Sony Ericsson Stereo System CDX M620 User Manual
CDX-M620/M670  
SERVICE MANUAL  
US Model  
CDX-M620/M670  
Ver 1.0 2001. 03  
AEP Model  
UK Model  
E Model  
CDX-M670  
• The tuner and CD sections have no adjustments.  
Model Name Using Similar Mechanism CDX-M700R/M750  
CD Drive Mechanism Type  
Optical Pick-up Name  
MG-383Z-121//K  
KSS-720A  
SPECIFICATIONS  
MW/LW (AEP, UK, E model)  
AUDIO POWER SPECIFICATIONS (US MODEL)  
POWER OUTPUT AND TOTAL HARMONIC DISTORTION  
23.2 watts per channel minimum continuous average power into  
4 ohms, 4 channels driven from 20 Hz to 20 kHz with no more  
than 5% total harmonic distortion.  
Tuning range  
MW: 531 – 1,602 kHz  
LW: 153 – 279 kHz  
Aerial terminal  
External aerial connector  
Intermediate frequency 10.7 MHz/450 kHz  
Sensitivity  
MW: 30 µV  
LW: 40 µV  
CD player section  
Signal-to-noise ratio  
Frequency response  
Wow and flutter  
90 dB  
10 – 20,000 Hz  
Below measurable limit  
Power amplifier section  
Outputs  
Speaker outputs (sure seal connectors)  
Speaker impedance  
Maximum power output 52 W × 4 (at 4 ohms)  
4 – 8 ohms  
Laser Diode Properties (US model)  
Material  
GaAlAs  
Wavelength  
Emission Duration  
Laser output power  
780 nm  
Continuous  
Less than 44.6 µW*  
General  
Outputs  
Audio outputs (front/rear)  
Subwoofer output (mono)  
Power antenna relay  
control lead (US model)  
Power aerial relay  
* This output is the value measured at a distance  
of 200 mm from the objective lens surface on the  
Optical Pick-up Block.  
control lead (AEP, UK, E model)  
Power amplifier control  
lead  
Tuner section  
FM  
Tuning range  
87.5 – 107.9 MHz (US model)  
87.5 – 108.0 MHz (AEP, UK, E model)  
External antenna connector  
Antenna terminal  
Intermediate frequency 10.7 MHz/450 kHz  
Usable sensitivity  
Selectivity  
Signal-to-noise ratio  
8 dBf  
– Continued on next page –  
75 dB at 400 kHz  
66 dB (stereo),  
72 dB (mono)  
Harmonic distortion at 1 kHz  
0.6% (stereo),  
0.3% (mono)  
Separation  
Frequency response  
35 dB at 1 kHz  
30 – 15,000 Hz  
FM/AM COMPACT DISC PLAYER  
CDX-M620/M670  
AM (US model)  
Tuning range  
530 – 1,710 kHz  
Antenna terminal  
External antenna connector  
Intermediate frequency 10.7 MHz/450 kHz  
FM/MW/LW COMPACT DISC PLAYER  
Sensitivity  
30 µV  
CDX-M670  
9-873-505-11  
2001C0400-1  
© 2001. 3  
Sony Corporation  
Audio Entertainment Group  
General Engineering Dept.  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
NOTE FOR THE OPENING OF THE FRONT PANEL  
In this set, the front panel is lowered to below the bottom face when  
it is opened.  
When servicing the set, place it on a stand having a height of about  
2 cm.  
TABLE OF CONTENTS  
1. GENERAL ........................................................................... 4  
2. DISASSEMBLY  
2-1. Front Panel Assy (Normal) ............................................... 16  
2-2. Front Panel Assy (Inoperative) ......................................... 16  
2-3. CD Mechanism Block, Flexible Board ............................. 16  
2-4. Sub Panel (CD) Sub Assy ................................................. 17  
2-5. Motor Block Assy, Cam (R) Assy ..................................... 17  
2-6. Main Board ....................................................................... 18  
2-7. Heat Sink ........................................................................... 18  
2-8. Chassis (T) Sub Assy ........................................................ 19  
2-9. Lever Section .................................................................... 19  
2-10. Servo Board....................................................................... 20  
2-11. Shaft Roller Assy............................................................... 20  
2-12. Floating Block Assy .......................................................... 21  
2-13. Optical Pick-up Block ....................................................... 21  
stand  
3. PHASE ALIGNMENT  
3-1. Arm (A-L) Assy, Arm (B-L) Assy ..................................... 22  
3-2. Cam (L) ............................................................................. 22  
3-3. Motor Block ...................................................................... 23  
3-4. Alignment between Arm (A-L) Assy  
TEST MODE  
and Arm (B-L) Assy .......................................................... 23  
3-5. Arm (A-R) Assy, Arm (B-R) Assy .................................... 24  
3-6. Cam (R) ............................................................................. 24  
1. Turn on the power.  
2. Push “4” on the card remote control for 2 sec.  
3. Push “5” on the control for 2 sec.  
4. Push “1” on the control for 2 sec.  
(The TEST MODE is entered.)  
4. DIAGRAMS  
5. Push the “OPEN/CLOSE” switch on the control for 2 sec.  
6. The front panel detouch position is set.  
(No display appears at this time.)  
4-1. IC Pin Descriptions ........................................................... 25  
4-2. Circuit Boards Location .................................................... 33  
4-3. Block Diagram –CD Section–........................................... 34  
4-4. Block Diagram –Tuner Section– ....................................... 35  
4-5. Block Diagram –Display Section– .................................... 36  
4-6. Printed Wiring Boards –CD Mechanism Section–............ 38  
4-7. Schematic Diagram –CD Mechanism Section (1/2)– ....... 40  
4-8. Schematic Diagram –CD Mechanism Section (2/2)– ....... 41  
4-9. Printed Wiring Boards –Main Section– ............................ 42  
4-10. Schematic Diagram –Main Section (1/4)– ........................ 44  
4-11. Schematic Diagram –Main Section (2/4)– ........................ 45  
4-12. Schematic Diagram –Main Section (3/4)– ........................ 46  
4-13. Schematic Diagram –Main Section (4/4)– ........................ 47  
4-14. Printed Wiring Board –Sub (CD) Section– ....................... 48  
4-15. Schematic Diagram –Sub (CD) Section–.......................... 49  
4-16. Printed Wiring Board –Key Section– ................................ 50  
4-17. Schematic Diagram –Key Section– .................................. 51  
4-18. Printed Wiring Board –Display Section– .......................... 52  
4-19. Schematic Diagram –Display Section–............................. 53  
7. Turn off the power and disassemble the set.  
5. EXPLODED VIEWS  
5-1. Chassis Section ................................................................. 56  
5-2. Cam Section ...................................................................... 57  
5-3. Main Board Section .......................................................... 58  
5-4. Front Panel (Key) Assy Section ........................................ 59  
5-5. Front Panel (Dspl) Assy Section ....................................... 60  
5-6. CD Mechanism Section (1) ............................................... 61  
5-7. CD Mechanism Section (2) ............................................... 62  
5-8. CD Mechanism Section (3) ............................................... 63  
6. ELECTRICAL PARTS LIST ........................................ 64  
3
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
SECTION 1  
GENERAL  
This section is extracted  
from instruction manual.  
US MODEL  
AEP, UK, E MODEL  
4
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
US, AEP, UK, E MODEL  
5
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
US MODEL  
6
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
AEP, UK, E MODEL  
7
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
8
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
9
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
US, AEP, UK, E MODEL  
10  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
11  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
US MODEL  
Connection  
12  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
13  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
AEP, UK, E MODEL  
Connection  
14  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
15  
15  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
SECTION 2  
DISASSEMBLY  
Note : This set can be disassemble according to the following sequence.  
2-2. FRONT PANEL ASSY (INOPERATIVE)  
Front Panel Assy (Normal)  
CD Mechanism Block, Front Panel (KEY) Assy  
Front Panel Assy (Inoperative)  
4 screw (panel)  
Sub Panel (CD) Sub Assy  
Chassis (T) Sub Assy  
Motor Block Assy, Cam (R) Assy  
Lever Section  
Main Board  
Heat Sink  
Shaft Roller Assy  
Floating Block Assy  
Servo Board  
1
5
Optical Pick-up Block  
3 screw (panel)  
flexible board  
6 front panel (key) assy  
2 front panel (DSPL) assy  
(Take care not to pull the  
flexible board excessively)  
Note : Follow the disassembly procedure in the numerical order given.  
2-1. FRONT PANEL ASSY (NORMAL)  
2-3. CD MECHANISM BLOCK, FRONT PANEL (KEY) ASSY  
1 Turn on the power and open the front panel.  
7 bracket (CD)  
5 CD mechanism block  
6 PTT 2.6x6  
8 tension spring (flexible)  
5 screw (panel)  
0 cover (flexible)  
9 slider (flexible)  
3 PTT 2.6x4  
qa CN604  
stand  
slider (flexible)  
flexible board  
2
Note: When installing  
the flexible board,  
make the board slack  
as illustrated.  
2 PTT 2.6x4  
4 screw (panel)  
flexible board  
1 PTT 2.6x6  
6 front panel (key) assy  
(Take care not to  
4 CN401  
pull the flexible  
board excessively)  
3 front panel (DSPL) assy  
qa front panel (key) assy  
16  
16  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
2-4. SUB PANEL (CD) SUB ASSY  
1 CN603  
4 claw  
3 PTT 2.6x6  
5 claw  
2 PTT 2.6 x6  
6 sub panel (CD) sub assy  
2-5. MOTOR BLOCK ASSY, CAM (R) ASSY  
Note : Install the motor block assy and cam (R) assy in this roder.  
For phase alignment between cams (L) and (R), see page 22 and 24.  
1 PTT 2.6x6  
Note: Install the cam (R) assy with  
4 PTT 2.6x6  
the cam fully rotated in the  
direction of the arrow A.  
5 motor block assy  
A
2 cam (R) assy  
3 CN602  
17  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
2-6. MAIN BOARD  
5 MAIN board  
4 PTT 2.6x6  
ground point  
3 PTT 2.6x6  
ground point  
2 PTT 2.6x6  
1 PTT 2.6x6  
2-7. HEAT SINK  
5 heat sink  
4 PTT 2.6x6  
3 PTT 2.6x10  
2 PTT 2.6x6  
1 PTT 2.6x6  
18  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
2-8. CHASSIS (T) SUB ASSY  
2 P 2x3  
3 P 2x3  
1 Unsolder the  
4 chassis (T) sub assy  
lead wires.  
black  
red  
white  
2-9. LEVER SECTION  
5 guide (disc)  
6 lever (R)  
3 tension spring (LR)  
7 lever (L)  
1 special screw  
2 DISC IN SW board  
4 claws  
19  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
2-10. SERVO BOARD  
7 special screws  
6 special screws  
3 Removal the solders.  
2 CN2  
1 CN3  
4 P 2x3  
8 SERVO board  
5 loading motor assy  
2-11. SHAFT ROLLER ASSY  
3 retaing ring (RA)  
4 shaft retainer (roller)  
shaft retainer (roller)  
washer  
arm  
washer  
shaft retainer (roller)  
retaing ring (RA)  
arm  
Fig. 1  
5 shaft roller assy  
2 arm (roller)  
1 tension spring (RA)  
20  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
2-12. FLOATING BLOCK ASSY  
6 floating block assy  
7 compression spring (FL)  
1 tension spring (KF1)  
8 compression spring (FL)  
4 Fit lever (D) in the  
direction of the arrow.  
5 Turn loading ring in the  
direction of the arrow.  
2 damper (T)  
3 damper (T)  
2-13. OPTICAL PICK-UP BLOCK  
1 P 2x3  
5 P 2x3  
6 spring (feed), plate  
4 PICK-UP flexible board  
2 sled motor assy  
7 shaft (feed) assy  
3 optical pick-up block  
21  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
SECTION 3  
PHASE ALIGNMENT  
3-1. ARM (A-L) ASSY, ARM (B-L) ASSY  
3 arm (A-L) assy  
4 stop ring 1.5, type-E  
2 stop ring 1.5, type-E  
1 arm (B-L) assy  
bracket (L) assy  
3-2. CAM (L)  
1 Move the arm (B-L) assy in the direction of the  
arrow A and the arm (A-L) assy in the direction of  
the arrow B fully (full open state).  
3 stop ring 1.5, type-E  
2 Align the hole (large) on the cam (L) with part C and  
install the cam.  
4 Turn the cam (L) clockwise and counterclockwise to  
verify that both the arms are operated.  
hole(large)  
cam (L)  
C
line  
A
arm (B-L) assy  
arm (A-L) assy  
B
22  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
3-3. MOTOR BLOCK  
1 Turn the cam (L) and position the cam so that part A  
does not touch the SWITCH board SW900.  
3 PTT 2.6x6  
4 PTT 2.6x6  
2 motor block  
SWITCH board  
5 PTT 2.6x6  
SW1001  
SW1002  
cam (L)  
A
3-4. ALIGNMENT BETWEEN ARM (A-L) ASSY  
AND ARM (B-L) ASSY  
1 Input 9V DC to the motor terminal until the cam (L)  
stops rotating.  
Take care to avoid overload of the motor.  
2 Verify that the arm (A-L) assy and arm (B-L) assy  
are positioned as shown below (full open).  
motor  
+B  
arm (B-L) assy  
DC 9V  
GND  
arm (A-L) assy  
23  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
3-5. ARM (A-R) ASSY, ARM (B-R) ASSY  
4 stop ring 1.5, type-E  
3 arm (A-R) assy  
2 stop ring 1.5, type-E  
1 arm (B-R) assy  
bracket (R) assy  
3-6. CAM (R)  
3 stop ring 1.5, type-E  
1 Move the arm (B-R) assy in the direction of the  
arrow A and the arm (A-R) assy in the direction of  
the arrow B fully (full open state).  
2 Align the hole (large) on the cam (R) with part C and  
install the cam.  
hole(large)  
4 Turn the cam (R) clockwise and counterclockwise to  
verify that both the arms are operated.  
cam (R)  
arm (B-R) assy  
A
C
line  
B
arm (A-R) assy  
5 damper, oil  
6 screw (P 2x4)  
24  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
SECTION 4  
DIAGRAMS  
4-1. IC PIN DESCRIPTIONS  
• IC501 CXD2598Q (DIGITAL SERVO, DIGITAL SIGNAL PROCESSOR) (SERVO BOARD)  
Pin No.  
1
Pin Name  
DVDD  
DVSS  
SOUT  
SOCK  
XOLT  
SQSO  
SQCK  
SCSY  
SBSO  
EXCK  
XRST  
STSM  
DATA  
XLAT  
CLOK  
SENS  
SCLK  
ATSK  
WFCK  
XUGF  
XPCK  
GFS  
I/O  
—
—
O
O
O
O
I
Pin Description  
Digital power supply pin  
Digital ground  
2
3
Servo brock serial data output (Not used.)  
4
Servo brock serial data read clock output (Not used.)  
Servo brock serial data latch output (Not used.)  
5
6
Sub Q 80 bit, PCM peak and level data output. CD TEXT data output  
Clock input from SQSO read out.  
Fixed at “L”.  
7
8
I
9
O
I
Serial output of sub-P to W. (Not used.)  
Clock input from SBSO read out. (Fixed at “L”)  
System reset (“L”: Reset)  
10  
11  
12  
13  
14  
15  
16  
17  
18  
19  
20  
21  
22  
23  
24  
25  
26  
27  
28  
29  
30  
31  
32  
33  
34  
35  
36  
37  
38  
39  
40  
41  
42  
43  
44  
45  
46  
47  
48  
49  
50  
51  
I
I
System mute input (Fixed at “L”)  
Serial data input from CPU.  
I
I
Latch input from CPU. Latch serial data at the falling edge.  
Serial data transfer clock input from CPU.  
SENS output for CPU.  
I
O
I
Clock input from SENS serial data read.  
Input/output for anti-shock.  
I/O  
O
O
O
O
O
O
O
O
I/O  
I/O  
—
—
I/O  
I/O  
I
WFCK (Write Flame Clock) output (Not used.)  
XUGF output (Not used.)  
XPCK output (Not used.)  
GFS output  
C2PO  
SCOR  
C4M  
C2PO output (Not used.)  
“H” output at either detection, sub code sync S0 or S1.  
4.2336 MHz output (Not used.)  
Word clock output f=2Fs (Not used.)  
Track number count signal input/output (Not used.)  
Mirror signal input/output (Not used.)  
Digital ground  
WDCK  
COUT  
MIRR  
DVSS  
DVDD  
DFCT  
FOK  
Digital power supply pin  
Diffect signal input/output (Not used.)  
Focus OK signal input/output  
External control input of spindle motor.  
Lock signal input/output  
PWM1  
LOCK  
MDP  
I/O  
O
I
Servo control output of spindle motor.  
Disc most inner track detection signal input  
2/3 frequency division input/output of pins ih and ij. (Not used.)  
Sled drive output  
SSTP  
FSTIO  
SFDR  
SRDR  
TFDR  
TRDR  
FFDR  
FRDR  
DVDD  
DVSS  
TEST  
TES1  
I/O  
O
O
O
O
O
O
—
—
I
Sled drive output  
Tracking drive output  
Tracking drive output  
Focus drive output  
Focus drive output  
Digital power supply pin  
Digital ground  
Test pin (Fixed at “L”.)  
I
Test pin (Fixed at “L”.)  
XTSL  
VC  
I
X’tal select input (“L”: 16.9344 MHz, “H”: 33.8688 MHz)  
Center voltage input  
I
FE  
I
Focus error signal input  
SE  
I
Sled error signal input  
25  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
Pin No.  
52  
53  
54  
55  
56  
57  
58  
59  
60  
61  
62  
63  
64  
65  
66  
67  
68  
69  
70  
71  
72  
73  
74  
75  
76  
77  
78  
79  
80  
81  
82  
83  
84  
85  
86  
87  
88  
89  
90  
91  
92  
93  
94  
95  
96  
97  
98  
99  
100  
Pin Name  
I/O  
I
Pin Description  
TE  
Tracking error signal input  
Center servo analog input  
RF signal input  
CE  
I
RFDC  
ADIO  
AVSSO  
IGEN  
I
O
—
I
Test pin (Not used.)  
Analog ground  
Constant current input from OP amplifier.  
Analog ground  
AVDDO  
ASYO  
ASYI  
—
O
I
