
Housing
Figure 3 - Installing Brick into Housing
Front Face
Figure 2 - Panel and Front Face Removal
120114-01C
3
Download from Www.Somanuals.com. All Manuals Search And Download.
BRICK INSTALLATION
Continued
F057 FULL
FULL
FULL F057
FULL
FULL
FULL
FULL
F057
F057
FULL
FULL
FULL
REAR
F058
F057
F057
F058
FULL
FULL
F057
F057
FULL
FULL
FULL
FULL
LEFT
RIGHT
F057
F057
FULL
FULL
FULL
FULL
FULL
FULL
FULL FULL
FULL FULL
FULL
FULL
F057
F057
FULL
FULL
FULL
F057 FULL
FULL
FULL F057
FULL
FULL
FULL
FULL
BOTTOM
REAR PANEL
IVORY
LEFT AND RIGHT PANEL
BOTTOM PANEL
RED
FULL
RED
IVORY
RED
FULL
IVORY
QTY
QTY
QTY
19*
4
FULL
FULL
FULL
FULL
10
4
5
(112140-01) (112140-05)
F057R F057W
(112140-01) (112140-05)
(112140-01) (112140-05)
F057R F057W
F057R
F058R
F057W
F058W
3
1
*Includes extra brick
Figure 4 - Brick Placement Chart for DHS-36
4
120114-01C
Download from Www.Somanuals.com. All Manuals Search And Download.
BRICK INSTALLATION
Continued
FULL
FULL FULL
FULL
FULL
FULL
F005
F005
F005
F006
F058
FULL
FULL
F006
F005
FULL
FULL
REAR
F057
F057
F058
FULL
FULL
F057
F057
FULL
FULL
FULL
FULL
LEFT
RIGHT
F057
F057
FULL
FULL
FULL
FULL
F006
F006
F006
FULL
FULL
FULL
FULL FULL
FULL FULL FULL
FULL
FULL
FULL
FULL
FULL
FULL
FULL
F005
F005
F005
F006
F006
FULL
FULL
F005
F006
FULL
BOTTOM
REAR PANEL
IVORY
LEFT AND RIGHT PANEL
BOTTOM PANEL
RED
FULL
RED
IVORY
RED
FULL
IVORY
QTY
QTY
QTY
FULL
FULL
FULL
FULL
10
5
19*
(112140-01) (112140-05)
(112140-01) (112140-05)
(112140-01) (112140-05)
F005R
F006R
F005W
F006W
4
2
F057R
F058R
F057W
F058W
3
1
F005R
F006R
F005W
F006W
4
6
*Includes extra brick
Figure 5 - Brick Placement Chart for DHS-42
120114-01C
5
Download from Www.Somanuals.com. All Manuals Search And Download.
BRICK INSTALLATION
Continued
F004
F004
FULL
FULL
FULL
FULL
FULL
F004
F004
F003
FULL FULL
FULL
FULL
F003
FULL
FULL
FULL
FULL
FULL
REAR
F058
F057
F057
F058
FULL
FULL
FULL
F057
F057
FULL
FULL
FULL
FULL
LEFT
RIGHT
F057
F057
FULL
FULL
FULL
F003
FULL
FULL
FULL FULL
FULL FULL
FULL FULL FULL
FULL
FULL
FULL
FULL
FULL
FULL
FULL
FULL
FULL
F003
F004
F004
F004
FULL
FULL
F003
F003
F004
FULL
FULL
F003
F003
BOTTOM
REAR PANEL
IVORY
LEFT AND RIGHT PANEL
BOTTOM PANEL
RED
FULL
RED
IVORY
RED
FULL
IVORY
QTY
QTY
QTY
FULL
FULL
FULL
FULL
14
5
22*
(112140-01) (112140-05)
(112140-01) (112140-05)
(112140-01) (112140-05)
F003R
F004R
F003W
F004W
2
4
F057R
F058R
F057W
F058W
3
1
F003R
F004R
F003W
F004W
6
4
*Includes extra brick
Figure 6 - Brick Placement Chart for DHS-50
6
120114-01C
Download from Www.Somanuals.com. All Manuals Search And Download.
GROUTING INSTRUCTIONS
Material Provided:
6. Using a trowel, remove excess grout
mixture by moving trowel in the direction
of the joint. Grout mixture in joint should
now be flush with brick surface.
Part No. Description
Qty.
2
117213-01 Bag, Cement 9 pounds
117215-01 Bag, Sand 9 pounds
2
7. Using a joint striker, force grout mixture
into joint an sweep back and forth until
grout is smooth and round. If grout
becomes too shallow add more grout
mixture with piping bag and strike again.
Materials Required:
(Availableatahomeimprovementormasonry
store)
•
•
•
•
Piping (grout) bag
Joints striker
8. Continue procedure around each group
of6bricksuntilanentirepanelisfinished.
