PCGA-DSD5/DSM5
SERVICE MANUAL
US Model
Canadian Model
S400
Specifications
Drive performance
CD-RW/DVD Docking Station (PCGA-DSM5)
Reading speed: 24X max. CD-ROM/CD-R reading,
Operating humidity
20 % to 80 % (not condensed), provided that humidity is
less than 65 % at 95 °F (35 °C)
(hygrometer reading of less than 84 °F (29 °C))
12X max. CD-RW reading,
8X max. DVD-ROM reading,
idential
Storage temperature
Writing speed: 8X max. CD-R writing,
4X max. CD-RW writing,
–4 °F to 140 °F (–20 °C to 60 °C)
(temperature gradient less than 18 °F (10 °C)/hour)
Storage humidity
Disk diameter 4 3/4 inch (12cm), 3inch (8cm)
Multi-session correspondence
10 % to 90 % (not condensed), provided that humidity is
less than 20 % at 140 °F (60 °C)
DVD Docking Station (PCGA-DSD5)
Conf
Reading speed: 24X max. CD-ROM reading,
(hygrometer reading of less than 95 °F (35 °C))
: 8X max. DVD-ROM reading,
Disk diameter 4 3/4 inch (12cm), 3inch (8cm)
Multi-session correspondence
Dimensions
Approx. 11.0 × 0.8(0.9 backside) × 9.3 inches (w/h/d)
(Approx. 279.5 × 18.5(21.5 backside) × 235.0 mm)
(the projecting parts are not included)
Floppy disk drive
Mass
PCGA-DSM5 2.38 lbs. (1,080 g)
3.5" 1.44MB/720KB
PCGA-DSD5 2.27 lbs. (1,030 g)
Supplied accessories
Connectors
SERIAL Connector: RS-232C, D-SUB 9 pin (1)
PRINTER Connector: ECP, D-SUB 25 pin (1)
MONITOR Connector: analog RGB, mini D-SUB 15 pin (1)
USB Connector: USB 4 pin (2)
Operating instructions (1)
Warranty card (1)
i.LINK (IEEE 1394) Connector S400 4pin(1) S400=400Mbps
NETWORK Connector: RJ-45 (1)*
*
There is a NETWORK Connector for the correspondence to 10BASE-T,
100BASE-TX.
Docking Connector: Dedicated connector 100pin(1)
Pow er source AC adapter or battery pack (only when it is attached to the
notebook computer)
Design and specifications are subject to change without notice.
Operating temperature
41 °F to 95 °F (5 °C to 35 °C)
(temperature gradient less than 18 °F (10 °C)/hour)
CD-RW/DVD Docking Station
DVD Docking Station
9-872-201-11
Download from Www.Somanuals.com. All Manuals Search And Download.
TABLE OF CONTENTS
Section
Title
Page
CHAPTER 1. GENERAL
1-1. Locating Controls and Connectors .................................. 1-1
1-2. Attention of i.LINK ......................................................... 1-2
(to 1-2)
CHAPTER 2. REMOVAL
2-1. Flowchart ......................................................................... 2-1
2-2. Main Electrical Parts Location Diagram ......................... 2-1
2-3. Removal ........................................................................... 2-2
1. Housing (Top) Assy ......................................................... 2-2
2. COMBO Drive, DVD-ROM ............................................ 2-2
3. FDD ................................................................................. 2-3
4. IRX-146 Board ................................................................ 2-3
5. CNX-130 Board ............................................................... 2-4
6. SWX-75 Board ................................................................ 2-4
7. CNX-132 Board ............................................................... 2-5
(to 2-5)
CHAPTER 3. SELF DIAGNOSTICS .......................... 3-1
Please confirm “Self Diagnostics” method which will be informed
you with distribution of “Self Diagnostics” software.
CHAPTER 4. BLOCK DIAGRAM ............................... 4-1
(to 4-2)
CHAPTER 5. FRAME HARNESS DIAGRAM ........ 5-1
(to 5-2)
CHAPTER 6. EXPLODED VIEWS AND
PARTS LIST
6-1. Main Section .................................................................... 6-1
6-2. Accessories ...................................................................... 6-4
(to 6-4)
•
Abbreviations
UC : US model / Canadian model
Confidential
– 3 –
PCGA-DSD5/DSM5 (UC)
Download from Www.Somanuals.com. All Manuals Search And Download.
CHAPTER 1.