EFM full-swing output (“L”: VSS, “H”: VDD)  
Asymmetry comparate voltage input  
EFM signal input  
RFAC  
AVSS3  
CLTV  
FILO  
I
—
I
Analog ground  
VCO control voltage input from master.  
Filter output for master PLL. (slave=digital PLL)  
Filter input from master PLL.  
O
I
FILI  
PCO  
O
—
I
Charge pump output for master PLL.  
Analog power supply pin  
AVDD3  
BIAS  
Asymmetry circuit constant current input  
VCO2 control input from wideband EFM PLL.  
VCO2 oscillator output for wideband EFM PLL. (Not used.)  
Charge pump output for wideband EFM PLL. (Not used.)  
Digital ground  
VCTL  
V16M  
VPCO  
DVSS  
MD2  
I
O
O
—
I
Digital out ON/OFF control input (“L”: OFF, “H”: ON)  
Digital out output  
DOUT  
ASYE  
DVDD  
LRCK  
LRCKI  
PCMD  
PCMD  
BCK  
O
I
Asymmetry circuit ON/OFF input (“L”: OFF, “H”: ON)  
Digital power supply pin  
—
O
I
D/A interface LR clock output (f=Fs)  
D/A interface LR clock input  
O
I
D/A interface serial data output (2’s COMP, MSB fast)  
D/A interface serial data input (2’s COMP, MSB fast)  
D/A interface bit clock output  
O
I
BCKI  
D/A interface bit clock input  
EMPH  
EMPHI  
XVDD  
XTAI  
O
I
Emphasis ON/OFF signal output  
Emphasis ON/OFF signal input (“H”: ON, “L”: OFF)  
Power supply for master clock.  
—
I
X’tal oscillator input from master clock (16.9344 MHz).  
X’tal oscillator output for master clock (16.9344 MHz). (Not used.)  
Ground pin for master clock.  
XTAO  
XVSS  
AVDD1  
AOUT1  
AIN1  
O
—
—
O
I
Analog power supply pin  
Lch analog output (Not used.)  
Lch OP amplifier input (Not used.)  
Lch LINE output (Not used.)  
LOUT1  
AVSS1  
AVSS2  
LOUT2  
AIN2  
O
—
—
O
I
Analog ground  
Analog ground  
Rch LINE output (Not used.)  
Rch OP amplifier input (Not used.)  
Rch analog output (Not used.)  
AOUT2  
AVDD2  
RMUT  
LMUT  
O
—
O
O
Analog power supply pin  
Rch “0” detect Flug (Not used.)  
Lch “0” detect Flug (Not used.)  
26  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
• IC5 CXP84640-072Q (CD SYSTEM CONTROL) (SERVO BOARD)  
Pin No.  
1
Pin Name  
ITRPT  
—
I/O  
—
—
—
I
Pin Description  
Not used in this set.  
2, 3  
4, 5  
6
Not used in this set.  
NCO  
Not used in this set.  
OPEN  
Front panel open detection input  
Front panel close control output  
Bus interface link input  
Not used in this set.  
7
CLOSE  
LINKOFF  
NCO  
O
I
8
9
—
I
10  
11  
D SW  
Down switch input (SW1)  
Limit switch input (SW4)  
Not used in this set.  
SSTP  
I
12, 13  
14, 15  
16  
17  
18  
19  
20  
21  
22  
23  
24  
25  
26  
27  
28  
29  
30  
31  
32  
33  
34  
35  
36  
37  
38  
39  
40  
41  
42  
43  
44  
45  
46  
47  
48  
49  
50  
51  
52  
53  
54  
55  
56  
NCO  
—
—
O
O
O
O
O
O
O
O
—
I
—
Not used in this set.  
EMPH O  
CDMON  
CD ON  
A MUT  
LD ON  
CD RST  
HOLD  
AGC CONT  
—
De-emphasis ON/OFF control output  
CD mechanism deck power control output  
CD power control output  
System attenuate control output  
Laser power ON/OFF control output  
CD system reset output  
Hold switch output  
AGC control output  
Not used in this set.  
PH3  
Not used in this set.  
TSTIN0  
TSTIN1  
TST.CLV  
NCO  
I
Not used in this set.  
I
Not used in this set.  
I
Not used in this set.  
—
I
Not used in this set.  
RESET  
X IN  
System reset input (“L”=Reset)  
X’tal oscillator input from system clock. (10 MHz)  
X’tal oscillator output for system clock. (10 MHz)  
Analog ground  
I
X OUT  
GND  
O
—
O
I
XT OUT  
XT IN  
Not used in this set.  
Not used in this set.  
AVSS  
—
I
A/D converter ground  
AVREF  
TEP L  
A/D converter reference voltage input  
Not used in this set.  
I
TEP H  
SLED–  
PH2  
I
Not used in this set.  
I
Sled drive input  
I
Not used in this set.  
SEK/SMET  
GFS/MNT2 SEL  
SC-JIG ON/OFF  
SCLK  
I
Fixed at “H” in this set.  
I
Fixed at “H” in this set.  
I
Fixed at “H” in this set.  
O
I/O  
—
O
I
CD-TEXT data read clock output  
Lock signal input/output  
Not used in this set.  
LOCK  
—
SCK2  
Sub Q read clock output  
SI2  
Sub Q 80 bit, PCM peak and level data 16 bit input.  
Not used in this set.  
—
—
I/O  
I
BUS CLK  
BUS SI  
BUS SO  
F OK  
Bus system serial clock input/output  
Bus system serial interface input  
Bus system serial interface output  
Focus OK signal input  
O
I
GFS  
I
GFS signal detection input  
Fixed at “H” in this set.  
TEST MODE  
I
27  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
Pin No.  
57  
Pin Name  
I/O  
I
Pin Description  
SENS  
—
SENS signal input  
58  
—
—
I
Not used in this set.  
59  
—
Not used in this set.  
60  
BU.IN  
BUSON  
IN SW  
SELF SW  
SCOR  
CD-CKO  
LM LOD  
CD DATA  
CD-XLAT  
LM-EJ  
DRV-OE  
MD2  
Back-up power detection input  
Bus on control input  
61  
I
62  
I
Disc in switch input (SW3)  
Self switch input (SW2)  
Sub-code sync output  
63  
I
64  
O
O
O
O
O
O
O
O
—
I
65  
CD signal process serial clock output  
Loading motor control output  
CD signal process serial data output  
CD signal process serial data latch output  
Loading motor control output  
Focus/tracking coil/sled motor control output  
Digital out ON/OFF control output (“L”: OFF, “H”: ON)  
Power supply pin  
66  
67  
68  
69  
70  
71  
72  
VDD  
73  
NIH  
Fixed at “H” in this set.  
74  
V/Z  
I
Fixed at “H” in this set.  
75  
PH1  
I
Not used in this set.  
76  
—
—
I
Not used in this set.  
77  
DOUT-SEL  
—
Fixed at “H” in this set.  
78 – 80  
—
Not used in this set.  
28  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
• IC501 MB90574BPMT-G-321-BND (SYSTEM CONTROL) (MAIN BOARD) (US MODEL)  
• IC501 MB90574BPMT-G-322-BND (SYSTEM CONTROL) (MAIN BOARD) (AEP, UK, E MODEL)  
Pin No.  
1 – 3  
4
Pin Name  
(NCO)  
I/O  
O
O
O
O
O
—
O
I/O  
I/O  
I
Pin Description  
Not used. (Open)  
SP LATCH  
ATT  
Spectrum analyzer data latch signal  
System mute signal  
5
6
SYS RST  
(NCO)  
System reset signal  
7
Not used. (Open)  
8
VCC  
Power supply pin (+5 V)  
Not used. (Open)  
9
(NCO)  
10  
11  
12  
13  
14  
15  
16  
17  
18  
19  
20 – 23  
24  
25  
26  
27  
28  
29  
30  
31  
32  
33  
34  
35  
36  
37  
38  
39  
40  
41  
42  
43  
44  
45  
46  
47  
48  
49  
50  
51  
52  
53  
54  
55  
56  
E2P SIO  
E2P CKO  
FLS SI  
FLS SO  
BUS ON  
BEEP  
Tuner unit EEPROM BUS serial data input/output  
Tuner unit EEPROM BUS serial clock input/output  
Flash CPU write-in data input  
Flash CPU write-in data output  
BUS ON signal  
O
O
O
I
Beep signal  
TEL ATT  
UNI SI  
UNI SO  
UNI CKO  
(NCO)  
Telephone mute signal  
SONY BUS serial data input  
SONY BUS serial data output  
SONY BUS serial clock output  
Not used. (Open)  
I
O
O
O
I
SIRCS  
Wireless remote data input  
DSP serial data input  
DSP SI  
DSP SO  
DSP CKO  
DSP PLL  
DSP MST  
(NCO)  
I
O
O
O
O
O
O
O
—
—
O
O
O
—
—
O
O
—
—
—
—
I
DSP serial data output  
DSP serial clock output  
DSP PLL clock control signal  
DSP master/slave control signal  
Not used. (Open)  
VOL ATT  
TU ATT  
VSS  
Electronic volume mute signal  
Not used. (Open)  
Ground  
C
Not used. (Open)  
DSP LAT  
DSP RST  
SHIFT  
DSP latch signal  
DSP reset signal  
OSC frequency shift signal for DC/DC conv.  
Power supply pin (+5 V)  
Ground  
DVCC  
DVSS  
FP CTRL  
(NCO)  
OPEN/CLOSE motor voltage control signal  
Not used. (Open)  
AVCC  
Power supply pin (+5 V)  
Power supply pin (+5 V)  
Ground  
AVRH  
AVRL  
AVSS  
Ground  
KEY IN0  
KEY IN1  
RC IN0  
(NCO)  
Key input 0  
I
Key input 1  
I
Rotary commander input 0  
Not used. (Open)  
O
I
QUALITY  
(NCO)  
Noise detection signal  
Not used. (Open)  
O
I
MPTH  
Tuner multi path detection signal  
S-meter voltage detection signal  
Power supply pin (+5 V)  
Power amplifier drive signal  
Noise detection ON/OFF control signal  
VSM  
I
VCC  
—
O
O
STBY  
NS MASK  
29  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
Pin No.  
57  
Pin Name  
I/O  
O
O
I
Pin Description  
DC/DC converter power control signal  
DDC ON  
CD EJECT OK  
CD OPEN REQ  
(NCO)  
58  
CD eject control signal  
59  
Front panel open request signal  
Not used. (Open)  
60  
O
I
61  
OPEN KEY  
NOSE SW  
VSS  
OPEN key detection signal  
Nose SW detection signal  
Ground  
62  
I
63  
—
I
64  
DETACH SW  
PWM  
Detach SW detection signal  
Oscillation frequency count input  
Not used. (Open)  
65  
I
66 – 68  
69  
(NCO)  
O
I
FLASH W  
I2C SIO  
I2C CKO  
RC IN1  
Flash write-in signal  
70  
I/O  
I/O  
I
I2C serial data input/output  
I2C serial clock input/output  
Rotary commander input 1  
Crystal oscillator (32.768 kHz)  
Crystal oscillator (32.768 kHz)  
RDS data acquisition detect signal  
CD mechanism power control signal  
Back-up power detection signal  
DSP ready signal  
71  
72  
73  
X1A  
—
—
I
74  
X0A  
75  
DAVN  
76  
CDON IN  
BU IN  
I
77  
I
78  
DSP READY  
KEY ACK  
AD ON  
I
79  
I
Key acknowledge signal  
80  
O
I
A/D converter power control signal  
Accessory key ON signal  
Flash power ON control signal  
Audio circuit power ON control signal  
Test mode initial setting detection signal  
RAM reset detection signal  
Hardware standby input  
81  
ACC IN  
FLS PWON  
PW ON  
TEST IN  
RAM BU  
HSTX  
82  
O
O
I
83  
84  
85  
I
86  
I
87  
MD2  
I
Connecting to ground in this set.  
Connecting to VCC in this set.  
Connecting to VCC in this set.  
Reset input  
88  
MD1  
I
89  
MD0  
I
90  
RSTX  
I
91  
VSS  
—
—
—
—
I
Ground  
92  
X0  
Crystal oscillator (3.68 MHz)  
Crystal oscillator (3.68 MHz)  
Power supply pin (+5 V)  
Illumination dimmer control signal  
OPEN/CLOSE motor abnormal current detection  
OPEN/CLOSE motor control signal  
OPEN/CLOSE motor control signal  
Close SW detection signal  
Open SW detection signal  
Cent SW detection signal  
Not used. (Open)  
93  
X1  
94  
VCC  
95  
ILL IN  
96  
I DET  
I
97  
MOT –  
O
O
I
98  
MOT +  
99  
CLOSE SW  
OPEN SW  
CENT SW  
(NCO)  
100  
101  
102  
103  
104  
105  
106  
107  
108  
109  
110  
111  
I
I
O
I
CDMD SEL  
DEST SEL1  
DEST SEL2  
BOOT  
CD/MD selector signal  
I
Destination selector signal 1  
Destination selector signal 2  
Display CPU write-in control signal  
Not used. (Open)  
I
O
O
O
O
I
(NCO)  
DSP ON  
SENS ON  
EMPH IN  
PACK IN  
DSP power control signal  
Not used. (Open)  
Emphasis input  
I
Pack detection signal  
30  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
Pin No.  
112  
Pin Name  
4V SEL  
(NCO)  
I/O  
I
Pin Description  
4V select control signal  
Not used. (Open)  
113  
O
O
O
O
O
O
—
O
114  
TUN ON  
LED SW1  
LED SW2  
(NCO)  
Tuner power control signal  
Illumination select control signal 1  
Illumination select control signal 2  
Not used. (Open)  
115  
116  
117  
118  
(NCO)  
Not used. (Open)  
119  
VSS  
Ground  
120  
(NCO)  
Not used. (Open)  
31  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
• IC702 HD643255A36F (SUB SYSTEM CONTROL) (MAIN BOARD)  
Pin No.  
1
Pin Name  
SA CLK  
PG4  
I/O  
O
O
—
—
—
O
—
O
O
—
O
O
—
O
I
Pin Description  
Not used. (Open)  
Not used. (Open)  
Ground  
2
3
VSS  
4
NC  
Not used. (Open)  
Power supply pin (+ 5V)  
Not used. (Open)  
Ground  
5
VCC  
6 – 9  
10  
PC0 – PC3  
VSS  
11 – 14  
15 – 18  
19  
PC4 – PC7  
PB0 – PB3  
VSS  
Not used. (Open)  
Not used. (Open)  
Ground  
20 – 23  
24 – 27  
28  
PB4 – PB7  
PA0 – PA3  
VSS  
Not used. (Open)  
Not used. (Open)  
Ground  
29 – 31  
32  
PA4 – PA6  
SA EN IN  
SPE LAT  
BU IN  
Not used. (Open)  
Connecting to ground in this set.  
33  
I
Spectrum analyzer data latch signal  
Back-up power detection signal  
Ground  
34  
I
35, 36  
37  
VSS  
—
O
I
P65  
Not used. (Open)  
38  
BUS ON  
VCC  
BUS ON signal  
39  
—
O
—
I
Power supply pin (+5 V)  
Not used. (Open)  
40 – 43  
44  
PE0 – PE3  
VSS  
Ground  
45  
DSP SEL  
LED SW1  
LED SW2  
PE7  
Spectrum analyzer data select signal  
Illumination select control signal 1  
Illumination select control signal 2  
Not used. (Open)  
46  
I
47  
I
48  
O
O
O
O
O
—
O
I
49  
BU IN  
Not used. (Open)  
50  
LINK OFF  
PD2  
Link OFF control signal  
Not used. (Open)  
51  
52  
ILL ON  
VSS  
Illumination power control signal  
Ground  
53  
54 – 56  
57  
PD4 – PD6  
BOOT  
Not used. (Open)  
Display CPU write-in control signal  
Power supply pin (+5 V)  
Not used. (Open)  
58  
VCC  
—
O
O
I
59  
P30  
60  
LCD SO/TX  
SP SI  
LCD driver serial data output  
Spectrum analyzer data input  
Flash CPU write-in data input  
Spectrum analyzer clock input  
LCD driver serial clock output  
Ground  
61  
62  
RX  
I
63  
SP CKI  
LCD CKO  
VSS  
I
64  
O
—
O
—
O
O
O
O
O
I
65  
66  
LCD CEO  
VSS  
LCD driver chip enable output  
Ground  
67, 68  
69  
LCD INH  
LCD CE1  
LCD CE2  
P27 – P21  
FL W  
LCD driver inhibit control signal  
LCD driver chip enable output  
LCD driver chip enable output  
Not used. (Open)  
70  
71  
72 – 78  
79  
Flash write control signal  
Flash write enable signal  
System reset signal  
80  
FW E  
81  
SYS RST  
NMI  
I
82  
I
Non maskable interrupt signal  
32  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
Pin No.  
83  
Pin Name  
STBY  
VCC  
I/O  
I
Pin Description  
4-2. CIRCUIT BOARDS LOCATION  
Hardware standby signal  
Power supply pin (+5 V)  
Crystal oscillator (18.432 MHz)  
Crystal oscillator (18.432 MHz)  
Ground  
84  
—
—
—
—
O
—
O
O
I
85  
XTAL  
EXTAL  
VSS  
86  
87  
DISC IN SW board  
LIMIT SW board  
88  
PF7  
Not used. (Open)  
89  
VCC  
Power supply pin (+5 V)  
Not used. (Open)  
SERVO board  
SWITCH board  
90 – 96  
97  
PF6 – PF0  
UNI SO  
UNI SI  
VSS  
SONY BUS serial data output  
SONY BUS serial data input  
Ground  
98  
99, 100  
101  
—
I
UNI CKI  
P53  
SONY BUS serial clock input  
Not used. (Open)  
102  
O
—
—
I
103  
AVCC  
VREF  
P40 – P47  
AVSS  
Power supply pin (+5 V)  
Power supply pin (+5 V)  
Connecting to ground in this set.  
Ground  
104  
105 – 112  
113  
tuner unit  
(TUX201)  
—
—
O
I
114  
VSS  
Ground  
DISPLAY board  
115 – 122  
123  
P17 – P10  
MD0  
Not used. (Open)  
MAIN board  
Mode setting 0  
124  
MD1  
I
Mode setting 1  
SUB (CD) board  
125  
MD2  
I
Mode setting 2  
126 – 128  
PG0 – PG2  
O
Not used. (Open)  
KEY board  
33  
33  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
4-3. BLOCK DIAGRAM — CD SECTION —  
4
TUNER  
CDL  
ATT  
RF AMP, LD APC,  
ERROR AMP  
IC1  
DIGITAL SERVO,  
DIGITAL SIGNAL PROCESSOR  
IC501  
SECTION  
CD SYSTEM CONTROL  
IC5  
SYSTEM CONTROL  
IC501 (1/3)  
OPTICAL PICK-UP  
KSS-720A  
(Page 35)  
• Signal path  
A MUT  
OPEN  
ATT  
CD EJECT OK  
CD OPENREQ  
19  
6
5
58  
59  
A
A
5
:CD  
CLOSE  
7
• R-ch : same as L-ch.  
BUS CLK  
BUS SI  
UNI CLK  
UNI SI  
UNI SO  
BUS ON  
SYS RST  
BU IN  
RAM BU  
RSTX SIRCS  
HSTX  
51  
52  
19  
17  
18  
14  
6
77  
85  
90  
86  
LOUT1  
LOUT2  
C
B
(Page 36)  
C
B
79  
79  
7
6
RFO  
RFAC  
RFDC  
RF  
EQ  
EFM  
DEM  
D/A  
I/F  
D/A  
CONV.  
16  
61  
54  
R-CH  
1
BUS ON  
RESET  
BU IN  
61  
30  
60  
CD ON  
MD ON  
SIRCS INTERFACE  
IC801  
I-V  
CONV.  
DISPLAY  
SECTION  
D
D
8
CDM ON  
17  
FOCUS  
ERROR  
17 D3  
G0  
9
CD ON  
LOCK  
24  
18  
46  
DIGITAL  
CLV  
LOCK  
34  
S60  
(RESET)  
XIN XOUT  
FE  
TE  
FE  
TE  
SE  
3
4
14  
13  
50  
52  
51  
IC502  
E
F
E
F
11  
10  
TRACKING  
ERROR  
SQSO  
SQCK  
SCOR  
SI2  
SCK2  
SCOR  
6
7
24  
49  
48  
64  
SUB  
BU 5V  
1
RESET  
2
X801  
4MHz  
CODE  
PROCESS  
SW901  
(RESET)  
PD  
LD  
PD  
LD  
4
3
MD2  
MD2  
73  
11  
13  
14  
17  
15  
16  
22  
32  
71  
21  
67  
68  
45  
65  
57  
55  
54  
LD ON  
LD  
AMP  
XRST  
DATA  
XLAT  
SCLK  
CLOK  
SENS  
GFS  
CD RST  
CD DATA  
CD XLAT  
SCLK  
CD CKO  
SENS  
22  
HOLD SW 21  
AGC CONT 20  
BATT (H)  
CHECK  
Q603  
LD  
DRIVE  
Q101  
BATT  
TRACKING/FOCUS COIL DRIVE  
SLED/SPINDLE/LOADING MOTOR DRIVE  
IC7  
GFS  
FOK  
FOK  
BUS INTERFACE  
IC601  
FFDR  
FRDR  
FOCUS  
32  
31  
XTALI  
XIN  
22  
21  
42  
43  
10  
11  
FOCUS  
COIL  
COIL  
X2  
16MHz  
X1  
10MHz  
BATT (L)  
CHECK  
DRIVE  
10  
13  
12  
3
2
1
BATT  
32  
32  
XTALO  
XOUT  
TFDR  
TRACKING  
COIL  
DRIVE  
25  
24  
40  
41  
8
9
SERVO  
TRACKING  
COIL  
TRDR CTL  
RESET  
SW4  
(LIMIT)  
SSTP  
11  
10  
62  
63  
Q602  
M902  
SFDR  
SRDR  
SLED  
MOTOR  
DRIVE  
SW1  
(DOWN)  
D SW  
6
7
31  
32  
38  
39  
BUS ON  
CONT  
SLED  
MOTOR  
SW3  
(DISC IN)  
IN SW  
SELF SW  
8
7
M901  
SPINDLE  
MOTOR  
SPINDLE  
MOTOR  
DRIVE  
12  
13  
9
8
6
5
4
3
2
1
MDP  
SW2  
(SELF)  
18  
35  
DATA  
6
4
CLK  
M903  
LOADING  
MOTOR  
LOADING  
MOTOR  
DRIVE  
LM EJ  
5
4
1
2
69  
66  
40  
70  
20  
22  
23  
11  
CN601  
BUS  
CONTROL IN  
LM LOD  
SLED –  
DRV OE  
LD ON  
HOLD  
AGC CONT  
MUTE 1 34  
MUTE 2 35  
BUS SO 53  
SRST  
BUS CLK  
BUS SI  
BUS ON  
BU CHECK  
UNI SO  
2
DISPLAY  
SECTION  
(Page 36)  
LINK OFF  
SIRCS  
34  
34  
Download from Www.Somanuals.com. All Manuals Search And Download.  
                     