Heavy duty mixing bucket
Trowel
9. Using trowel, scrape in direction of joints
to remove any grout that may have col-
ected around bricks during striking. If
desired, take a moist sponge and lightly
sweep over bricks to remove any grout
that may have gotten on the bricks. DO
NOT PRESS HARD OR RUB IN A CIR-
CULAR MOTION. This will press grout
into brick and turn brick a different color.
1. In a heavy duty mixing bucket, pour in
seven (7) cups water then add 4.5 lbs
(half of one bag provided) of sand and
4.5lbsofcement.Mixtogetherwellusing
powerdrillwithmixingwandattachmnet.
2. Theoveralllengthofpipingbagshouldbe
about16''. Ifbagislongerthan16''donot
fill piping bag all the way. This will make
the bag easier to handle. Put 2 to 3 cups
of grout mixture into piping bag making
sure smaller opening is downward and
overamoisttoweltoavoidspilling.Place
a wet towel over bucket making sure it
is directly on surface of grout mixture.
This will keep mixture moist and not dry
out before use.
3. Moisten brick surface with damp sponge
or spray bottle just prior to application.
when bricks are wet, any excess grout
mixture that might have gotten onto the
brick will easily wipe off.
4. Begingroutingbyfirstdoinga''fillerpass''.
This is done by filling the joint about
about 3/4 full with the grout mixture. It
is important to to work with 6 bricks at
a time so that the grout doesn't set up
before striking.
Figure 7 - Grouting
5. Next complete ''finish pass'' around 6
bricks with filler pass. This is done by
slowly filling in remainder of joint with a
thick amount of grout mixture. Mixture
shouldbealittlehigherthanbricksurface.
120114-01C
7
Download from Www.Somanuals.com. All Manuals Search And Download.
WARRANTY
KEEP THIS WARRANTY
Model (located on product or identification tag)_____________________________
Serial No. (located on product or identification tag)__________________________
Date Purchased __________________________
Keep receipt for warranty verification.
Always specify model and serial numbers when communicating with the factory.
The only warranty applicable is our standard written warranty. We make no other warranty,
expressed or implied.
LIMITED WARRANTY
FMIPRODUCTS, LLCwarrantsthisproducttobefreefromdefectsforalifetime, providedthattheproducthasbeen
properlyinstalled, maintainedandoperatedinaccordancewithFMIPRODUCTS, LLC’swarningsandinstructions.
To make a claim under this warranty the bill of sale must be presented.
This warranty is extended only to the original retail purchaser. This warranty covers the cost of part(s) required to
restore this productto proper operating condition and an allowance for labor when provided by a FMIPRODUCTS,
LLCAuthorizedServiceCenteroraproviderapprovedbyFMIPRODUCTS, LLC. Warrantypartsmustbeobtained
through authorized dealers of this product and/or FMI PRODUCTS, LLC who will provide original factory replace-
ment parts. Failure to use original factory replacement parts voids this warranty. This product must be installed by
a qualified installer in accordance with all local codes and instructions furnished with the unit.
This warranty does not apply to parts that are not in original condition because of normal wear and tear, or parts
that fail or become damaged as a result of misuse, accidents, lack of proper maintenance or defects caused by
improper installation. Travel, diagnostic cost, labor, transportation and any and all such other costs related to repair
will be the responsability of the owner.
TO THE FULL EXTENTALLOWED BY THE LAW OF THE JURISDICTION THAT GOVERNS THE SALE
OF THE PRODUCT; THIS EXPRESS WARRANTY EXCLUDES ANY AND ALL OTHER EXPRESSED
WARRANTIES AND LIMITS THE DURATION OF ANY AND ALL IMPLIED WARRANTIES, INCLUD-
ING WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE TO a
lifetime FROM THE DATE OF FIRST PURCHASE;AND FMI PRODUCTS, LLC'S LIABILITY IS HEREBY
LIMITED TO THE PURCHASE PRICE OF THE PRODUCT AND FMI PRODUCTS, LLC SHALL NOT
BE LIABLE FOR ANY OTHER DAMAGES WHATSOEVER INCLUDING INDIRECT, INCIDENTAL OR
CONSEQUENTIAL DAMAGES.
Some states do not allow limitations on how long an implied warranty lasts or the exclusion or limitation of incidental
or consequential damages, so the above limitation or exclusion may not apply to you.
This warranty gives you specific legal rights, and you may also have other rights which vary from state to state.
For information about this warranty contact:
2701 S. Harbor Blvd.
Santa Ana, CA 92704
1-866-328-4537
120114-01
Rev. C
03/11
Download from Www.Somanuals.com. All Manuals Search And Download.
|