GENERAL
1-1. Locating Controls and Connectors
Confidential
1-1
PCGA-DSD5/DSM5 (UC)
Download from Www.Somanuals.com. All Manuals Search And Download.
1-2. Attention of i.LINK
The i.LINK compatible unit connected to this set is not recognized. Or,
the message such as “Operation is disabled, as DV unit is not con-
nected or the power is not turned on” is displayed.
t Disconnect the i.LINK cable once, and reconnect it. For further informa-
tion, see “Connecting i.LINK unit” of “Data transfer to i.LINK unit” in the
“Extend” of the Online Manual for this set.
The unit connected to the i.LINK connector on the docking station does
not operate normally.
t Use the i.LINK connector on this set.
The operation of i.LINK compatible unit connected to this set stopped.
t Finish the operation of the i.LINK compatible unit first, when removing
the docking station during the connection of i.LINK compatible unit.
The message “Recording to DV unit failed. Retry after checking the DV
unit for power supply and connection state” is displayed during the
recording on the tape using the “DVgate” software.
t Check if the power and connection cables are connected correctly to
the DV unit. Continuous recording may cause a recording failure even if
the unit is connected correctly. In such a case, restart this set after exit-
ing all of the software.
To use the set in more comfortable environment, it is recommended to
extend the memory.For further information, see“Extending the memory”
(page 109).
The frames drop during the use of “DVgate” software.
t The frames may drop depending on the operating condition. In such a
case, extend the memory. For further information, see “Extending the
memory” (page 109).
Confidential
PCGA-DSD5/DSM5 (UC)
1-2
(END)
Download from Www.Somanuals.com. All Manuals Search And Download.
CHAPTER 2.
REMOVAL
2-1. Flowchart
HOUSING
(TOP) ASSY
COMBO DRIVE,
DVD-ROM
POWER
OFF
P 2-2
P 2-2
FDD
P 2-3
IFX-146
BOARD
P 2-3
CNX-130
BOARD
P 2-4
SWX-75
BOARD
P 2-4
CNX-132
BOARD
P 2-5
• P XX means pages that appears in this manual.
2-2. Main Electrical Parts Location Diagram
CNX-130 Board
IFX-146 Board
CNX-132 Board
FDD
SWX-75 Board
COMBO Drive
(PCGA-DSM5)
DVD-ROM
(PCGA-DSD5)
Confidential
2-1
PCGA-DSD5/DSM5 (UC)
Download from Www.Somanuals.com. All Manuals Search And Download.
2-3. Removal
1. Housing (Top) Assy
Housing (Top) Assy
1 P2.6X8
1 P2.6X8
2
1 P2.6X8
2. COMBO Drive, DVD-ROM
2 FPC (50 Pin)
COMBO Drive
(PCGA-DSM5)
DVD-ROM
(PCGA-DSD5)
3
1 M2X3
*Can remove the drive
by taking off three screws.
Confidential
PCGA-DSD5/DSM5 (UC)
2-2
Download from Www.Somanuals.com. All Manuals Search And Download.
3. FDD
3 Bezel (FDD) Assy
FDD
1 FFC (26 Pin For FDD)
2
4. IRX-146 Board
2 FFC (26 Pin For FDD)
3 FPC (i LINK Connector)
4 FFC (54 Pin With Shield)
8 Harness (Power 3P)
IFX-146 Board
7
9 RJ-45 Harness
(For Internal)
5 FFC (6 Pin)
6 Claw
1 FPC (50 Pin)
Confidential
2-3
PCGA-DSD5/DSM5 (UC)
Download from Www.Somanuals.com. All Manuals Search And Download.
5. CNX-130 Board
CNX-130 Board
1 FPC (i LINK Connector)
3
2 FFC (54 Pin With Shield)
6. SWX-75 Board
1 FFC (6 Pin)
SWX-75 Board
3 Knob (UD)
2
Confidential
PCGA-DSD5/DSM5 (UC)
2-4
Download from Www.Somanuals.com. All Manuals Search And Download.
7. CNX-132 Board
1 Harness (Power 3P)
CNX-132 Board
2
Confidential
2-5
PCGA-DSD5/DSM5 (UC)
(END)
Download from Www.Somanuals.com. All Manuals Search And Download.
CHAPTER 3.
SELF DIAGNOSTICS
< ATTENTION >
Please confirm “Self Diagnostics” method which will be informed
you with distribution of “Self Diagnostics” software.
Confidential
3-1
PCGA-DSD5/DSM5 (UC)
(END)
Download from Www.Somanuals.com. All Manuals Search And Download.