CDX-M620/M670  
4-4. BLOCK DIAGRAM — TUNER SECTION —  
CN302  
–1  
L
BUS AUDIO IN  
–2  
ATT  
CDL  
CD  
SECTION  
(Page 34)  
R-CH  
R-CH  
R-CH  
R
EXCEPT M670:US  
4
ELECTRONIC VOLUME  
IC305  
IC304  
–5  
4
AUXL  
28  
3
5
1
7
L
OUT FL  
AUDIO OUT  
FRONT  
Q301  
Q303  
43  
38  
MDL  
ACOUTL  
M670:US  
–6  
IC310  
LINE  
AMP  
R
(Page 36)  
5
7
33  
AC INL  
TUNER UNIT  
TUX201  
–3  
27  
L
OUT RL  
3
SA CLK  
SA OUT  
35  
38  
SA CLK  
SA OUT  
AUDIO OUT  
REAR  
–4  
AJ1  
(ANTENNA)  
DISPLAY SECTION  
AM ANT  
FM ANT  
1
2
R
EXCEPT M670:US  
MPX  
10  
8
13  
MPX  
AMDET  
11  
15  
14  
20  
21  
17  
18  
AM  
CN301  
MP IN  
S METER  
SDA  
SCL  
QUAL  
EXT ATT  
L
IC310  
SUB OUT (MONO)  
3
1
24  
R
SWR  
FM AMP  
Q202  
Q305  
MUTE  
CONTROL  
Q310,312  
EXCEPT M670:US  
M670:US  
SYSTEM CONTROL  
IC501 (2/3)  
POWER AMP  
IC309  
CN101  
1
31  
50  
VOL ATT  
QUALITY  
IC307  
Q309  
FL+  
5
NOISE  
CANCEL  
IC201  
FL  
6
7
3
5
1
7
12  
11  
Q203  
9
2
FL–  
3
9
PRE  
AMP  
56  
NS MASK  
RL+  
RL  
10  
EXCEPT M670:US  
RL–  
7
22 MUTE  
STBY  
RDS DECODER  
IC202  
55  
16  
4
ST-BY  
TEL ATT  
4
12  
3
FR+  
FR–  
RR+  
RR–  
ILL IN 95  
RDSDET  
SDA  
SCL  
9
16  
4
9
10  
MPX  
OSCO  
Q406  
81  
ACC IN  
R-CH  
ILLUM CHECK  
Q407  
X201  
4.3MHz  
11  
73  
74  
X1A  
X501  
32.768kHz  
MPTH  
DAVN  
5
20  
2
8
52  
75  
OSCI  
LV IN  
MPTH  
DAVN  
ACC CHECK  
Q405  
13  
14  
7
TEL MUTE  
ILL  
ACC  
X0A  
AEP,UK,E  
15  
TEST  
84  
S METER  
SDA  
S-METER TEST IN  
14  
12  
13  
53  
70  
71  
Q402  
Q404  
I2CSDA  
PW ON  
I2CSCL  
X0  
83  
92  
SCL  
5
6
POWER  
POWER  
CONT  
Q401  
X503  
3.68MHz  
AMP REM  
ANT REM  
BATT  
CONT  
AUDIO 9V  
9V  
SDA  
SCL  
E2PSDA  
X1  
17  
18  
10  
11  
93  
EEPROM  
Q110,111  
E2PSCL  
114  
TUN ON  
• Signal path  
POWER  
CONT  
Q107,108  
F901  
-11V  
16  
TUNER 8V  
BATT  
9V  
BATT  
: FM  
POWER  
CONT  
: AM/MW  
: CD  
• R-ch : same as L-ch.  
DC-DC  
CONVERTER  
IC306  
1
8
5
BATT  
Q306-308  
REG  
Q201  
TUNER 5V  
+11V  
35  
35  
Download from Www.Somanuals.com. All Manuals Search And Download.  
                     
CDX-M620/M670  
4-5. BLOCK DIAGRAM — DISPLAY SECTION —  
(Page 35)  
SUB SYSTEM CONTROL  
IC702  
3
SA CLK  
SA IN  
TUNER  
BUS SI  
UNI SO  
98 UNI SI  
97 UNI SO  
1
112  
SA CLK  
SA OUT  
SYSTEM CONTROL  
IC501 (3/3)  
SECTION  
UNI CKI  
BUS ON  
BU IN  
BUS CLK  
BUS ON  
BU CHECK  
101  
38  
34  
AD ON  
2
BU 5V  
SW  
CD  
Q501  
SECTION  
(Page 34)  
80  
79  
AD ON  
BUF  
IC701  
SYS RES  
LINK OFF  
S RST  
6
7
81  
50  
LINK OFF  
KEY ACK  
SIRCS  
D70  
AEP,UK,E  
IR  
16 RECEIVE  
IC62  
7
7
72  
48  
RC IN1  
RC IN0  
J651  
(REMOTE IN)  
D908  
IR  
16 RECEIVE  
IC901  
46  
47  
KEY IN  
MATRIX  
KEY IN0  
KEY IN1  
LCD DRIVER  
IC60  
XTAL  
85  
86  
BOOT  
LED SW2  
LED SW1  
EXTAL  
57  
47  
46  
106  
116  
115  
BOOT  
LED SW2  
LED SW1  
X701  
18.432MHz  
(Page 34)  
97 99 100 98 86 85  
RX  
LCD SO/TX  
62  
60  
12  
13  
RX  
TX  
1
VOLTAGE CHECK  
IC102  
CEO  
INH  
CKO  
CEI  
CD  
66  
CD ON  
MD ON  
ILL ON  
52  
82  
69  
64  
70  
71  
FLSWPWON  
SECTION  
POWER  
CONT.  
LCD60  
REG  
LCD  
REG  
CD 6V  
BATT  
2
1
57  
DDC ON  
Q117,118  
Q114,115  
MT +B  
1
3
BATT  
IC652  
CE2  
2
M601  
OPEN/CLOSE  
MOTOR  
REG  
Q119  
POWER  
CONT.  
Q60,61  
DIMMER  
CONTLROL  
Q62  
9V  
CD 5V  
LCD 9V  
REG  
Q113,116  
BU 5V  
MOTOR  
DRIVE  
IC651  
3
POWER  
CONT.  
Q109,112  
MOT+  
MOT–  
11  
6
98  
97  
97 99 100 98  
LCD9V  
9V  
14  
16  
12  
LCD DRIVER  
IC61  
VREF  
CONT.  
MT +B  
CN902  
Q651,652  
BEEP  
DRIVE  
Q502  
ILL ON 9V  
LCD 9V  
FPCRTL  
I DET  
15  
BEEP  
40  
96  
BZ501  
TX (SO)  
RX (SI)  
FL SW  
I
I
POWER  
CONT.  
3
7
DET  
Q650  
DET  
BATT  
IC650  
DC/DC CONV.  
CONTROL  
IC101  
Q101,102  
97 98 99 100  
SW1001  
9
OPEN SW  
(OPEN/CLOSE)  
100  
99  
VCC  
LCD1  
LCD DRIVER  
IC1  
ON/OFF  
DRIVE  
Q103  
D903  
(DISC IN)  
CLOSE SW  
CD 6V  
9V  
OUT1  
INA1  
7
3
LED  
DRIVE  
SW1002  
(CENTER)  
84  
86  
Q901,902  
SHIFT  
Q105  
CENTER SW  
FLASH W  
101  
69  
37  
2
RT  
SHIFT  
ON/OFF  
DRIVE  
Q106  
OUT2 10  
INA2 14  
POWER  
CONT.  
Q1,2  
DIMMER  
CONTLROL  
Q3  
LSW60  
OPEN  
LCD 9V  
OPEN KEY  
61  
(DISPLAY BOARD)  
NOSE SW  
62  
64  
S1  
DETACH  
DETACH SW  
36  
36  
Download from Www.Somanuals.com. All Manuals Search And Download.  
                               
CDX-M620/M670  
• Waveforms  
• Waveforms  
— Main Board —  
(MODE: FM)  
THIS NOTE IS COMMON FOR PRINTED WIRING  
BOARDS AND SCHEMATIC DIAGRAMS.  
(In addition to this, the necessary note is  
printed in each block.)  
— Servo Board —  
(MODE: CD PLAY)  
1
1
for schematic diagram:  
• All capacitors are in µF unless otherwise noted. pF: µµF  
50 WV or less are not indicated except for electrolytics  
and tantalums.  
3.8Vp-p  
0V  
• All resistors are in Ω and 1/4 W or less unless otherwise  
specified.  
Approx. 200mVp-p  
4.332MHz  
(TE)  
(OSCD)  
IC1  
IC202  
qd  
4
•
•
%
f
: indicates tolerance.  
: internal component.  
2
3
4
5
2
3
4
5
• C : panel designation.  
5.4Vp-p  
0V  
Note: The components identified by mark 0 or dotted line  
with mark 0 are critical for safety.  
Approx. 620mVp-p  
32.768kHz  
Replace only with part number specified.  
(FE)  
(XOA)  
IC1  
IC501  
qf  
uf  
• A : B+ Line.  
• Power voltage is dc 14.4V and fed with regulated dc power  
supply from ACC and BATT cords.  
• Voltages are taken with a VOM (Input impedance 10 MΩ).  
Voltage variations may be noted due to normal produc-  
tion tolerances.  
• Waveforms are taken with a oscilloscope.  
Voltage variations may be noted due to normal produc-  
tion tolerances.  
2.6Vp-p  
1.2Vp-p  
3.68MHz  
(RFO)  
(XO)  
IC1  
IC501  
os  
qh  
• Circled numbers refer to waveforms.  
• Signal path.  
3.8Vp-p  
F
f
J
: FM  
: AM/MW  
: CD  
3.8Vp-p  
16.89MHz  
18.432MHz  
(XTAI)  
(EXTAL)  
IC501  
IC702  
ih  
ih  
for printed wiring boards:  
• X : parts extracted from the component side.  
• Y : parts extracted from the conductor side.  
a
•
•
: Through hole.  
: Pattern from the side which enables seeing.  
(The other layer’s patterns are not indicated.)  
3.5Vp-p  
2Vp-p  
10MHz  
4MHz  
Caution:  
(X IN)  
(XOUT)  
IC5  
IC801  
ea  
4
Pattern face side: Parts on the pattern face side seen from the  
(Side B)  
Parts face side: Parts on the parts face side seen from the  
(Side A) parts face are indicated.  
pattern face are indicated.  
37  
37  
Download from Www.Somanuals.com. All Manuals Search And Download.  
                   
CDX-M620/M670  
4-6. PRINTED WIRING BOARDS — CD MECHANISM SECTION —  
38  
38  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
• Semiconductor  
Location  
Ref. No. Location  
IC1  
IC5  
IC7  
IC501  
C-2  
C-6  
F-2  
F-5  
Q101  
B-2  
(Page 43)  
39  
39  
Download from Www.Somanuals.com. All Manuals Search And Download.  
         
CDX-M620/M670  
• Refer to page 37 for Waveforms.  
4-7. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (1/2) — • Refer to page 54 for IC Block Diagrams.  
IC B/D  
(Page 41)  
(Page 46)  
Note:  
• Voltage is dc with respect to  
ground under no-signal conditions.  
no mark : CD PLAY  
(Page 41)  
40  
40  
Download from Www.Somanuals.com. All Manuals Search And Download.  
               
CDX-M620/M670  
• Refer to page 37 for Waveforms.  
4-8. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (2/2) — • Refer to page 54 for IC Block Diagrams.  
(Page 40)  
IC B/D  
(Page 40)  
Note:  
• Voltage is dc with respect to  
ground under no-signal conditions.  
no mark : CD PLAY  
41  
41  
Download from Www.Somanuals.com. All Manuals Search And Download.  
           
CDX-M620/M670  
4-9. PRINTED WIRING BOARDS — MAIN SECTION —  
• Semiconductor Location  
Ref. No. Location Ref. No. Location  
D104  
D107  
D109  
D202  
D203  
D204  
D205  
D302  
D303  
D304  
D309  
D311  
D404  
D406  
D407  
D503  
D505  
D506  
D507  
D509  
D511  
D602  
D604  
D605  
D606  
D609  
D612  
D650  
D804  
D807  
K-8  
E-2  
G-2  
C-13  
B-13  
G-8  
G-9  
B-7  
B-6  
B-6  
G-7  
C-7  
C-4  
D-4  
C-6  
H-6  
H-5  
J-8  
IC502  
IC650  
IC651  
IC652  
IC702  
IC801  
J-9  
J-2  
I-3  
I-3  
I-12  
I-9  
Q101  
Q102  
Q105  
Q107  
Q108  
Q109  
Q110  
Q111  
Q112  
Q114  
Q115  
Q116  
Q117  
Q118  
Q201  
Q202  
Q203  
Q301  
Q302  
Q303  
Q304  
Q305  
Q306  
Q307  
Q308  
Q309  
Q310  
Q312  
Q401  
Q402  
Q404  
Q405  
Q406  
Q407  
Q602  
Q651  
Q652  
F-2  
F-1  
E-3  
H-4  
G-4  
K-9  
F-4  
E-4  
K-8  
D-2  
E-2  
E-2  
G-1  
G-1  
C-13  
H-10  
G-9  
B-10  
B-9  
B-11  
B-10  
B-11  
E-8  
E-7  
E-8  
C-8  
C-7  
C-8  
C-4  
D-5  
D-5  
D-6  
D-7  
D-6  
G-5  
J-3  
J-8  
I-8  
H-5  
F-5  
G-4  
F-5  
G-4  
G-7  
G-6  
I-2  
J-10  
H-10  
IC101  
IC102  
IC201  
IC202  
IC301  
IC302  
IC303  
IC304  
IC305  
IC306  
IC307  
IC308  
IC310  
IC501  
F-2  
D-2  
G-9  
F-13  
G-8  
F-9  
C-11  
C-11  
E-10  
E-8  
D-9  
D-9  
C-12  
I-6  
I-3  
(Page 50)  
42  
42  
Download from Www.Somanuals.com. All Manuals Search And Download.  
                                         
CDX-M620/M670  
(Page 39)  
(Page 48)  
Ref. No. Location  
• Semiconductor Location  
Ref. No. Location Ref. No. Location  
Ref. No. Location  
Ref. No. Location  
Ref. No. Location  
Ref. No. Location  
D101  
D102  
D105  
D106  
D301  
D305  
E-3  
F-3  
D-1  
E-2  
B-7  
B-8  
D306  
D307  
D308  
D401  
D405  
D501  
B-8  
B-8  
B-8  
B-3  
C-5  
B-2  
D502  
D504  
D508  
D510  
D603  
D607  
H-4  
I-4  
H-4  
G-4  
G-5  
G-4  
D608  
D610  
D611  
D651  
D652  
D801  
G-7  
B-2  
B-2  
I-3  
J-4  
J-12  
D802  
D803  
D805  
D806  
J-10  
J-5  
J-10  
J-11  
IC601  
IC701  
G-5  
I-12  
Q119  
Q501  
Q502  
Q603  
Q650  
F-1  
I-5  
G-14  
G-5  
I-2  
Q103  
Q106  
Q113  
E-2  
F-2  
E-1  
IC309  
A-7  
43  
43  
Download from Www.Somanuals.com. All Manuals Search And Download.  
         
CDX-M620/M670  
• Refer to page 37 for Waveforms.  
4-10. SCHEMATIC DIAGRAM — MAIN SECTION (1/4) — • Refer to page 54 for IC Block Diagrams.  
(Page 45)  
IC B/D  
(Page 46)  
Note:  
• Voltage is dc with respect to ground under  
no-signal (detuned) condition.  
no mark : FM  
44  
44  
Download from Www.Somanuals.com. All Manuals Search And Download.  
           
CDX-M620/M670  
4-11. SCHEMATIC DIAGRAM — MAIN SECTION (2/4) — • Refer to page 54 for IC Block Diagrams.  
IC B/D  
(Page  
44)  
IC B/D  
IC B/D  
(Page 46)  
Note:  
• Voltage is dc with respect to ground under  
no-signal (detuned) condition.  
no mark : FM  
45  
45  
Download from Www.Somanuals.com. All Manuals Search And Download.  
                               
CDX-M620/M670  
• Refer to page 37 for Waveforms.  
4-12. SCHEMATIC DIAGRAM — MAIN SECTION (3/4) — • Refer to page 54 for IC Block Diagrams.  
(Page 45)  
(Page 44)  
IC B/D  
(Page 40)  
(Page 47)  
IC B/D  
Note:  
• Voltage is dc with respect to ground under  
no-signal (detuned) condition.  
no mark : FM  
(
<
) : AM/MW/LW  
> : CD PLAY  
46  
46  
Download from Www.Somanuals.com. All Manuals Search And Download.  
                     
CDX-M620/M670  
• Refer to page 37 for Waveforms.  
4-13. SCHEMATIC DIAGRAM — MAIN SECTION (4/4) — • Refer to page 54 for IC Block Diagrams.  
(Page 51)  
(Page  
46)  
(Page 49)  
IC B/D  
Note:  
• Voltage is dc with respect to ground under  
no-signal (detuned) condition.  
no mark : FM  
47  
47  
Download from Www.Somanuals.com. All Manuals Search And Download.  
                       
CDX-M620/M670  
4-14. PRINTED WIRING BOARD — SUB (CD) SECTION —  
(Page 43)  
• Semiconductor  
Location  
Ref. No. Location  
D901  
D902  
D903  
D906  
D907  
(D908)  
B-10  
B-6  
B-7  
B-10  
B-6  
B-13  
IC901  
B-13  
Q901  
Q902  
B-9  
B-9  
(
) : SIDE B  
48  
48  
Download from Www.Somanuals.com. All Manuals Search And Download.  
   
CDX-M620/M670  
4-15. SCHEMATIC DIAGRAM — SUB (CD) SECTION — • Refer to page 55 for IC Block Diagram.  
(Page 47)  
IC B/D  
Note:  
• Voltage is dc with respect to ground under  
no-signal (detuned) condition.  
no mark : FM  
49  
49  
Download from Www.Somanuals.com. All Manuals Search And Download.  
     