CHAPTER 4.
BLOCK DIAGRAM
– OVERALL BLOCK DIAGRAM –
Docking
Connector
BATT+
+VDC_IN
D_+VDC_IN
PC_SENSE*
DC IN
+VPWRSRC
DOCK_+VPWRSRC
D_PWRSRC_ON*
+VCC5
+VCC3
DC/DC
Conv.
Reg.
DOCKED*
D_INUSE
D_INUSE
RESET
IC
D_PWRGD
UNDOCK_SW*
i.LINK
Bridge Chip
Optical Disc
Drive
PHY-LINK
ATAPI
i.LINK
PHY Chip
H8
INUSE_LED
UNDOCK SW
i.LINK I/F
Docking
Station
Indicator
i.LINK I/F
i.LINK-4
D_SUSPEND
RSRV_ID
i.LINK
Network SW
BUS SW
Floppy Disk
Drive
FD I/F
FD I/F
FDDBUS
MPBID1
Hi-Side
Switch
ICH
USB_EN
USB_PWR_ON
USB I/F
SUS_ON*
x 2
USB Atype
DSUB-9
DSUB-25
DSUB-15
RJ-45
Serial I/F
Parallel I/F
VGA
Ethernet
PCG-R505 Side
Docking Station Side
Confidential
4-1
4-2
(END)
PCGA-DSD5/DSM5 (UC)
Download from Www.Somanuals.com. All Manuals Search And Download.
CHAPTER 5.
FROM board connector (direct connection)
Harness (connector at both end)
Harness (soldered at one end)
FRAME HARNESS DIAGRAM
CN500 CN507
CN506
USB
CN601
DC IN
CN504
SERIAL
CN505
PRINTER
CN503
MONITOR
NETWORK
iLINK
S400
USB
4
1
4
1
Rear
CNX-132
BOARD
SIDE A
CNX-130 BOARD
SIDE A
S500
UNDOCK SW
Side L
3
2
1
10
9
CN600
FPC (iLINK CONNECTOR)
CN501
1
1
54
CN502
FFC (54PIN, WITH SHIELD)
CN302
HARNESS (POWER 3P)
CN101
54
1
CN201
10
1
Side R
1
3
CN304
8
1
CN301
6
FFC
(6PIN)
1
6
1
26
CN400
CN303
1
DC IN
FFC
(26PIN FOR FDD)
SWX-75
BOARD
SIDE B
IFX-146 BOARD
SIDE A
1
99
CN300
1
FDD
26
2
100
S400
i. LINK
NETWORK SW
1
50
NOTEBOOK COMPUTER
(PCG-R600 SERIES)
PCGA-DSM5:
COMBO DRIVE
PCGA-DSD5:
DVD-ROM
FPC (50PIN)
Confidential
5-1
5-2
(END)
PCGA-DSD5/DSM5 (UC)
Download from Www.Somanuals.com. All Manuals Search And Download.
CHAPTER 6.
Ref.No. Part No.
Description
EXPLODED VIEWS AND PARTS LIST
* 1
2
4-652-975-01 BRACKET (FDD (R))
1-772-978-31 FDD
NOTE:
* 3
4
4-652-974-01 BRACKET (FDD (L))
1-815-683-11 FFC (26 PIN FOR FDD)
X-4623-581-1 BEZEL (FDD) ASSY
The components identified by mark 0 or
dotted line with mark 0 are critical for safety.
Replace only with part number specified.
• The mechanical parts with no reference number in the
exploded views are not supplied.
• Items marked “ *” are not stocked since they are seldom
required for routine service. Some delay should be
anticipated when ordering these items.
5
Les composants identifiés par une marque
0 sont critiques pour la sécurité.
Ne les remplacer que par une pièce portant
le numéro spécifié.
* 6
7
4-652-969-01 PLATE (TOP), SHIELD
X-4623-594-1 BRACKET (HOOK) ASSY
X-4623-582-1 GROUND ASSY, MAIN
4-652-966-01 SHAFT (PUSH) (L)
X-4623-579-1 HOUSING (TOP) ASSY
8
• When the same reference numbers are written down in the
list, please use the one listed in the first place as the main
part.