CDX-M620/M670  
4-16. PRINTED WIRING BOARD — KEY SECTION —  
• Semiconductor Location  
Ref. No. Location Ref. No. Location  
Ref. No. Location  
(D7)  
(D8)  
A-8  
A-9  
LED5  
LED6  
LED7  
LED8  
LED9  
LED10  
LED11  
LED12  
LED13  
B-2  
B-3  
C-1  
C-3  
C-13  
C-2  
A-3  
A-2  
C-13  
LED14  
LED15  
LED16  
LED17  
LED18  
A-13  
A-11  
C-11  
B-12  
C-12  
(Page 52)  
(Page 42)  
(IC1)  
B-7  
LED1  
LED2  
LED3  
LED4  
B-4  
B-10  
B-2  
B-3  
Q1  
Q2  
Q3  
A-4  
A-3  
B-4  
(
) : SIDE B  
50  
50  
Download from Www.Somanuals.com. All Manuals Search And Download.  
     
CDX-M620/M670  
4-17. SCHEMATIC DIAGRAM — KEY SECTION —  
(Page 53)  
(Page  
47)  
Note:  
• Voltage is dc with respect to ground under no-signal  
(detuned) condition.  
no mark : FM  
51  
51  
Download from Www.Somanuals.com. All Manuals Search And Download.  
     
CDX-M620/M670  
4-18. PRINTED WIRING BOARD — DISPLAY SECTION —  
(Page 50)  
• Semiconductor Location  
Ref. No. Location Ref. No. Location  
Ref. No. Location  
(D61)  
(D62)  
(D63)  
(D64)  
(D65)  
(D66)  
(D67)  
(D68)  
(D70)  
A-11  
A-2  
A-2  
A-3  
A-3  
(IC60)  
(IC61)  
(IC62)  
B-9  
B-11  
A-13  
LED66  
LED67  
LED68  
LED69  
B-2  
B-12  
C-2  
C-12  
LED60  
LED62  
LED63  
LED64  
LED65  
A-1  
A-2  
A-12  
B-2  
B-12  
A-3  
(Q60)  
(Q61)  
(Q62)  
A-2  
A-2  
B-2  
B-10  
A-12  
A-13  
(
) : SIDE B  
52  
52  
Download from Www.Somanuals.com. All Manuals Search And Download.  
       
CDX-M620/M670  
4-19. SCHEMATIC DIAGRAM — DISPLAY SECTION — • Refer to page 55 for IC Block Diagrams.  
(Page  
51)  
IC B/D  
Note:  
• Voltage is dc with respect to ground under no-signal  
(detuned) condition.  
no mark : FM  
53  
53  
Download from Www.Somanuals.com. All Manuals Search And Download.  
       
CDX-M620/M670  
• IC BLOCK DIAGRAMS  
IC1 CXA2596M  
IC7 LA6576L-TE-L  
IC306 TC7660SE0A713  
V+  
OSC  
LV  
8
7
6
5
APC PD AMP  
GND  
+
–
FWD  
REV  
1
36 S-GND  
VCC  
HOLD  
1
VCC  
24  
23  
22  
21  
20  
19  
18  
17  
16  
15  
14  
13  
VCC  
INPUT  
VOUT  
VEE  
+
–
CH2-CH4 OUTPUT  
ON/OFF  
2
3
4
5
6
7
8
9
35  
34  
MUTE2  
MUTE1  
VIN4  
MUTE2  
LC/PD  
LD ON  
HOLD SW  
AGCCONT  
RF BOT  
RFTC  
RF I  
AGCVTH  
2
3
RC  
RC  
VEE  
+
–
+2  
1
BOOST  
CH1 OUTPUT  
ON/OFF  
+
–
OSCILLATOR  
OSCILLATOR  
VCC2  
VL0–  
VL0+  
VO4+  
VO4–  
VO3+  
VO3–  
APC LD AMP  
MUTE1  
LOGIC  
NETWORK  
LD  
PD  
A
33  
32  
31  
30  
29  
28  
INTERNAL  
VOLTAGE  
REGULATOR  
OUTPUT  
CONTROL  
VCC  
VC  
VIN4–  
4
–
+
+
–
2
3
4
CAP+  
GND  
CAP–  
–
+
+
–
VIN4+  
LEVEL  
SHIFT  
5
–
+
VREF-IN  
VIN1-SW  
VREF-OUT  
+
–
+
–
B
VC  
6
VIN1/VREF SW  
+
–
LEVEL  
SHIFT  
VEE  
C
7
+
–
+
–
VC  
VC  
IC101 TL1451ACDB-E20  
IC601 BA8270F-E2  
–
+
D
8
RF SUMMING AMP  
RF EQ AMP  
BUS ON  
SWITCH  
14 VCC  
5V REG  
BUS ON  
1
2
3
16  
VERF.  
15  
14  
13  
12  
11  
10  
9
+
–
VC  
VO2+  
VO2–  
REG-OUT  
REG-IN  
VIN3+  
VIN3–  
VIN3  
10  
11  
12  
13  
14  
15  
16  
17  
18  
RFO  
27  
26  
25  
24  
23  
22  
21  
20  
19  
VEE  
F
ERROR AMP  
FOCUS  
9
VEE  
RESET  
SWITCH  
+2.5V  
13  
RESET  
VC  
RST  
VCC  
–
+
LEVEL  
SHIFT  
12 BUS ON  
11 CLK IN  
10 BU IN  
REFERENCE  
VOLTAGE  
+
–
PWM  
COMPA-  
RATOR2  
ERROR  
AMP2  
+
–
VC  
BATTERY  
SWITCH  
BATT  
RFE  
10  
11  
12  
+2.5V  
VERF  
OUTPUT2  
OUTPUT1  
VO1+  
SHORT  
CIRCUIT  
4
5
6
CLK  
VREF  
DATA  
VERF  
VERF  
+
–
LEVEL  
SHIFT  
–
+
PROTECTION  
COMPARATOR  
–
+
FE  
E
9
8
DATA IN  
VO1–  
+
+
–
VC  
VC  
–
+
S
R
R
GND  
7
DATA OUT  
LATCH  
U.V.L.O  
VREF/2  
PWM  
COMPA-  
RATOR1  
VCC1  
VC BUFFER  
TE  
VC  
VCC  
VEE  
+
TRACKING  
ERROR AMP  
–
+
–
VC  
–
+
VIN1  
VIN2+  
VIN2–  
TRIANGLE  
OSCILLATOR  
VC  
+
–
–
+
ERROR  
AMP1  
GND  
2
3
4
5
6
7
8
1
VIN1–A  
VIN1+A  
VIN1–B  
IC202 SAA6588T-V2-118  
AMP-A  
–
+
VIN2  
20  
19  
18  
17  
16  
15  
14  
13  
12 11  
–
+
VIN1 +B  
POWER SUPPLY  
& RESET  
PAUSE  
AMP-B  
DETECTOR  
MULTI  
PATH  
IC651 BA6288FS-E2  
IC102 RN5VD53AA-TL  
57kHz  
DETECTOR  
8th ORDER  
BAND-PASS FILTER  
GND  
NC  
1
16 RNF  
15 NC  
5
4
2
3
4
5
6
7
8
CLOCKED  
SIGNAL QUALITY  
DECODER  
DRIVER  
DRIVER  
COMPARATOR  
OUT1  
M BATT  
VCC  
14 OUT2  
13  
NC  
RESET  
2
4
5
4
CLOCK  
CLOCK  
DATA  
POWER  
SAVE  
12 VREF  
11 OPEN  
10 NC  
RDS/RDBS  
RDS/RDBS  
DECODER  
INTERFACE  
REGISTER  
3
1
DEMODULATOR  
CLOSE  
NC  
DATA  
NC  
TSD  
9
NC  
TEST  
OSCILLATOR  
& CLOCK  
IIC BUS SLAVE  
TRANSCEIVER  
CONTROL  
1
2
3
4
5
6
7
8
9
10  
54  
54  
Download from Www.Somanuals.com. All Manuals Search And Download.  
               
CDX-M620/M670  
IC305 TDA7406TR  
33 32 31  
30  
29  
28  
27  
26  
25  
24 23  
MIXER  
MONO- MONO-  
FADER FADER  
MONO- MONO-  
FADER FADER  
MONO- MONO-  
FADER FADER  
ACINLF 34  
SWINR 35  
SWINL 36  
FRONT  
REAR  
SW  
SUBWOOFER  
+PHASE  
CONTROL  
ACIN  
OUTPUT  
SELECTOR  
ACOUTR 37  
ACOUTL 38  
MAIN  
SECOND  
CREF 39  
22 VDD  
LP  
VOICE  
BANDPASS  
21 SCL  
20 SDA  
HP  
BASS  
SUPPLY  
19 GND  
TREBLE  
HIGH-CUT  
18 EXT-ATT  
VOLUME  
SOFTMUTE  
LOUDNESS  
S&H  
PULSE  
FORMER  
25kHz  
LP  
QUAL  
17 QUAL  
COMPANDER  
LOUDNESS  
16 MPOUT  
15 MPIN  
MULTIPATH  
DETECTOR  
DEMODULATOR  
+STEREO ADJUST  
+STEREO BLAND  
MUX 40  
IN-GAIN  
MUTE  
+
BEEP  
D/A  
CONVERTER  
14 S-METER  
IN-GAIN  
+AUTO ZERO  
PILOT  
CANCELATION  
PIL DET  
PLL  
MAIN SOURCE  
SELECTOR  
MIXING  
SECOND SOURCE  
SELECTOR  
SELECTOR  
MD1 41  
MD1G 42  
MAIN  
80kHz  
LP  
13 MPX  
12 AMIF  
INPUT  
MULTIPLEXER  
FM  
AM  
11  
MD2 43  
MD2G 44  
PHONO  
MAIN  
AM/FM  
NOISE BLANKER  
CH0  
AUX  
1
2
3
4
5
6
7
8
9
10  
IC62, 901 RRX9000-0601  
V IN  
16  
GND  
15  
V IN  
14  
V AGC  
13  
INS GNDVCO NC  
12 11 10  
9
INPUT  
SLAGE  
320kHz  
/500kHz  
NOISE  
SUPPRESSION  
320kHz  
PULSE  
COUNTER  
AGC  
PULSE  
FORMER  
BANDGAP  
REFERENCE  
1
2
3
4
5
6
7
8
L IN GND V STAB  
VCC  
NC NC  
VPO  
NC  
55  
Download from Www.Somanuals.com. All Manuals Search And Download.  
     
CDX-M620/M670  
SECTION 5  
EXPLODED VIEWS  
NOTE:  
The components identified by  
mark 0 or dotted line with mark  
0 are critical for safety.  
Replace only with part number  
specified.  
• The mechanical parts with no reference  
number in the exploded views are not supplied.  
• Items marked “*” are not stocked since  
they are seldom required for routine service.  
Some delay should be anticipated  
when ordering these items.  
• Color Indication of Appearance Parts  
Example :  
KNOB, BALANCE (WHITE) ... (RED)  
R
R
Parts Color Cabinet’s Color  
• Accessories and packing materials and  
• -XX and -X mean standardized parts, so  
they may have some difference from the  
original one.  
hardware (# mark) list are given in  
the last of this parts list.  
5-1. CHASSIS SECTION  
9
#2  
#2  
2
MG-383Z-121//K  
#1  
1
8
4
7
#1  
A
#2  
6
3
5
#2  
A
CN901  
#2  
8
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
* 1  
2
2
3-230-511-01 COVER  
1-776-207-72 CORD (WITH CONNECTOR) (POWER) (US)  
1-776-527-71 CORD (WITH CONNECTOR) (ISO) (POWER)  
* 4  
5
6
7
8
1-681-373-11 SUB (CD) BOARD  
3-230-515-01 SLIDER (FLEXIBLE)  
3-230-514-01 COVER (FLEXIBLE)  
3-230-516-01 SPRING (FLEXIBLE), TENSION  
3-045-756-01 SCREW (PANEL)  
(AEP,UK,E)  
3
3
X-3380-551-1 PANEL (CD) SUB ASSY, SUB (M670:US)  
X-3380-552-1 PANEL (CD) SUB ASSY, SUB (M620)  
* 9  
3-045-743-01 BRACKET (CD)  
3
X-3380-554-1 PANEL (CD) SUB ASSY, SUB (AEP,UK,E)  
CN901 1-783-268-11 CABLE, FLAT 11P  
56  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
5-2. CAM SECTION  
59  
58  
57  
55  
#5  
M601  
56  
61  
60  
#4  
#2  
#2  
#2  
#5  
65  
#2  
63  
58  
64  
#2  
#2  
#5  
54  
62  
#12  
53  
51  
#5  
#5  
#5  
52  
66  
Ref. No.  
Part No.  
3-230-495-01 CAM (L)  
X-3380-549-1 ARM (B-R) ASSY  
X-3380-544-1 BRACKET (L) ASSY  
X-3380-548-1 ARM (B-L) ASSY  
X-3380-546-1 ARM (A-L) ASSY  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
51  
52  
53  
54  
55  
* 60  
* 61  
62  
63  
64  
1-681-375-11 SW BOARD  
X-3378-711-1 BRACKET (MOTOR) ASSY  
3-230-494-01 GEAR (C)  
3-230-496-01 CAM (R)  
X-3380-545-1 BRACKET (R) ASSY  
56  
57  
58  
59  
3-376-464-11 SCREW (+PTT 2.6X6), GROUND POINT  
3-045-714-01 GEAR (B)  
3-342-940-01 WASHER (M)  
65  
66  
M601  
3-030-909-11 DAMPER, OIL  
X-3380-547-1 ARM (A-R) ASSY  
X-3378-769-1 MOTOR ASSY (OPEN/CLOSE)  
3-045-713-01 GEAR (A)  
57  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
5-3. MAIN BOARD SECTION  
113  
#2  
#2  
#2  
#3  
108  
114  
112  
107  
#2  
#2  
#2  
110  
115  
#2  
109  
#2  
111  
#2  
104  
TUX201  
106  
105  
107  
F901  
106  
104  
103  
103  
102  
101  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
101  
* 102  
103  
104  
105  
X-3380-558-1 CHASSIS (CD) ASSY  
3-230-417-01 SHEET, INSULATING  
3-230-493-01 GEAR (DRIVE SHAFT)  
3-230-444-01 GUIDE (DRIVE SHAFT)  
3-045-721-01 SHAFT, DRIVE  
* 109  
* 110  
* 111  
* 112  
* 112  
3-230-513-01 HEAT SINK (REG)  
3-230-509-01 CHASSIS, BACK  
3-019-565-01 BRACKET (IC)  
3-230-510-21 HEAT SINK (US)  
3-230-510-31 HEAT SINK (AEP,UK,E)  
106  
107  
* 108  
* 108  
* 108  
3-040-692-01 RING, CE TYPE RETAINING  
113  
114  
115  
F901  
1-777-246-41 CORD (WITH CONNECTOR) (ANT)  
3-376-464-11 SCREW (+PTT 2.6X6), GROUND POINT  
A-3283-172-A MAIN BOARD, COMPLETE (M670:US)  
A-3283-173-A MAIN BOARD, COMPLETE (M620)  
A-3283-174-A MAIN BOARD, COMPLETE (AEP,UK,E)  
1-790-375-21 CORD (WITH CONNECTOR) (SUB OUT (MONO))  
1-757-775-11 CORD (WITH CONNECTOR) (AUX-IN (AUDIO))  
1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A  
TUX201 A-3220-813-A TUNER UNIT (TUX-020)  
58  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
5-4. FRONT PANEL (KEY) ASSY SECTION  
front panel (DSPL) assy  
171  
#6  
172  
173  
174  
170  
169  
178  
175  
not supplied  
(KEY board)  
#6  
168  
166  
LCD1  
176  
164  
177  
167  
165  
162  
163  
159  
161  
160  
156  
153  
157  
158  
151  
152  
155  
154  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
151  
151  
151  
152  
153  
X-3380-536-1 PANEL (KEY) SUB ASSY, FRONT (M670:US)  
X-3380-537-1 PANEL (KEY) SUB ASSY, FRONT (M620)  
X-3380-539-1 PANEL (KEY) SUB ASSY, FRONT (AEP,UK,E)  
3-230-483-01 BUTTON (ENTER)  
* 164  
165  
166  
* 167  
* 168  
3-230-486-01 HOLDER (LCD-KEY)  
1-694-808-21 CONDUCTIVE BOARD, CONNECTION  
1-694-807-21 CONDUCTIVE BOARD, CONNECTION  
3-230-487-01 PLATE (LCD-KEY), LIGHT GUIDE  
3-230-488-01 SHEET (LCD-KEY), DIFFUSION  
3-230-482-01 BUTTON (EQ7)  
154  
155  
156  
157  
158  
3-230-480-01 BUTTON (EJECT)  
3-230-481-01 BUTTON (SEEK)  
3-230-485-01 PLATE (RING), LIGHT GUIDE  
3-230-477-01 BUTTON (+/–)  
* 169  
170  
171  
172  
173  
3-230-415-01 SHEET (KEY), INSULATING  
X-3380-543-1 PANEL ASSY, BASE  
X-3380-560-1 SPRING (DETOUCH L) ASSY  
3-063-745-11 SCREW (+P M2 B TITE)  
3-230-490-01 GUIDE (DETOUCH)  
3-230-478-01 BUTTON (SOURCE)  
159  
160  
161  
161  
162  
3-230-484-01 BUTTON (CLOSE)  
174  
175  
176  
177  
178  
2-134-636-31 SCREW (M1.7X2.5)  
3-230-416-01 SCREW  
X-3380-561-1 SPRING (DETOUCH R) ASSY  
1-681-390-11 FLEXIBLE BOARD  
3-230-491-01 GUIDE (FLEXIBLE)  
3-231-433-01 CUSHION (ELECTROSTATIC)  
3-230-398-01 BUTTON (6 KEY) (US)  
3-230-398-11 BUTTON (6 KEY) (AEP,UK,E)  
3-230-479-01 BUTTON (MODE) (US)  
162  
* 163  
* 163  
3-230-479-11 BUTTON (MODE) (AEP,UK,E)  
A-3283-164-A KEY BOARD, COMPLETE (US)  
A-3283-176-A KEY BOARD, COMPLETE (AEP,UK,E)  
LCD1  
1-804-349-11 DISPLAY PANEL, LIQUID CRYSTAL  
59  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
5-5. FRONT PANEL (DSPL) ASSY SECTION  
212  
211  
213  
210  
207  
206  
209  
205  
LCD60  
214  
208  
207  
215  
204  
not supplied  
(DISPLAY board)  
#7  
203  
202  
201  
#7  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
201  
202  
203  
3-230-470-01 PANEL (FRONT BACK)  
3-230-472-01 SPRING (LOCK), TENSION  
3-230-471-01 LOCK (DETOUCH)  
* 209  
210  
211  
3-230-466-01 HOLDER (LCD-DSPL)  
3-230-426-01 BUTTON (OPEN)  
3-230-422-01 PLATE (LOGO), LIGHT GUIDE  
204  
* 205  
3-230-378-01 SHEET, INSULATING  
3-230-469-01 SHEET (DSPL), REFLECTION  
212  
213  
3-230-427-01 BUTTON (RESET-DSPL)  
X-3380-903-1 PANEL SUB (DSPL) ASSY, FRONT  
* 206  
207  
* 208  
3-230-467-01 PLATE (LCD-DSPL), LIGHT GUIDE  
1-694-806-21 CONDUCTIVE BOARD, CONNECTION  
3-230-468-01 SHEET (DSPL), DIFFUSION  
214  
215  
3-230-423-01 FILTER (IR-DSPL)  
3-232-858-01 CUSHION (LIGHT GUIDE PLATE)  
LCD60 1-804-348-11 DISPLAY PANEL, LIQUID CRYSTAL  
60  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
5-6. CD MECHANISM SECTION (1)  
(MG-383Z-121//K)  
252  
#8  
#8  
254  
253  
257  
259  
251  
266  
265  
264  
256  
264  
255  
C
255  
263  
M903  
261  
C
260  
#10  
262  
267  
258  
#9  
#8  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
* 251  
252  
253  
254  
255  
1-676-709-11 DISC IN SW BOARD  
3-040-039-01 CHASSIS (T)  
3-040-038-01 SPRING (LR), TENSION  
3-040-050-01 LEVER (L)  
3-040-022-01 RETAINER (ROLLER), SHAFT  
260  
* 261  
262  
263  
264  
3-040-040-01 ARM (ROLLER)  
A-3294-809-A SERVO BOARD, COMPLETE  
3-221-779-01 BRACKET (MOTOR)  
3-040-034-01 SPRING (RA), TENSION  
3-040-042-01 WASHER  
256  
257  
258  
259  
3-040-044-01 ROLLER (S)  
3-040-067-01 LEVER (R)  
A-3301-980-A SHAFT ROLLER ASSY  
265  
266  
267  
3-043-880-01 RING (RA), RETAINING  
3-044-206-11 SCREW, SPECIAL  
3-231-392-01 PLATE (CD), SHIELD  
3-040-037-01 GUIDE (DISC)  
M903  
A-3315-039-A MOTOR SUB ASSY, LO (LOADING)  
61  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
5-7. CD MECHANISM SECTION (2)  
(MG-383Z-121//K)  
304  
301  
306  
307  
307  
D
308  
314  
310  
not supplied  
312  
303  
305  
313  
311  
D
309  
302  
302  
302  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
301  
302  
303  
304  
305  
3-040-025-01 ARM, CHUCKING  
3-040-031-01 DAMPER (T)  
3-040-056-01 LEVER (D)  
3-040-024-01 RETAINER (DISC)  
3-040-054-01 WHEEL (LW), WORM  
308  
309  
310  
311  
312  
3-040-033-01 SPRING (KF1), TENSION  
A-3307-422-A CHASSIS (M) COMPLETE ASSY  
3-040-059-01 SPRING (TR), TENSION  
3-040-057-01 LEVER (LOCK)  
3-040-058-01 GEAR (MDL)  
306  
307  
3-040-026-01 SPRING (CH), TENSION  
3-040-032-01 SPRING (FL), COMPRESSION  
313  
314  
3-040-052-01 WHEEL (U), WORM  
3-040-051-01 LEVER (TR)  
62  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
5-8. CD MECHANISM SECTION (3)  
(MG-383Z-121//K)  
351  
M901  
(supplied with 351)  
352  
357  
M902  
353  
358  
#11  
359  
356  
360  
354  
#8  
355  
361  
#8  
The components identified by  
mark 0 or dotted line with mark  
0 are critical for safety.  
Replace only with part number  
specified.  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
351  
352  
353  
354  
355  
X-3378-480-1 CHASSIS (OP) ASSY (including M901)  
3-040-029-01 SPRING (SL), TORSION  
3-040-045-01 BASE (DRIVING)  
3-040-194-01 GEAR (MIDWAY)  
A-3301-983-A SHAFT (FEED) ASSY  
357  
* 358  
359  
0360  
361  
1-677-182-11 MOTOR FLEXIBLE BOARD  
1-676-708-11 LIMIT SW BOARD  
3-909-607-01 SCREW  
8-820-103-03 PICK-UP, OPTICAL KSS-720A/K1RP  
3-040-030-01 SPRING (FEED), PLATE  
356  
1-676-707-11 PICK-UP FLEXIBLE BOARD  
M902  
A-3301-985-A MOTOR ASSY, SLED (SLED)  
63  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
DISPLAY  
SECTION 6  
ELECTRICAL PARTS LIST  
NOTE:  
The components identified by  
mark 0 or dotted line with mark  
0 are critical for safety.  
Replace only with part number  
specified.  
• Due to standardization, replacements in  
the parts list may be different from the  
parts specified in the diagrams or the  
components used on the set.  
• -XX and -X mean standardized parts, so  
they may have some difference from the  
original one.  
• Items marked “*” are not stocked since  
they are seldom required for routine service.  
Some delay should be anticipated  
when ordering these items.  
• SEMICONDUCTORS  
In each case, u : µ, for example:  
uA.. : µA.. uPA.. : µPA..  
uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD..  
• CAPACITORS  
When indicating parts by reference  
number, please include the board.  
• RESISTORS  
All resistors are in ohms.  
METAL:Metal-film resistor.  
METAL OXIDE: Metal oxide-film resistor.  
F:nonflammable  
uF : µF  
• COILS  
uH : µH  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
FB60  
Part No.  
Description  
Remark  
DISPLAY BOARD  
**************  
< FERRITE BEAD >  
1-500-329-21 INDUCTOR, FERRITE BEAD  
< IC >  
1-694-806-21 CONDUCTIVE BOARD, CONNECTION  
3-230-378-01 SHEET, INSULATING  
*
*
*
3-230-466-01 HOLDER (LCD-DSPL)  
3-230-467-01 PLATE (LCD-DSPL), LIGHT GUIDE  
3-230-468-01 SHEET (DSPL), DIFFUSION  
IC60  
IC61  
IC62  
8-759-653-26 IC LC75878W  
8-759-653-26 IC LC75878W  
8-759-830-18 IC RRX9000-0601#1  
*
3-230-469-01 SHEET (DSPL), REFLECTION  
< CAPACITOR >  
< LIQUID CRYSTAL DISPLAY >  
LCD60 1-804-348-11 DISPLAY PANEL, LIQUID CRYSTAL  
< DIODE >  
C60  
C61  
C62  
C63  
C64  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-115-412-11 CERAMIC CHIP 680PF  
10%  
10%  
10%  
10%  
5%  
16V  
16V  
16V  
16V  
25V  
LED60 8-719-079-49 LED LWT673-R1S2-34 (SONY)  
LED62 8-719-076-58 LED NSSW440-BRS (LCD BACK LIGHT)  
LED63 8-719-076-58 LED NSSW440-BRS (LCD BACK LIGHT)  
LED64 8-719-076-58 LED NSSW440-BRS (LCD BACK LIGHT)  
LED65 8-719-076-58 LED NSSW440-BRS (LCD BACK LIGHT)  
C65  
C66  
C67  
C70  
C71  
1-165-176-11 CERAMIC CHIP 0.047uF 10%  
1-165-176-11 CERAMIC CHIP 0.047uF 10%  
1-165-176-11 CERAMIC CHIP 0.047uF 10%  
1-115-412-11 CERAMIC CHIP 680PF  
1-165-176-11 CERAMIC CHIP 0.047uF 10%  
16V  
16V  
16V  
25V  
16V  
5%  
LED66 8-719-076-58 LED NSSW440-BRS (LCD BACK LIGHT)  
LED67 8-719-076-58 LED NSSW440-BRS (LCD BACK LIGHT)  
LED68 8-719-076-58 LED NSSW440-BRS (LCD BACK LIGHT)  
LED69 8-719-076-58 LED NSSW440-BRS (LCD BACK LIGHT)  
C72  
C73  
C74  
C75  
C76  
1-165-176-11 CERAMIC CHIP 0.047uF 10%  
1-165-176-11 CERAMIC CHIP 0.047uF 10%  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-107-826-11 CERAMIC CHIP 0.1uF  
16V  
16V  
16V  
16V  
16V  
10%  
10%  
10%  
< SWITCH >  
LSW60 1-771-883-11 SWITCH, TACTILE (WITH LED) (OPEN)  
< TRANSISTOR >  
C77  
C78  
C79  
C80  
C81  
1-124-778-00 ELECT CHIP  
22uF  
20%  
10%  
10%  
5%  
6.3V  
25V  
6.3V  
50V  
16V  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-125-837-11 CERAMIC CHIP 1uF  
1-164-388-11 CERAMIC CHIP 270PF  
1-107-826-11 CERAMIC CHIP 0.1uF  
Q60  
Q61  
Q62  
8-729-106-60 TRANSISTOR 2SB1132-T101-QR  
8-729-038-67 TRANSISTOR KRC102S  
8-729-904-66 TRANSISTOR DTD113EK-T-146  
10%  
< CONNECTOR >  
1-815-500-21 PLUG, CONNECTOR 15P  
< DIODE >  
< RESISTOR >  
CN60  
R60  
R61  
R62  
R63  
R64  
1-216-829-11 METAL CHIP  
1-216-833-11 METAL CHIP  
1-216-829-11 METAL CHIP  
1-216-037-00 METAL CHIP  
1-216-037-00 METAL CHIP  
4.7K  
10K  
4.7K  
330  
330  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/10W  
1/10W  
D61  
D62  
D63  
D64  
D65  
8-719-422-41 DIODE MA8051-L-TX  
8-719-977-12 DIODE KDZ6.8V  
8-719-977-12 DIODE KDZ6.8V  
8-719-977-12 DIODE KDZ6.8V  
8-719-977-12 DIODE KDZ6.8V  
R65  
R66  
R67  
R68  
R69  
1-216-025-11 RES-CHIP  
1-216-025-11 RES-CHIP  
1-216-025-11 RES-CHIP  
1-216-025-11 RES-CHIP  
1-216-033-00 METAL CHIP  
100  
100  
100  
100  
220  
5%  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
1/10W  
D66  
D67  
D68  
D70  
8-719-977-12 DIODE KDZ6.8V  
8-719-420-14 DIODE MA8082-M(TX)  
8-719-977-12 DIODE KDZ6.8V  
R70  
R71  
1-216-864-11 SHORT  
1-216-033-00 METAL CHIP  
0
220  
8-719-083-14 DIODE RRX9000-0501  
5%  
1/10W  
64  
Download from Www.Somanuals.com. All Manuals Search And Download.  
     