9
10
11
12
4-654-139-01 SHAFT (PUSH) (R)
A-8066-662-A MOUNTED PWB IFX-146
1-815-682-11 FFC (54 PIN, WITH SHIELD)
1-823-006-11 FPC (iLINK CONNECTOR)
4-652-971-01 BRACKET (IO)
13
6-1. Main Section
14
B8
* 15
47
16
* 17
18
A-8066-658-A MOUNTED PWB CNX-130
4-652-970-01 PLATE (BOTTOM), SHIELD
X-4623-679-1 DOOR (JACK) ASSY
1-961-147-21 HARNESS (POWER 3P)
A-8066-660-A MOUNTED PWB CNX-132
14
48
12
9
19
13
B
20
B5
D E
10
21
22
23
24
25
1-961-140-21 HARNESS, RJ-45 (FOR INTERNAL)
4-652-982-01 SPRING (SLIDER), COIL
4-652-968-01 SLIDER (R)
F
B3
C
4-652-965-01 HOOK (R)
G
4-652-981-01 SPRING (HOOK), COMPRESSION COIL
15
49
26
27
28
29
30
4-652-993-01 SHAFT
D
4-652-980-01 SPRING (R), TORSION
4-652-963-01 LEVER (R)
H
B3
1-815-681-11 FFC (6 PIN)
A-8066-659-A MOUNTED PWB SWX-75
50
11
16
E
B3
31
32
33
34
35
4-652-961-01 KNOB (UD)
38
X-4623-680-1 HOUSING (BOTTOM) ASSY
4-641-449-11 FOOT (F)
8
A
C
39
7
4-653-453-01 COVER, FFC
8
X-4623-580-1 (DSD5)...BEZEL (T (DVD)) ASSY
46
B2
17
B4
35
36
X-4623-617-1 (DSM5)...BEZEL (P (DVD)) ASSY
1-796-018-11 (DSD5)...DVD-ROM (X8 SD-C2502)
1-796-072-12 (DSM5)...COMBO DRIVE (UJDA710)
4-652-972-01 BRACKET (CD-R (L))
B2
36
* 37
38
1-823-007-11 FPC (50 PIN)
40
* 39
40
4-652-973-01 BRACKET (CD-R (R))
4-652-967-01 SLIDER (L)
B2
22
26
41
4-652-962-01 LEVER (L)
18
44
B4
42
4-652-979-01 SPRING (L), TORSION
4-653-152-01 BRACKET
7
19
43
25
42
41
* 43
F
6
37
44
45
46
47
48
4-652-964-01 HOOK (L)
36
35
4-655-037-01 SPACER, RIB
PCGA-DSD5
39
45
20
21
25
B2
4-655-034-01 SPACER, BOSS
22
4-652-978-01 PLATE (CONNECTOR), GROUND
4-652-995-01 SHEET (GROUND PLATE I/O)
G
5
24
B
34
49
* 50
B1
4-652-994-01 INSULATING SHEET (BRACKET I/O)
4-652-976-01 BRACKET (CONNECTOR)
4
23
B4
4-646-807-11 0 PLATE M2.5 (FDD) (2.5X2.7)
4-648-320-01 TAPPING (M2) (3X4)
26
B7
B2
B1
27
B3
7-685-134-19 SCREW +P2.6X8 TYPE2 NON-SLIT
28
30
33
3
B4
* B5
B6
4-644-492-91 ACE (M2), LOCK (2X3)
4-635-966-01 SCREW (HEX)
A
4-644-492-41 ACE (M2), LOCK (2X3)
4-645-177-01 SCREW (M1.7X3.5)
4-644-492-81 ACE (M2), LOCK
29
H
B7
B8
B4
B1
2
B7
B3
31
37
1
B6
36
35
PCGA-DSM5
32
Confidential
6-1
6-2
PCGA-DSD5/DSM5 (UC)
Download from Www.Somanuals.com. All Manuals Search And Download.
MEMO
6-2. Accessories
Ref.No. Part No.
Description
ACCESSORIES
***********
4-653-715-11 MANUAL, INSTRUCTION
Confidential
6-3
6-4
(END)
PCGA-DSD5/DSM5 (UC)
Download from Www.Somanuals.com. All Manuals Search And Download.
PCGA-DSD5/DSM5 (UC)
This manual and the constituent data may not be
replicated, copied nor reprinted in whole or in part
without prior written authorization of Sony Corporation.
English
2001D0500-1
Sony Corporation
Printed in USA
© 2001 Sony Corporation
16
Download from Www.Somanuals.com. All Manuals Search And Download.
Published by MNC IT Planning & Control Dept. [SODP]
9-872-201-11
|