CDX-M620/M670  
DISPLAY DISC IN SW KEY  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
R72  
R73  
R74  
R76  
R77  
1-216-811-11 METAL CHIP  
1-216-805-11 METAL CHIP  
1-216-864-11 SHORT  
1-216-841-11 METAL CHIP  
1-216-825-11 METAL CHIP  
150  
47  
0
47K  
2.2K  
5%  
5%  
1/16W  
1/16W  
C7  
C8  
C9  
C10  
1-165-176-11 CERAMIC CHIP 0.047uF 10%  
1-165-176-11 CERAMIC CHIP 0.047uF 10%  
1-164-156-11 CERAMIC CHIP 0.1uF  
16V  
16V  
25V  
50V  
5%  
5%  
1/16W  
1/16W  
1-162-974-11 CERAMIC CHIP 0.01uF  
< CONNECTOR >  
R78  
R79  
R80  
R81  
R82  
1-216-825-11 METAL CHIP  
1-216-825-11 METAL CHIP  
1-216-825-11 METAL CHIP  
1-216-817-11 METAL CHIP  
1-216-809-11 METAL CHIP  
2.2K  
2.2K  
2.2K  
470  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
CN1  
CN2  
1-815-499-21 CONNECTOR, FPC (ZIF) 18P  
1-815-501-11 SOCKET, CONNECTOR 15P  
100  
< DIODE >  
R83  
R84  
R85  
R86  
R87  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-841-11 METAL CHIP  
1-216-825-11 METAL CHIP  
1-216-825-11 METAL CHIP  
100  
100  
47K  
2.2K  
2.2K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
D7  
D8  
8-719-422-41 DIODE MA8051-L-TX  
8-719-422-80 DIODE MA8075-H-TX  
< IC >  
IC1  
8-759-653-26 IC LC75878W  
< LIQUID CRYSTAL DISPLAY >  
1-804-349-11 DISPLAY PANEL, LIQUID CRYSTAL  
< DIODE >  
R88  
R89  
R90  
R91  
R92  
1-216-825-11 METAL CHIP  
1-216-825-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
2.2K  
2.2K  
100  
100  
100  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
LCD1  
R93  
R94  
R95  
R96  
R97  
1-216-817-11 METAL CHIP  
1-216-864-11 SHORT  
1-216-846-11 METAL CHIP  
1-216-850-11 METAL CHIP  
1-216-033-00 METAL CHIP  
470  
0
120K  
270K  
220  
5%  
1/16W  
LED1  
LED2  
LED3  
LED4  
LED5  
8-719-079-26 LED NSSB440-WRST-THR (LCD BACK LIGHT)  
8-719-079-26 LED NSSB440-WRST-THR (LCD BACK LIGHT)  
8-719-078-39 LED CL-170SR-CD-T (RING ILLUMINATION)  
8-719-078-39 LED CL-170SR-CD-T (RING ILLUMINATION)  
8-719-078-39 LED CL-170SR-CD-T (RING ILLUMINATION)  
5%  
5%  
5%  
1/16W  
1/16W  
1/10W  
< SWITCH >  
LED6  
LED7  
LED8  
LED9  
8-719-078-39 LED CL-170SR-CD-T (RING ILLUMINATION)  
8-719-078-39 LED CL-170SR-CD-T (CLOSE)  
8-719-078-39 LED CL-170SR-CD-T (MODE)  
8-719-078-39 LED CL-170SR-CD-T (Z)  
S60  
1-771-884-11 SWITCH, TACTILE (WITH LED) (RESET)  
*************************************************************  
*
1-676-709-11 DISC IN SW BOARD  
LED10 8-719-078-39 LED CL-170SR-CD-T (OFF)  
****************  
LED11 8-719-078-39 LED CL-170SR-CD-T (DSPL/PTY)  
LED12 8-719-078-39 LED CL-170SR-CD-T (SCRL)  
LED13 8-719-078-39 LED CL-170SR-CD-T (ENTER)  
LED14 8-719-078-39 LED CL-170SR-CD-T (LIST)  
LED15 8-719-078-39 LED CL-170SR-CD-T (MENU)  
< SWITCH >  
SW2  
SW3  
1-529-566-21 SWITCH, PUSH (1 KEY) (SELF)  
1-529-566-21 SWITCH, PUSH (1 KEY) (DISC IN)  
*************************************************************  
LED16 8-719-078-39 LED CL-170SR-CD-T (SOUND)  
LED17 8-719-078-09 LED SLR-332CD-T32MN (DSO)  
LED18 8-719-078-09 LED SLR-332CD-T32MN (EQ7)  
*
*
A-3283-164-A KEY BOARD, COMPLETE (US)  
A-3283-176-A KEY BOARD, COMPLETE (AEP,UK,E)  
********************  
< SWITCH >  
1-694-807-21 CONDUCTIVE BOARD, CONNECTION  
1-694-808-21 CONDUCTIVE BOARD, CONNECTION  
3-230-486-01 HOLDER (LCD-KEY)  
3-230-487-01 PLATE (LCD-KEY), LIGHT GUIDE  
3-230-488-01 SHEET (LCD-KEY), DIFFUSION  
LSW1  
LSW2  
LSW5  
LSW6  
1-771-883-11 SWITCH, TACTILE (WITH LED) (–)  
1-771-476-11 SWITCH, KEYBOARD (WITH LED) (SOURCE)  
1-771-883-11 SWITCH, TACTILE (WITH LED) (+)  
1-771-476-11 SWITCH, KEYBOARD (WITH LED) (AF)  
*
*
*
(AEP,UK,E)  
< CAPACITOR >  
LSW7  
1-771-476-11 SWITCH, KEYBOARD (WITH LED) (1/REP)  
C1  
C2  
C3  
C4  
C5  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-115-412-11 CERAMIC CHIP 680PF  
10%  
10%  
10%  
10%  
5%  
16V  
16V  
16V  
16V  
25V  
LSW8  
LSW9  
1-771-476-11 SWITCH, KEYBOARD (WITH LED) (2/SHUF)  
1-771-476-11 SWITCH, KEYBOARD (WITH LED) (3)  
LSW10 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (6)  
LSW11 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (5)  
LSW12 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (4)  
C6  
1-165-176-11 CERAMIC CHIP 0.047uF 10%  
16V  
LSW13 1-771-883-11 SWITCH, TACTILE (WITH LED) (. m)  
65  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
CDX-M620/M670  
KEY LIMIT SW  
Ref. No.  
LSW15 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (TA)  
(AEP,UK,E)  
LSW18 1-771-883-11 SWITCH, TACTILE (WITH LED) (DISC –)  
LSW20 1-771-883-11 SWITCH, TACTILE (WITH LED) (DISC +)  
LSW22 1-771-883-11 SWITCH, TACTILE (WITH LED) (> M)  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
R42  
R43  
R44  
R45  
R46  
1-216-825-11 METAL CHIP  
1-216-825-11 METAL CHIP  
1-216-825-11 METAL CHIP  
1-216-825-11 METAL CHIP  
1-216-025-11 RES-CHIP  
2.2K  
2.2K  
2.2K  
2.2K  
100  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/10W  
(US)  
< TRANSISTOR >  
R47  
R48  
R49  
R50  
1-216-029-00 METAL CHIP  
1-216-029-00 METAL CHIP  
1-216-029-00 METAL CHIP  
1-216-025-11 RES-CHIP  
150  
150  
150  
100  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
Q1  
Q2  
Q3  
8-729-106-60 TRANSISTOR 2SB1132-T101-QR  
8-729-038-67 TRANSISTOR KRC102S  
8-729-904-66 TRANSISTOR DTD113EK-T-146  
(US)  
< RESISTOR >  
R51  
1-216-029-00 METAL CHIP  
150  
5%  
1/10W  
R1  
R2  
R3  
R4  
R5  
1-216-837-11 METAL CHIP  
1-216-835-11 METAL CHIP  
1-216-833-11 METAL CHIP  
1-216-831-11 METAL CHIP  
1-216-829-11 METAL CHIP  
22K  
15K  
10K  
6.8K  
4.7K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
R52  
R53  
R54  
R55  
1-216-029-00 METAL CHIP  
1-216-029-00 METAL CHIP  
1-216-029-00 METAL CHIP  
1-216-029-00 METAL CHIP  
150  
150  
150  
150  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
1/10W  
< SWITCH >  
R6  
R7  
R8  
R9  
R10  
1-216-827-11 METAL CHIP  
1-216-825-11 METAL CHIP  
1-216-823-11 METAL CHIP  
1-216-823-11 METAL CHIP  
1-216-821-11 METAL CHIP  
3.3K  
2.2K  
1.5K  
1.5K  
1K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
S1  
S2  
S3  
S4  
S7  
1-786-101-11 SWITCH, DETECTION (DETOUCH)  
1-771-884-11 SWITCH, TACTILE (WITH LED) (CLOSE)  
1-692-135-21 SWITCH, KEYBOARD (MODE)  
1-771-884-11 SWITCH, TACTILE (WITH LED) (Z)  
1-692-135-21 SWITCH, KEYBOARD (OFF)  
R11  
R12  
R13  
R14  
R15  
1-216-819-11 METAL CHIP  
1-216-819-11 METAL CHIP  
1-216-819-11 METAL CHIP  
1-216-837-11 METAL CHIP  
1-216-835-11 METAL CHIP  
680  
680  
680  
22K  
15K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
S8  
S9  
S10  
S11  
S12  
1-692-135-21 SWITCH, KEYBOARD (SCRL)  
1-692-135-21 SWITCH, KEYBOARD (DSPL/PTY)  
1-692-135-21 SWITCH, KEYBOARD (ENTER)  
1-692-135-21 SWITCH, KEYBOARD (LIST)  
1-692-135-21 SWITCH, KEYBOARD (MENU)  
R16  
R17  
R18  
R19  
R20  
1-216-833-11 METAL CHIP  
1-216-831-11 METAL CHIP  
1-216-829-11 METAL CHIP  
1-216-827-11 METAL CHIP  
1-216-825-11 METAL CHIP  
10K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
6.8K  
4.7K  
3.3K  
2.2K  
S13  
S14  
S15  
1-692-135-21 SWITCH, KEYBOARD (SOUND)  
1-771-884-11 SWITCH, TACTILE (WITH LED) (DSO)  
1-771-884-11 SWITCH, TACTILE (WITH LED) (EQ7)  
*************************************************************  
R21  
R22  
R23  
R24  
R25  
1-216-823-11 METAL CHIP  
1-216-823-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-819-11 METAL CHIP  
1-216-819-11 METAL CHIP  
1.5K  
1.5K  
1K  
680  
680  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
*
1-676-708-11 LIMIT SW BOARD  
***************  
< CONNECTOR >  
1-770-347-21 CONNECTOR, FPC 6P  
< SWITCH >  
CN13  
SW4  
R26  
R27  
R28  
R29  
R30  
1-216-819-11 METAL CHIP  
1-216-827-11 METAL CHIP  
1-216-833-11 METAL CHIP  
1-216-827-11 METAL CHIP  
1-216-815-11 METAL CHIP  
680  
3.3K  
10K  
3.3K  
330  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
1-529-565-11 SWITCH, PUSH (1 KEY) (LIMIT)  
*************************************************************  
R31  
R32  
R33  
R34  
R35  
1-216-033-00 METAL CHIP  
1-216-025-11 RES-CHIP  
1-216-807-11 METAL CHIP  
1-216-035-00 METAL CHIP  
1-216-035-00 METAL CHIP  
220  
100  
68  
270  
270  
5%  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/16W  
1/10W  
1/10W  
R36  
R37  
R38  
R39  
R40  
1-216-817-11 METAL CHIP  
1-216-029-00 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
470  
150  
100  
100  
100  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/10W  
1/16W  
1/16W  
1/16W  
R41  
1-216-841-11 METAL CHIP  
47K  
5%  
1/16W  
66  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
MAIN  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
*
*
*
A-3283-172-A MAIN BOARD, COMPLETE (M670:US)  
A-3283-173-A MAIN BOARD, COMPLETE (M620)  
A-3283-174-A MAIN BOARD, COMPLETE (AEP,UK,E)  
*********************  
C128  
C201  
C202  
C205  
C206  
1-125-837-11 CERAMIC CHIP 1uF  
1-162-918-11 CERAMIC CHIP 18PF  
1-164-156-11 CERAMIC CHIP 0.1uF  
1-164-156-11 CERAMIC CHIP 0.1uF  
1-164-156-11 CERAMIC CHIP 0.1uF  
10%  
5%  
6.3V  
50V  
25V  
25V  
25V  
*
*
*
*
*
3-019-565-01 BRACKET (IC)  
3-230-509-01 CHASSIS, BACK  
3-230-510-21 HEAT SINK (US)  
3-230-510-31 HEAT SINK (AEP,UK,E)  
3-230-513-01 HEAT SINK (REG)  
C207  
C208  
C209  
C210  
1-124-589-11 ELECT  
1-164-156-11 CERAMIC CHIP 0.1uF  
1-104-942-11 ELECT 1uF  
47uF  
20%  
20%  
16V  
25V  
50V  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
50V  
(AEP,UK,E)  
16V  
(AEP,UK,E)  
7-685-792-09 SCREW +PTT 2.6X6 (S)  
7-685-794-09 SCREW +PTT 2.6X10 (S)  
C211  
1-164-360-11 CERAMIC CHIP 0.1uF  
< BUZZER >  
C212  
C213  
C214  
C215  
C216  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
50V  
(AEP,UK,E)  
50V  
(AEP,UK,E)  
BZ501 1-504-920-11 BUZZER  
< CAPACITOR >  
1-162-915-11 CERAMIC CHIP 10PF  
1-125-891-11 CERAMIC CHIP 0.47uF  
0.5PF 50V  
(AEP,UK,E)  
10V  
(AEP,UK,E)  
10V  
(AEP,UK,E)  
C51  
C52  
C53  
C54  
C55  
1-162-919-11 CERAMIC CHIP 22PF  
1-162-919-11 CERAMIC CHIP 22PF  
1-162-919-11 CERAMIC CHIP 22PF  
1-162-919-11 CERAMIC CHIP 22PF  
1-162-919-11 CERAMIC CHIP 22PF  
5%  
5%  
5%  
5%  
5%  
50V  
(M670:US)  
50V  
(M670:US)  
50V  
(M670:US)  
50V  
(M670:US)  
50V  
(M670:US)  
10%  
20%  
1-104-664-11 ELECT  
47uF  
C217  
C218  
C219  
C220  
C221  
1-164-315-11 CERAMIC CHIP 470PF  
1-107-826-11 CERAMIC CHIP 0.1uF  
5%  
50V  
(AEP,UK,E)  
16V  
10%  
(AEP,UK,E)  
1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V  
(AEP,UK,E)  
50V  
(AEP,UK,E)  
50V  
(AEP,UK,E)  
C57  
C58  
C101  
C103  
C104  
1-162-927-11 CERAMIC CHIP 100PF  
1-164-156-11 CERAMIC CHIP 0.1uF  
1-124-570-11 ELECT  
1-164-156-11 CERAMIC CHIP 0.1uF  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
5%  
50V  
25V  
16V  
25V  
50V  
1-162-924-11 CERAMIC CHIP 56PF  
1-162-924-11 CERAMIC CHIP 56PF  
5%  
5%  
220uF  
20%  
C222  
C223  
C224  
C225  
C226  
1-165-176-11 CERAMIC CHIP 0.047uF 10%  
16V  
(AEP,UK,E)  
50V  
(AEP,UK,E)  
16V  
(AEP,UK,E)  
16V  
(AEP,UK,E)  
16V  
C105  
C106  
C107  
C108  
C109  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-162-959-11 CERAMIC CHIP 330PF  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-162-959-11 CERAMIC CHIP 330PF  
10%  
5%  
10%  
5%  
20%  
25V  
50V  
25V  
50V  
10V  
1-164-315-11 CERAMIC CHIP 470PF  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-107-826-11 CERAMIC CHIP 0.1uF  
5%  
10%  
10%  
10%  
1-126-176-11 ELECT  
220uF  
C110  
C111  
C112  
C113  
C115  
1-164-217-11 CERAMIC CHIP 150PF  
1-115-156-11 CERAMIC CHIP 1uF  
1-164-156-11 CERAMIC CHIP 0.1uF  
5%  
50V  
10V  
25V  
10V  
50V  
(AEP,UK,E)  
1-126-176-11 ELECT  
220uF  
20%  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
C227  
C228  
C229  
C230  
C231  
1-162-966-11 CERAMIC CHIP 0.0022uF 10%  
50V  
(AEP,UK,E)  
50V  
(AEP,UK,E)  
6.3V  
(AEP,UK,E)  
50V  
(AEP,UK,E)  
C116  
C117  
C118  
C119  
C120  
1-126-176-11 ELECT  
1-126-176-11 ELECT  
220uF  
220uF  
20%  
20%  
10V  
10V  
25V  
50V  
25V  
1-162-959-11 CERAMIC CHIP 330PF  
1-125-838-11 CERAMIC CHIP 2.2uF  
1-164-739-11 CERAMIC CHIP 560PF  
5%  
1-164-156-11 CERAMIC CHIP 0.1uF  
1-162-923-11 CERAMIC CHIP 47PF  
1-164-156-11 CERAMIC CHIP 0.1uF  
10%  
5%  
5%  
C121  
C122  
C123  
C124  
C125  
1-128-057-11 ELECT  
330uF  
20%  
6.3V  
5.5V  
16V  
25V  
25V  
1-124-233-11 ELECT  
10uF  
20%  
16V  
1-110-654-11 DOUBLE LAYERS 0.047F  
1-107-826-11 CERAMIC CHIP 0.1uF  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-164-156-11 CERAMIC CHIP 0.1uF  
10%  
10%  
C301  
C302  
C303  
C304  
C305  
1-162-927-11 CERAMIC CHIP 100PF  
1-162-927-11 CERAMIC CHIP 100PF  
5%  
5%  
50V  
50V  
50V  
50V  
16V  
1-136-154-00 FILM  
1-136-154-00 FILM  
1-124-233-11 ELECT  
0.012uF 5%  
0.012uF 5%  
10uF 20%  
C126  
C127  
1-124-937-11 ELECT  
10uF  
20%  
16V  
25V  
1-164-156-11 CERAMIC CHIP 0.1uF  
67  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
MAIN  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
C348  
Part No.  
Description  
Remark  
10V  
(EXCEPT M670:US)  
C306  
C307  
C308  
C309  
1-162-965-11 CERAMIC CHIP 0.0015uF 10%  
1-162-965-11 CERAMIC CHIP 0.0015uF 10%  
1-162-927-11 CERAMIC CHIP 100PF  
1-125-837-11 CERAMIC CHIP 1uF  
50V  
50V  
50V  
1-125-891-11 CERAMIC CHIP 0.47uF  
10%  
5%  
10%  
C348  
1-127-715-11 CERAMIC CHIP 0.22uF  
10%  
16V  
(M670:US)  
6.3V  
(M670:US)  
25V  
(M670:US)  
C349  
C350  
C351  
1-165-176-11 CERAMIC CHIP 0.047uF 10%  
1-164-227-11 CERAMIC CHIP 0.022uF 10%  
1-164-156-11 CERAMIC CHIP 0.1uF  
16V  
25V  
25V  
C310  
1-164-156-11 CERAMIC CHIP 0.1uF  
(M670:US)  
C311  
C312  
1-125-837-11 CERAMIC CHIP 1uF  
1-164-156-11 CERAMIC CHIP 0.1uF  
10%  
5%  
6.3V  
(M670:US)  
25V  
(M670:US)  
50V  
C352  
1-164-156-11 CERAMIC CHIP 0.1uF  
25V  
(M670:US)  
50V  
50V  
(M670:US)  
25V  
(M670:US)  
16V  
(M670:US)  
C353  
C354  
1-162-968-11 CERAMIC CHIP 0.0047uF 10%  
1-162-974-11 CERAMIC CHIP 0.01uF  
C313  
C314  
C315  
1-162-927-11 CERAMIC CHIP 100PF  
1-164-156-11 CERAMIC CHIP 0.1uF  
1-164-156-11 CERAMIC CHIP 0.1uF  
25V  
25V  
C355  
C356  
1-164-156-11 CERAMIC CHIP 0.1uF  
C316  
C317  
C318  
C319  
C320  
1-124-937-11 ELECT  
1-124-233-11 ELECT  
10uF  
10uF  
20%  
20%  
5%  
5%  
5%  
16V  
16V  
50V  
50V  
50V  
1-127-715-11 CERAMIC CHIP 0.22uF  
10%  
10%  
1-162-927-11 CERAMIC CHIP 100PF  
1-162-927-11 CERAMIC CHIP 100PF  
1-162-927-11 CERAMIC CHIP 100PF  
C357  
C357  
1-125-891-11 CERAMIC CHIP 0.47uF  
1-127-715-11 CERAMIC CHIP 0.22uF  
10V  
(EXCEPT M670:US)  
10%  
16V  
(M670:US)  
6.3V  
6.3V  
16V  
C321  
C322  
1-125-837-11 CERAMIC CHIP 1uF  
1-125-837-11 CERAMIC CHIP 1uF  
1-162-927-11 CERAMIC CHIP 100PF  
10%  
10%  
6.3V  
(M670:US)  
6.3V  
(M670:US)  
50V  
16V  
16V  
C358  
C359  
C360  
1-125-837-11 CERAMIC CHIP 1uF  
1-125-837-11 CERAMIC CHIP 1uF  
10%  
10%  
20%  
1-126-382-11 ELECT  
1-124-233-11 ELECT  
1-126-786-11 ELECT  
100uF  
10uF  
47uF  
C323  
C324  
C325  
5%  
20%  
20%  
1-124-233-11 ELECT  
10uF  
C361  
C361  
C362  
20%  
16V  
1-126-157-11 ELECT  
10uF  
(EXCEPT M670:US)  
20%  
16V  
(M670:US)  
25V  
(M670:US)  
25V  
C328  
C329  
C332  
C333  
C334  
1-124-233-11 ELECT  
10uF  
20%  
16V  
25V  
16V  
16V  
16V  
1-164-156-11 CERAMIC CHIP 0.1uF  
1-127-573-11 CERAMIC CHIP 1uF  
1-127-573-11 CERAMIC CHIP 1uF  
1-164-156-11 CERAMIC CHIP 0.1uF  
10%  
10%  
20%  
C363  
C364  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-125-891-11 CERAMIC CHIP 0.47uF  
10%  
10%  
1-124-234-00 ELECT  
22uF  
10V  
(M670:US)  
C365  
C366  
C371  
C372  
1-162-968-11 CERAMIC CHIP 0.0047uF 10%  
50V  
50V  
50V  
C335  
C336  
1-125-837-11 CERAMIC CHIP 1uF  
1-127-715-11 CERAMIC CHIP 0.22uF  
10%  
10%  
6.3V  
16V  
(M670:US)  
1-162-927-11 CERAMIC CHIP 100PF  
5%  
1-104-942-11 ELECT  
1-126-157-11 ELECT  
1uF  
10uF  
20%  
20%  
16V  
C337  
C337  
C338  
C339  
C340  
1-125-891-11 CERAMIC CHIP 0.47uF  
1-127-715-11 CERAMIC CHIP 0.22uF  
1-127-573-11 CERAMIC CHIP 1uF  
1-127-715-11 CERAMIC CHIP 0.22uF  
10%  
10V  
(M670:US)  
6.3V  
(EXCEPT M670:US)  
C373  
1-125-837-11 CERAMIC CHIP 1uF  
10%  
10%  
10%  
10%  
20%  
16V  
(M670:US)  
16V  
C374  
C375  
C376  
C377  
C378  
1-126-786-11 ELECT  
47uF  
20%  
10%  
5%  
5%  
5%  
16V  
25V  
50V  
50V  
50V  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-162-927-11 CERAMIC CHIP 100PF  
1-162-927-11 CERAMIC CHIP 100PF  
1-162-927-11 CERAMIC CHIP 100PF  
16V  
(M670:US)  
16V  
1-124-234-00 ELECT  
22uF  
(M670:US)  
16V  
16V  
(M670:US)  
25V  
C379  
C380  
C381  
C382  
C383  
1-162-927-11 CERAMIC CHIP 100PF  
1-162-927-11 CERAMIC CHIP 100PF  
1-164-156-11 CERAMIC CHIP 0.1uF  
5%  
5%  
50V  
50V  
25V  
10V  
16V  
C341  
C342  
1-127-573-11 CERAMIC CHIP 1uF  
10%  
20%  
1-124-234-00 ELECT  
22uF  
1-126-176-11 ELECT  
220uF  
20%  
10%  
C343  
C344  
C344  
1-164-156-11 CERAMIC CHIP 0.1uF  
1-125-891-11 CERAMIC CHIP 0.47uF  
1-127-715-11 CERAMIC CHIP 0.22uF  
1-127-715-11 CERAMIC CHIP 0.22uF  
10%  
10V  
C384  
C385  
C386  
C387  
C388  
1-127-715-11 CERAMIC CHIP 0.22uF  
1-162-919-11 CERAMIC CHIP 22PF  
1-162-919-11 CERAMIC CHIP 22PF  
1-162-919-11 CERAMIC CHIP 22PF  
1-162-919-11 CERAMIC CHIP 22PF  
10%  
5%  
5%  
5%  
5%  
16V  
50V  
50V  
50V  
50V  
(EXCEPT M670:US)  
10%  
16V  
(M670:US)  
25V  
C345  
C346  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-127-715-11 CERAMIC CHIP 0.22uF  
10%  
10%  
16V  
(M670:US)  
50V  
C403  
C406  
1-135-473-21 ELECT  
1-127-573-11 CERAMIC CHIP 1uF  
3300uF  
20%  
10%  
16V  
16V  
C347  
1-124-465-00 ELECT  
0.47uF  
20%  
68  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
MAIN  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
C407  
C451  
C452  
C454  
C455  
1-126-572-11 ELECT  
1-124-234-00 ELECT  
1-124-234-00 ELECT  
1-128-057-11 ELECT  
1-124-234-00 ELECT  
4.7uF  
22uF  
22uF  
330uF  
22uF  
20%  
20%  
20%  
20%  
20%  
35V  
16V  
16V  
6.3V  
16V  
< CONNECTOR >  
CN101 1-774-701-11 PIN, CONNECTOR 16P  
* CN201 1-506-984-11 PIN, CONNECTOR (PC BOARD) 2P  
* CN301 1-506-985-11 PIN, CONNECTOR (PC BOARD) 3P  
CN401 1-764-617-12 PIN, CONNECTOR (PC BOARD) 30P  
CN601 1-580-907-31 PLUG, CONNECTOR (BUS CONTROL IN)  
C456  
C457  
C501  
1-162-974-11 CERAMIC CHIP 0.01uF  
1-164-156-11 CERAMIC CHIP 0.1uF  
1-162-968-11 CERAMIC CHIP 0.0047uF 10%  
1-165-176-11 CERAMIC CHIP 0.047uF 10%  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
50V  
25V  
50V  
(AEP,UK,E)  
16V  
CN602 1-568-955-11 PIN, CONNECTOR 6P  
CN603 1-563-614-31 CONNECTOR, FLEXIBLE 11P  
CN604 1-815-499-21 CONNECTOR, FPC (ZIF) 18P  
C501  
C502  
(US)  
50V  
< JACK >  
C503  
C505  
C506  
C507  
C508  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
50V  
50V  
50V  
50V  
50V  
CN302 1-774-700-11 JACK, PIN 6P (BUS AUDIO IN,  
AUDIO OUT REAR/FRONT)  
1-164-315-11 CERAMIC CHIP 470PF  
1-164-230-11 CERAMIC CHIP 220PF  
1-164-160-11 CERAMIC CHIP 20PF  
5%  
5%  
5%  
< DIODE >  
D101  
D102  
D104  
D105  
D106  
8-719-055-30 DIODE D1FS4A-TA  
8-719-055-30 DIODE D1FS4A-TA  
8-719-801-78 DIODE 1SS184  
8-719-060-81 DIODE MA735-TX  
8-719-053-18 DIODE 1SR154-400TE-25  
C509  
C510  
C511  
C512  
C513  
1-162-920-11 CERAMIC CHIP 27PF  
1-164-156-11 CERAMIC CHIP 0.1uF  
1-125-838-11 CERAMIC CHIP 2.2uF  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
1-164-156-11 CERAMIC CHIP 0.1uF  
5%  
50V  
25V  
6.3V  
50V  
25V  
10%  
D107  
D109  
D202  
D203  
D204  
8-719-422-62 DIODE MA8062-L-TX  
8-719-977-03 DIODE DTZ5.6B  
8-719-988-61 DIODE 1SS355TE-17  
8-719-422-41 DIODE MA8051-L-TX  
8-719-800-76 DIODE MA153-TX (AEP,UK,E)  
C514  
C515  
C516  
C517  
C602  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
50V  
10V  
50V  
50V  
25V  
1-124-584-00 ELECT  
100uF  
20%  
1-162-920-11 CERAMIC CHIP 27PF  
1-164-160-11 CERAMIC CHIP 20PF  
1-162-970-11 CERAMIC CHIP 0.01uF  
5%  
5%  
10%  
D205  
D301  
D302  
D303  
D304  
8-719-422-41 DIODE MA8051-L-TX (AEP,UK,E)  
8-719-074-47 DIODE CRS02(TE85L)  
8-719-074-47 DIODE CRS02(TE85L)  
8-719-074-47 DIODE CRS02(TE85L)  
8-719-074-47 DIODE CRS02(TE85L)  
C603  
C650  
C651  
C652  
C653  
1-126-934-11 ELECT  
220uF  
20%  
16V  
25V  
25V  
25V  
25V  
1-164-156-11 CERAMIC CHIP 0.1uF  
1-164-156-11 CERAMIC CHIP 0.1uF  
1-164-156-11 CERAMIC CHIP 0.1uF  
1-164-156-11 CERAMIC CHIP 0.1uF  
D305  
D306  
D307  
D308  
D309  
8-719-074-47 DIODE CRS02(TE85L)  
8-719-074-47 DIODE CRS02(TE85L)  
8-719-074-47 DIODE CRS02(TE85L)  
8-719-074-47 DIODE CRS02(TE85L)  
8-719-801-78 DIODE 1SS184  
C655  
C656  
C657  
C658  
C659  
1-124-589-11 ELECT  
47uF  
20%  
16V  
25V  
25V  
25V  
25V  
1-164-156-11 CERAMIC CHIP 0.1uF  
1-164-156-11 CERAMIC CHIP 0.1uF  
1-164-156-11 CERAMIC CHIP 0.1uF  
1-164-156-11 CERAMIC CHIP 0.1uF  
D311  
D401  
D404  
D405  
D406  
8-719-988-61 DIODE 1SS355TE-17  
8-719-049-38 DIODE 1N5404TU  
8-719-977-12 DIODE DTZ6.8B  
8-719-053-18 DIODE 1SR154-400TE-25  
8-719-053-18 DIODE 1SR154-400TE-25  
C660  
C701  
C703  
C704  
C705  
1-162-970-11 CERAMIC CHIP 0.01uF  
10%  
20%  
25V  
16V  
50V  
50V  
50V  
1-124-589-11 ELECT  
47uF  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
D407  
D501  
D502  
D503  
D504  
8-719-988-61 DIODE 1SS355TE-17  
8-719-988-61 DIODE 1SS355TE-17 (AEP,UK,E)  
8-719-988-61 DIODE 1SS355TE-17  
8-719-988-61 DIODE 1SS355TE-17  
8-719-422-41 DIODE MA8051-L-TX  
C706  
C707  
C708  
C709  
C710  
1-164-156-11 CERAMIC CHIP 0.1uF  
1-162-974-11 CERAMIC CHIP 0.01uF  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
25V  
50V  
50V  
50V  
50V  
D505  
D506  
D507  
D508  
D509  
8-719-988-61 DIODE 1SS355TE-17  
8-719-988-61 DIODE 1SS355TE-17  
8-719-801-78 DIODE 1SS184  
8-719-988-61 DIODE 1SS355TE-17  
8-719-988-61 DIODE 1SS355TE-17  
C711  
C712  
C801  
C802  
C813  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-162-974-11 CERAMIC CHIP 0.01uF  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
1-162-964-11 CERAMIC CHIP 0.001uF 10%  
1-115-156-11 CERAMIC CHIP 1uF  
10%  
25V  
50V  
50V  
50V  
10V  
D510  
D511  
8-719-988-61 DIODE 1SS355TE-17  
8-719-988-61 DIODE 1SS355TE-17  
C814  
1-164-156-11 CERAMIC CHIP 0.1uF  
25V  
69  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
MAIN  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
J651  
Part No.  
Description  
< JACK >  
Remark  
D602  
D603  
D604  
D605  
D606  
8-719-017-95 DIODE MA8180-TX  
8-719-422-64 DIODE MA8062-M  
8-719-017-95 DIODE MA8180-TX  
8-719-420-51 DIODE MA729  
1-566-822-41 JACK (REMOTE IN) (AEP,UK,E)  
< COIL >  
8-719-988-61 DIODE 1SS355TE-17  
D607  
D608  
D609  
D610  
D611  
8-719-017-95 DIODE MA8180-TX  
8-719-988-61 DIODE 1SS355TE-17  
8-719-801-78 DIODE 1SS184  
8-719-977-12 DIODE KDZ6.8V (AEP,UK,E)  
8-719-977-12 DIODE KDZ6.8V (AEP,UK,E)  
L101  
L102  
L103  
L104  
L105  
1-419-506-11 INDUCTOR  
1-414-392-41 INDUCTOR  
1-419-506-11 INDUCTOR  
1-414-394-41 INDUCTOR  
1-414-394-41 INDUCTOR  
150uH  
1uH  
150uH  
2.2uH  
2.2uH  
D612  
D650  
D651  
D652  
D801  
8-719-988-61 DIODE 1SS355TE-17  
8-719-081-98 DIODE MM3Z6V8T1  
8-719-801-78 DIODE 1SS184  
8-719-820-05 DIODE 1SS181  
8-719-977-12 DIODE DTZ6.8B  
L201  
L401  
L501  
L701  
1-216-295-11 SHORT  
0
1-419-476-31 COIL, CHOKE  
1-414-185-51 INDUCTOR  
1-414-856-51 INDUCTOR  
250uH  
22uH  
10uH  
< TRANSISTOR >  
D802  
D803  
D804  
D805  
D806  
8-719-078-81 DIODE DF5A6.8FU(TE85R)  
8-719-988-61 DIODE 1SS355TE-17  
8-719-423-32 DIODE MA8120-M  
8-719-078-81 DIODE DF5A6.8FU(TE85R)  
8-719-078-81 DIODE DF5A6.8FU(TE85R)  
Q101  
Q102  
Q103  
Q105  
Q106  
8-729-038-68 TRANSISTOR KRC103S  
8-729-038-55 TRANSISTOR KRA103S  
8-729-820-46 TRANSISTOR 2SB1202FAS  
8-729-034-49 TRANSISTOR KRC104S  
8-729-820-46 TRANSISTOR 2SB1202FAS  
D807  
8-719-988-61 DIODE 1SS355TE-17  
< FERRITE BEAD >  
Q107  
Q108  
Q109  
Q110  
Q111  
8-729-038-68 TRANSISTOR KRC103S  
8-729-106-60 TRANSISTOR 2SB1115A-YQ  
8-729-106-60 TRANSISTOR 2SB1115A-YQ  
8-729-106-60 TRANSISTOR 2SB1115A-YQ  
8-729-038-68 TRANSISTOR KRC103S  
FB706 1-414-760-21 FERRITE, EMI (SMD)  
FB707 1-414-760-21 FERRITE, EMI (SMD)  
< IC >  
Q112  
Q113  
Q114  
Q115  
Q116  
8-729-038-68 TRANSISTOR KRC103S  
8-729-040-17 TRANSISTOR 2SD2164-K  
8-729-106-60 TRANSISTOR 2SB1115A-YQ  
8-729-038-67 TRANSISTOR KRC102S  
8-729-034-49 TRANSISTOR KRC104S  
IC101  
IC102  
IC201  
IC202  
IC301  
8-759-990-43 IC TL1451ACDB-E20  
8-759-836-78 IC RN5VD53AA-TL  
8-759-909-71 IC BA4558F-T1 (AEP,UK,E)  
8-759-492-59 IC SAA6588T/V2-118 (AEP,UK,E)  
8-759-422-21 IC NJM4580V(TE2)  
Q117  
Q118  
Q119  
Q201  
Q202  
8-729-038-67 TRANSISTOR KRC102S  
8-759-068-54 IC WS57C291B-RE20A  
8-729-019-00 TRANSISTOR 2SD2394-G  
8-729-920-85 TRANSISTOR 2SD1664-QR  
IC302  
IC303  
IC304  
IC305  
IC306  
8-759-422-21 IC NJM4580V(TE2)  
8-759-422-21 IC NJM4580V(TE2) (M670:US)  
8-759-422-21 IC NJM4580V(TE2) (M670:US)  
8-759-827-13 IC TDA7406T  
8-729-120-28 TRANSISTOR 2SC2412K-T-146-R (AEP,UK,E)  
8-759-363-28 IC TC7660SEOA713 (M670:US)  
Q203  
Q301  
Q301  
Q302  
Q302  
8-729-038-67 TRANSISTOR KRC102S (AEP,UK,E)  
8-729-021-95 TRANSISTOR RN1441-A(TE85L) (M670:US)  
8-729-920-21 TRANSISTOR DTC314TKH04 (AEP,UK,E)  
8-729-021-95 TRANSISTOR RN1441-A(TE85L) (M670:US)  
8-729-920-21 TRANSISTOR DTC314TKH04 (AEP,UK,E)  
IC307  
IC308  
IC309  
IC309  
IC310  
8-759-422-21 IC NJM4580V(TE2) (M670:US)  
8-759-422-21 IC NJM4580V(TE2) (M670:US)  
8-759-660-96 IC TDA7560 (M670:US)  
8-759-827-14 IC TA8268AH (EXCEPT M670:US)  
8-759-422-21 IC NJM4580V(TE2)  
Q303  
Q303  
Q304  
Q304  
Q305  
8-729-021-95 TRANSISTOR RN1441-A(TE85L) (M670:US)  
8-729-920-21 TRANSISTOR DTC314TKH04 (AEP,UK,E)  
8-729-021-95 TRANSISTOR RN1441-A(TE85L) (M670:US)  
8-729-920-21 TRANSISTOR DTC314TKH04 (AEP,UK,E)  
8-729-021-95 TRANSISTOR RN1441-A(TE85L) (M670:US)  
IC501  
IC501  
IC502  
IC601  
IC650  
6-700-182-01 IC MB90574BPMT-G-321-BND (US)  
6-700-183-01 IC MB90574BPMT-G-322-BND (AEP,UK,E)  
8-759-828-22 IC XC61CN4102MR  
8-759-449-89 IC BA8270F-E2  
8-759-337-40 IC NJM2904V(TE2)  
Q305  
Q306  
Q307  
Q308  
Q309  
8-729-920-21 TRANSISTOR DTC314TKH04 (AEP,UK,E)  
8-729-120-28 TRANSISTOR 2SC2412K-T-146-R (M670:US)  
8-729-106-60 TRANSISTOR 2SB1132-T100-R (M670:US)  
8-729-120-28 TRANSISTOR 2SC2412K-T-146-R (M670:US)  
8-729-144-85 FET 2SK1133  
IC651  
IC652  
IC701  
IC702  
IC801  
8-759-580-33 IC BA6288FS-E2  
8-759-668-14 IC PQ09DZ1U  
8-759-277-63 IC TC7W14FU(TE12R)  
6-700-210-01 IC HD6432355A36F  
8-759-830-17 IC RRX9000-0401R#01  
Q310  
Q312  
8-729-038-56 TRANSISTOR KRA104S  
8-729-034-49 TRANSISTOR KRC104S  
70  
Download from Www.Somanuals.com. All Manuals Search And Download.  
                                         
CDX-M620/M670  
MAIN  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
Q401  
Q402  
Q404  
Q405  
Q406  
8-729-049-13 TRANSISTOR UPA1853GR-9JG-E1  
8-729-038-68 TRANSISTOR KRC103S  
8-729-038-68 TRANSISTOR KRC103S  
8-729-120-28 TRANSISTOR 2SC1623-L5L6  
8-729-120-28 TRANSISTOR 2SC1623-L5L6  
R138  
R139  
R140  
R141  
R201  
1-216-821-11 METAL CHIP  
1-216-864-11 SHORT  
1-216-864-11 SHORT  
1-216-845-11 METAL CHIP  
1-216-001-00 METAL CHIP  
1K  
0
0
100K  
10  
5%  
1/16W  
5%  
5%  
1/16W  
1/10W  
Q407  
Q501  
Q502  
Q602  
Q603  
8-729-120-28 TRANSISTOR 2SC1623-L5L6  
8-759-068-54 IC WS57C291B-RE20A  
8-729-038-67 TRANSISTOR KRC102S  
8-729-038-56 TRANSISTOR KRA104S  
8-729-038-67 TRANSISTOR KRC102S  
R202  
R203  
R204  
R205  
1-216-864-11 SHORT  
1-216-864-11 SHORT  
1-216-817-11 METAL CHIP  
1-216-833-11 METAL CHIP  
0
0
470  
10K  
5%  
5%  
1/16W  
1/16W  
(AEP,UK,E)  
1/16W  
R206  
1-216-825-11 METAL CHIP  
2.2K  
5%  
Q650  
Q651  
Q652  
8-729-038-68 TRANSISTOR KRC103S  
8-729-120-28 TRANSISTOR 2SC1623-L5L6  
8-729-216-22 TRANSISTOR 2SA1162-G  
(AEP,UK,E)  
R207  
R208  
1-216-809-11 METAL CHIP  
1-216-845-11 METAL CHIP  
100  
5%  
5%  
1/16W  
(AEP,UK,E)  
1/16W  
< RESISTOR >  
100K  
(AEP,UK,E)  
(AEP,UK,E)  
1/16W  
(AEP,UK,E)  
1/16W  
R51  
1-216-821-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-055-00 METAL CHIP  
1-216-055-00 METAL CHIP  
1-216-055-00 METAL CHIP  
1K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/10W  
1/10W  
1/10W  
R209  
R210  
1-216-295-11 SHORT  
1-216-833-11 METAL CHIP  
0
10K  
R101  
R102  
R103  
R104  
100  
1.8K  
1.8K  
1.8K  
5%  
5%  
R211  
1-216-825-11 METAL CHIP  
2.2K  
(AEP,UK,E)  
R105  
R106  
R107  
R108  
R109  
1-216-809-11 METAL CHIP  
1-216-829-11 METAL CHIP  
1-216-829-11 METAL CHIP  
1-218-861-11 METAL CHIP  
1-218-847-11 METAL CHIP  
100  
4.7K  
4.7K  
3.9K  
1K  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
R212  
R213  
R214  
R215  
R216  
1-216-825-11 METAL CHIP  
1-216-857-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-853-11 METAL CHIP  
1-216-817-11 METAL CHIP  
2.2K  
1M  
5%  
5%  
5%  
5%  
5%  
1/16W  
(AEP,UK,E)  
1/16W  
(AEP,UK,E)  
1/16W  
(AEP,UK,E)  
1/16W  
(AEP,UK,E)  
1/16W  
0.5% 1/16W  
0.5% 1/16W  
100  
470K  
470  
R110  
R111  
R112  
R113  
R114  
1-218-873-11 METAL CHIP  
1-216-841-11 METAL CHIP  
1-216-841-11 METAL CHIP  
1-216-841-11 METAL CHIP  
1-216-841-11 METAL CHIP  
12K  
47K  
47K  
47K  
47K  
0.5% 1/16W  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
(AEP,UK,E)  
R217  
R218  
R219  
R220  
R221  
1-216-797-11 METAL CHIP  
1-216-823-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-797-11 METAL CHIP  
1-216-864-11 SHORT  
10  
1.5K  
1K  
10  
0
5%  
5%  
5%  
5%  
1/16W  
(AEP,UK,E)  
1/16W  
(AEP,UK,E)  
1/16W  
(AEP,UK,E)  
1/16W  
(AEP,UK,E)  
R115  
R116  
R117  
R118  
R119  
1-216-845-11 METAL CHIP  
1-218-897-11 METAL CHIP  
1-216-864-11 SHORT  
1-216-809-11 METAL CHIP  
1-216-055-00 METAL CHIP  
100K  
120K  
0
100  
1.8K  
5%  
1/16W  
0.5% 1/16W  
5%  
5%  
1/16W  
1/10W  
R120  
R121  
R122  
R123  
R124  
1-216-055-00 METAL CHIP  
1-216-055-00 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-057-00 METAL CHIP  
1-216-845-11 METAL CHIP  
1.8K  
1.8K  
100  
2.2K  
100K  
5%  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/16W  
1/10W  
1/16W  
R222  
R301  
R302  
R303  
R304  
1-216-864-11 SHORT  
0
1-216-821-11 METAL CHIP  
1-216-833-11 METAL CHIP  
1-216-864-11 SHORT  
1K  
10K  
0
5%  
5%  
1/16W  
1/16W  
R125  
R126  
R127  
R128  
R129  
1-218-847-11 METAL CHIP  
1-218-866-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-057-00 METAL CHIP  
1-216-057-00 METAL CHIP  
1K  
0.5% 1/16W  
0.5% 1/16W  
5%  
5%  
5%  
(EXCEPTM670:US)  
5%  
6.2K  
100K  
2.2K  
2.2K  
1-216-833-11 METAL CHIP  
10K  
1/16W  
1/16W  
1/10W  
1/10W  
R305  
R306  
R307  
R308  
R309  
1-216-864-11 SHORT  
1-216-864-11 SHORT  
1-216-833-11 METAL CHIP  
1-216-833-11 METAL CHIP  
1-216-833-11 METAL CHIP  
0
0
10K  
10K  
10K  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
R130  
R131  
R132  
R133  
R134  
1-216-845-11 METAL CHIP  
1-216-829-11 METAL CHIP  
1-216-833-11 METAL CHIP  
1-216-835-11 METAL CHIP  
1-216-821-11 METAL CHIP  
100K  
4.7K  
10K  
15K  
1K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
R310  
R311  
R312  
R313  
R314  
1-216-833-11 METAL CHIP  
1-216-864-11 SHORT  
1-216-821-11 METAL CHIP  
1-216-833-11 METAL CHIP  
1-216-809-11 METAL CHIP  
10K  
0
1K  
10K  
100  
5%  
1/16W  
(EXCEPTM670:US)  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
R135  
R136  
R137  
1-216-057-00 METAL CHIP  
1-216-057-00 METAL CHIP  
1-216-841-11 METAL CHIP  
2.2K  
2.2K  
47K  
5%  
5%  
5%  
1/10W  
1/10W  
1/16W  
(EXCEPT M670:US)  
71  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
MAIN  
Ref. No.  
R314  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
1-216-813-11 METAL CHIP  
220  
5%  
1/16W  
(M670:US)  
1/16W  
1/16W  
1/16W  
R347  
R348  
R349  
R350  
1-216-864-11 SHORT  
1-216-864-11 SHORT  
1-216-864-11 SHORT  
1-216-833-11 METAL CHIP  
0
0
0
10K  
(EXCEPT M670:US)  
(EXCEPT M670:US)  
(EXCEPT M670:US)  
R316  
R317  
R318  
1-216-833-11 METAL CHIP  
1-216-841-11 METAL CHIP  
1-216-845-11 METAL CHIP  
10K  
47K  
100K  
5%  
5%  
5%  
5%  
1/16W  
(M670:US)  
1/16W  
(M670:US)  
1/16W  
R351  
1-216-833-11 METAL CHIP  
10K  
5%  
R319  
1-216-837-11 METAL CHIP  
22K  
5%  
(M670:US)  
(M670:US)  
R352  
R353  
R354  
R355  
R356  
1-216-835-11 METAL CHIP  
1-216-822-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-835-11 METAL CHIP  
1-216-813-11 METAL CHIP  
15K  
1.2K  
1K  
5%  
5%  
5%  
5%  
5%  
1/16W  
(M670:US)  
1/16W  
(M670:US)  
1/16W  
(M670:US)  
1/16W  
(M670:US)  
R320  
R321  
R322  
R323  
R324  
R325  
R325  
R326  
R326  
R327  
1-216-845-11 METAL CHIP  
1-216-841-11 METAL CHIP  
1-216-837-11 METAL CHIP  
1-216-841-11 METAL CHIP  
1-216-841-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-813-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-813-11 METAL CHIP  
1-216-841-11 METAL CHIP  
100K  
47K  
22K  
47K  
47K  
100  
220  
100  
220  
47K  
5%  
5%  
5%  
5%  
5%  
5%  
1/16W  
(M670:US)  
1/16W  
(M670:US)  
1/16W  
(M670:US)  
1/16W  
(M670:US)  
1/16W  
15K  
220  
1/16W  
R357  
R358  
R359  
1-216-813-11 METAL CHIP  
1-216-813-11 METAL CHIP  
1-216-817-11 METAL CHIP  
220  
220  
470  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
(M670:US)  
1/16W  
1/16W  
(EXCEPT M670:US)  
5%  
1/16W  
(M670:US)  
1/16W  
R360  
R361  
1-216-831-11 METAL CHIP  
1-216-813-11 METAL CHIP  
6.8K  
220  
5%  
5%  
5%  
1/16W  
(EXCEPT M670:US)  
5%  
1/16W  
(M670:US)  
1/16W  
R362  
1-216-821-11 METAL CHIP  
1K  
5%  
1/16W  
(M670:US)  
1/16W  
1/16W  
1/16W  
(M670:US)  
1/16W  
5%  
R363  
R364  
R365  
1-216-845-11 METAL CHIP  
1-216-813-11 METAL CHIP  
1-216-833-11 METAL CHIP  
100K  
220  
10K  
5%  
5%  
5%  
R329  
R330  
R331  
1-216-841-11 METAL CHIP  
1-216-833-11 METAL CHIP  
1-216-841-11 METAL CHIP  
47K  
10K  
47K  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
R366  
1-216-821-11 METAL CHIP  
1K  
5%  
(M670:US)  
1/16W  
(M670:US)  
1/16W  
(M670:US)  
R332  
R333  
1-216-841-11 METAL CHIP  
1-216-845-11 METAL CHIP  
47K  
5%  
5%  
R367  
R368  
R369  
R370  
R371  
1-216-821-11 METAL CHIP  
1-216-835-11 METAL CHIP  
1-216-835-11 METAL CHIP  
1-216-833-11 METAL CHIP  
1-216-833-11 METAL CHIP  
1K  
5%  
5%  
5%  
5%  
5%  
1/16W  
(M670:US)  
1/16W  
(M670:US)  
1/16W  
(M670:US)  
1/16W  
100K  
(M670:US)  
15K  
15K  
10K  
10K  
R334  
1-216-837-11 METAL CHIP  
22K  
5%  
1/16W  
(M670:US)  
1/16W  
1/16W  
(M670:US)  
R335  
R336  
1-216-833-11 METAL CHIP  
1-216-845-11 METAL CHIP  
10K  
100K  
5%  
5%  
(M670:US)  
1/16W  
R337  
R338  
1-216-837-11 METAL CHIP  
1-216-809-11 METAL CHIP  
22K  
100  
5%  
5%  
1/16W  
(M670:US)  
1/16W  
(M670:US)  
R372  
R373  
R374  
R375  
R376  
1-216-864-11 SHORT  
1-216-864-11 SHORT  
1-216-841-11 METAL CHIP  
1-216-864-11 SHORT  
1-216-841-11 METAL CHIP  
0
0
47K  
0
47K  
(EXCEPT M670:US)  
5%  
5%  
1/16W  
(US)  
1/16W  
R338  
1-216-813-11 METAL CHIP  
220  
5%  
1/16W  
(M670:US)  
1/16W  
1/16W  
1/16W  
R339  
R340  
R341  
1-216-833-11 METAL CHIP  
1-216-833-11 METAL CHIP  
1-216-809-11 METAL CHIP  
10K  
10K  
100  
5%  
5%  
5%  
R377  
R379  
R380  
R382  
R383  
1-216-864-11 SHORT  
0
1-216-805-11 METAL CHIP  
1-216-841-11 METAL CHIP  
1-216-817-11 METAL CHIP  
1-216-295-11 SHORT  
47  
47K  
470  
0
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
(EXCEPT M670:US)  
5%  
R341  
1-216-813-11 METAL CHIP  
220  
1/16W  
(M670:US)  
(M670:US)  
R342  
R343  
R344  
R345  
R346  
1-216-841-11 METAL CHIP  
1-216-864-11 SHORT  
1-216-864-11 SHORT  
1-216-864-11 SHORT  
1-216-864-11 SHORT  
47K  
0
0
0
0
5%  
1/16W  
R384  
R385  
R388  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-829-11 METAL CHIP  
100K  
100K  
4.7K  
5%  
5%  
5%  
1/16W  
(M670:US)  
1/16W  
(M670:US)  
1/16W  
(EXCEPTM670:US)  
(EXCEPT M670:US)  
(EXCEPT M670:US)  
(M670:US)  
72  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
MAIN  
Ref. No.  
R389  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
1-216-829-11 METAL CHIP  
4.7K  
5%  
1/16W  
(M670:US)  
(EXCEPT M670:US)  
R512  
R513  
R514  
R515  
R516  
1-216-815-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-841-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-864-11 SHORT  
330  
1K  
47K  
1K  
0
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
R389  
R390  
R391  
R393  
1-216-864-11 SHORT  
0
1-216-841-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-821-11 METAL CHIP  
47K  
1K  
1K  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
R517  
R518  
R519  
R520  
R521  
1-216-821-11 METAL CHIP  
1-216-829-11 METAL CHIP  
1-216-813-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-864-11 SHORT  
1K  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
R395  
R397  
R399  
1-216-821-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1K  
1K  
100K  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
(M670:US)  
1/16W  
(M670:US)  
4.7K  
220  
1K  
0
R400  
R401  
1-216-845-11 METAL CHIP  
1-216-057-00 METAL CHIP  
100K  
2.2K  
5%  
5%  
R522  
R523  
R524  
R526  
R527  
1-216-864-11 SHORT  
1-216-864-11 SHORT  
1-216-864-11 SHORT  
1-216-845-11 METAL CHIP  
1-216-831-11 METAL CHIP  
0
0
0
1/10W  
R402  
R403  
R404  
R405  
R406  
1-216-821-11 METAL CHIP  
1-216-073-00 METAL CHIP  
1-216-073-00 METAL CHIP  
1-216-833-11 METAL CHIP  
1-216-833-11 METAL CHIP  
1K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/10W  
1/10W  
1/16W  
1/16W  
100K  
6.8K  
5%  
5%  
1/16W  
1/16W  
10K  
10K  
10K  
10K  
R528  
R529  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
100K  
100K  
5%  
5%  
1/16W  
1/16W  
(EXCEPT M670:US)  
(M670:US)  
R409  
R410  
R411  
R412  
1-216-073-00 METAL CHIP  
1-216-073-00 METAL CHIP  
1-216-057-00 METAL CHIP  
1-216-841-11 METAL CHIP  
10K  
10K  
2.2K  
47K  
5%  
5%  
5%  
5%  
1/10W  
1/10W  
1/10W  
R530  
R535  
R536  
1-216-864-91 SHORT  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
0
100K  
100K  
5%  
5%  
1/16W  
1/16W  
1/16W  
(M670:US)  
1/16W  
R537  
R538  
R539  
R540  
R541  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
100K  
100K  
100K  
100K  
100K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
R413  
1-216-841-11 METAL CHIP  
47K  
5%  
R414  
R415  
R416  
R417  
R418  
1-216-841-11 METAL CHIP  
1-216-829-11 METAL CHIP  
1-216-829-11 METAL CHIP  
1-216-829-11 METAL CHIP  
1-216-833-11 METAL CHIP  
47K  
4.7K  
4.7K  
4.7K  
10K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
R542  
R543  
R544  
R545  
R546  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-853-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
100K  
100K  
470K  
100K  
100K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
R419  
R420  
R421  
R422  
R423  
1-216-833-11 METAL CHIP  
1-216-841-11 METAL CHIP  
1-216-837-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-833-11 METAL CHIP  
10K  
47K  
22K  
100K  
10K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
R547  
R548  
R549  
R550  
R551  
1-216-821-11 METAL CHIP  
1-216-864-11 SHORT  
1-216-845-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1K  
0
100K  
1K  
1K  
5%  
1/16W  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
R424  
R425  
R451  
R452  
R453  
1-216-833-11 METAL CHIP  
1-216-829-11 METAL CHIP  
1-216-295-11 SHORT  
1-216-017-11 RES-CHIP  
1-216-295-11 SHORT  
10K  
4.7K  
0
47  
0
5%  
5%  
1/16W  
1/16W  
5%  
5%  
1/10W  
1/10W  
R552  
R553  
R601  
R602  
R603  
1-216-821-11 METAL CHIP  
1-216-817-11 METAL CHIP  
1-216-841-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
470  
47K  
100  
100  
R455  
R456  
R457  
R500  
R501  
1-216-001-00 METAL CHIP  
1-216-295-11 SHORT  
1-216-864-11 SHORT  
1-216-864-11 SHORT  
1-216-837-11 METAL CHIP  
10  
0
0
0
22K  
(AEP,UK,E)  
1/16W  
R604  
R605  
R606  
1-216-835-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-809-11 METAL CHIP  
15K  
1K  
100  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
(AEP,UK,E)  
1/16W  
(AEP,UK,E)  
5%  
5%  
R502  
R503  
R504  
R505  
R506  
1-216-821-11 METAL CHIP  
1-216-864-11 SHORT  
1-216-833-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-833-11 METAL CHIP  
1K  
0
10K  
100K  
10K  
1/16W  
R607  
R608  
1-216-809-11 METAL CHIP  
1-218-716-11 METAL CHIP  
100  
10K  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
0.5% 1/16W  
R650  
R651  
R652  
R653  
R654  
1-216-833-11 METAL CHIP  
1-216-836-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-829-11 METAL CHIP  
10K  
18K  
1K  
100K  
4.7K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
R507  
R508  
R509  
R510  
R511  
1-216-833-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-864-11 SHORT  
10K  
100K  
1K  
1K  
0
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
73  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
SERVO  
MAIN  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
R655  
R656  
R657  
R658  
R659  
1-216-837-11 METAL CHIP  
1-216-304-11 METAL CHIP  
1-216-839-11 METAL CHIP  
1-216-304-11 METAL CHIP  
1-216-304-11 METAL CHIP  
22K  
3.3  
33K  
3.3  
3.3  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/10W  
1/16W  
1/10W  
1/10W  
R824  
R825  
R827  
R828  
R830  
1-216-817-11 METAL CHIP  
1-216-857-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-845-11 METAL CHIP  
470  
1M  
100K  
1K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
100K  
R660  
R661  
R662  
R701  
R702  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-304-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-821-11 METAL CHIP  
100  
100  
3.3  
1K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/10W  
1/16W  
1/16W  
< THERMISTOR (POSITIVE) >  
TH101 1-810-940-11 THERMISTOR, POSITIVE  
TH102 1-810-940-11 THERMISTOR, POSITIVE  
TH601 1-801-792-21 THERMISTOR, POSITIVE  
1K  
R703  
R704  
R705  
R708  
R709  
1-216-821-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-864-11 SHORT  
1K  
1K  
1K  
1K  
0
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
< TUNER >  
TUX201 A-3220-813-A TUNER UNIT (TUX-020)  
< VIBRATOR >  
R711  
R712  
R713  
R714  
R715  
1-216-864-11 SHORT  
1-216-845-11 METAL CHIP  
1-216-864-11 SHORT  
1-216-821-11 METAL CHIP  
1-216-864-11 SHORT  
0
X201  
X501  
X503  
X701  
X801  
1-579-900-21 VIBRATOR, CRYSTAL (4.332MHz) (AEP,UK,E)  
1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz)  
1-767-993-31 VIBRATOR, CRYSTAL (3.68MHz)  
1-781-822-21 VIBRATOR, CERAMIC (18.432MHz)  
1-781-282-11 VIBRATOR, CERAMIC (4MHz)  
100K  
0
1K  
5%  
5%  
1/16W  
1/16W  
0
*************************************************************  
R716  
R717  
R718  
R719  
R722  
1-216-821-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
100K  
100K  
100K  
100K  
*
A-3294-809-A SERVO BOARD, COMPLETE  
**********************  
< CAPACITOR >  
R723  
R724  
R725  
R726  
R727  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-833-11 METAL CHIP  
1-216-845-11 METAL CHIP  
100K  
100K  
100K  
10K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
C101  
C103  
C104  
C106  
C107  
1-115-156-11 CERAMIC CHIP 1uF  
10V  
4V  
10V  
16V  
10V  
1-104-609-11 ELECT CHIP  
100uF  
20%  
1-115-156-11 CERAMIC CHIP 1uF  
1-164-360-11 CERAMIC CHIP 0.1uF  
1-115-156-11 CERAMIC CHIP 1uF  
100K  
R801  
R802  
R803  
R804  
R805  
1-216-821-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-218-716-11 METAL CHIP  
1-218-716-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1K  
1K  
10K  
10K  
100K  
5%  
5%  
1/16W  
1/16W  
C108  
C109  
C115  
C116  
C117  
1-162-974-11 CERAMIC CHIP 0.01uF  
1-162-917-11 CERAMIC CHIP 15PF  
1-164-733-11 CERAMIC CHIP 820PF  
1-165-128-11 CERAMIC CHIP 0.22uF  
1-164-733-11 CERAMIC CHIP 820PF  
50V  
50V  
50V  
16V  
50V  
5%  
10%  
0.5% 1/16W  
0.5% 1/16W  
5%  
1/16W  
10%  
R806  
R807  
R808  
R809  
R810  
1-216-821-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
C118  
C127  
C301  
C302  
C303  
1-164-360-11 CERAMIC CHIP 0.1uF  
16V  
10V  
10V  
16V  
25V  
100  
100  
1K  
1-104-851-11 ELECT CHIP  
1-126-393-11 ELECT CHIP  
10uF  
33uF  
10%  
20%  
1-164-360-11 CERAMIC CHIP 0.1uF  
1-163-037-11 CERAMIC CHIP 0.022uF 10%  
1K  
R811  
R812  
R813  
R814  
R815  
1-216-821-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-817-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1K  
1K  
1K  
470  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
C304  
C305  
C306  
C307  
C308  
1-163-037-11 CERAMIC CHIP 0.022uF 10%  
1-162-965-11 CERAMIC CHIP 0.0015uF 10%  
1-162-965-11 CERAMIC CHIP 0.0015uF 10%  
25V  
50V  
50V  
50V  
50V  
1-162-962-11 CERAMIC CHIP 470PF  
10%  
100K  
1-162-962-11 CERAMIC CHIP 470PF  
10%  
R816  
R817  
R818  
R819  
R820  
1-216-813-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-841-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
220  
1K  
47K  
100K  
100K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
C309  
C310  
C311  
C502  
C504  
1-164-227-11 CERAMIC CHIP 0.022uF 10%  
1-125-838-11 CERAMIC CHIP 2.2uF 10%  
1-164-677-11 CERAMIC CHIP 0.033uF 10%  
1-162-965-11 CERAMIC CHIP 0.0015uF 10%  
1-162-967-11 CERAMIC CHIP 0.0033uF 10%  
25V  
6.3V  
16V  
50V  
50V  
R821  
R822  
R823  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-821-11 METAL CHIP  
100K  
100K  
1K  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
C505  
C506  
C507  
1-165-176-11 CERAMIC CHIP 0.047uF 10%  
16V  
16V  
16V  
1-107-823-11 CERAMIC CHIP 0.47uF  
1-107-826-11 CERAMIC CHIP 0.1uF  
10%  
10%  
74  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
SERVO  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
C508  
C509  
C510  
C511  
C512  
1-164-230-11 CERAMIC CHIP 220PF  
1-164-360-11 CERAMIC CHIP 0.1uF  
1-164-217-11 CERAMIC CHIP 150PF  
1-164-217-11 CERAMIC CHIP 150PF  
1-162-963-11 CERAMIC CHIP 680PF  
5%  
50V  
16V  
50V  
50V  
50V  
R111  
R113  
R122  
R123  
R127  
1-216-842-11 METAL CHIP  
1-216-839-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-839-11 METAL CHIP  
1-216-821-11 METAL CHIP  
56K  
33K  
100K  
33K  
1K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
5%  
5%  
10%  
C513  
C515  
C516  
C517  
C518  
1-162-963-11 CERAMIC CHIP 680PF  
1-164-360-11 CERAMIC CHIP 0.1uF  
1-162-974-11 CERAMIC CHIP 0.01uF  
1-164-360-11 CERAMIC CHIP 0.1uF  
1-164-360-11 CERAMIC CHIP 0.1uF  
10%  
50V  
16V  
50V  
16V  
16V  
R213  
R301  
R302  
R303  
R304  
1-216-821-11 METAL CHIP  
1-216-839-11 METAL CHIP  
1-216-839-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-839-11 METAL CHIP  
1K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
33K  
33K  
1K  
33K  
C519  
C520  
C521  
C522  
C550  
1-164-360-11 CERAMIC CHIP 0.1uF  
1-164-360-11 CERAMIC CHIP 0.1uF  
1-164-360-11 CERAMIC CHIP 0.1uF  
1-164-360-11 CERAMIC CHIP 0.1uF  
1-164-360-11 CERAMIC CHIP 0.1uF  
16V  
16V  
16V  
16V  
16V  
R306  
R307  
R308  
R309  
R310  
1-216-833-11 METAL CHIP  
1-216-833-11 METAL CHIP  
1-216-833-11 METAL CHIP  
1-216-833-11 METAL CHIP  
1-216-833-11 METAL CHIP  
10K  
10K  
10K  
10K  
10K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
C553  
C554  
1-164-360-11 CERAMIC CHIP 0.1uF  
1-164-360-11 CERAMIC CHIP 0.1uF  
16V  
16V  
R311  
R312  
R313  
R314  
R315  
1-216-833-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-842-11 METAL CHIP  
1-216-842-11 METAL CHIP  
1-216-842-11 METAL CHIP  
10K  
100K  
56K  
56K  
56K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
< CONNECTOR >  
CN1  
CN2  
CN3  
1-764-616-12 HOUSING, CONNECTOR (PC BOARD) 30P  
1-794-153-21 CONNECTOR, FPC (ZIF) 16P  
1-770-347-21 CONNECTOR, FPC 6P  
R316  
R317  
R318  
R319  
R320  
1-216-842-11 METAL CHIP  
1-216-838-11 METAL CHIP  
1-216-840-11 METAL CHIP  
1-216-840-11 METAL CHIP  
1-216-833-11 METAL CHIP  
56K  
27K  
39K  
39K  
10K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
< FERRITE BEAD >  
FB101 1-469-710-21 INDUCTOR, FERRITE BEAD  
FB102 1-469-710-21 INDUCTOR, FERRITE BEAD  
FB503 1-469-730-11 INDUCTOR, FERRITE BEAD  
R321  
R322  
R501  
R503  
R504  
1-216-846-11 METAL CHIP  
1-216-835-11 METAL CHIP  
1-216-833-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-857-11 METAL CHIP  
120K  
15K  
10K  
100K  
1M  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
< IC >  
IC1  
IC5  
IC7  
IC501  
8-752-095-36 IC CXA2596M-T6  
8-752-920-24 IC CXP84640-081Q  
8-759-832-99 IC LA6576L-TE-L  
8-752-392-04 IC CXD2598Q  
R505  
R506  
R507  
R511  
R513  
1-216-839-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-827-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-827-11 METAL CHIP  
33K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
100K  
3.3K  
100K  
3.3K  
< JUMPER RESISTOR >  
JR501 1-216-864-11 SHORT  
JR505 1-216-864-11 SHORT  
JR506 1-216-864-11 SHORT  
0
0
0
R516  
R517  
R518  
R519  
R520  
1-216-845-11 METAL CHIP  
1-216-837-11 METAL CHIP  
1-216-834-11 METAL CHIP  
1-216-834-11 METAL CHIP  
1-216-834-11 METAL CHIP  
100K  
22K  
12K  
12K  
12K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
< TRANSISTOR >  
Q101  
8-729-904-87 TRANSISTOR 2SB1197K-T-146-R  
< RESISTOR >  
R521  
R522  
R523  
R524  
R526  
1-216-834-11 METAL CHIP  
1-216-834-11 METAL CHIP  
1-216-834-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
12K  
12K  
12K  
100K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
R101  
R102  
R103  
R104  
R105  
1-216-847-11 METAL CHIP  
1-216-847-11 METAL CHIP  
1-216-801-11 METAL CHIP  
1-216-857-11 METAL CHIP  
1-216-833-11 METAL CHIP  
150K  
150K  
22  
1M  
10K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
100K  
R527  
R531  
R532  
R533  
R535  
1-216-845-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
100K  
100  
100K  
100K  
100K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
R106  
R107  
R108  
R109  
R110  
1-216-857-11 METAL CHIP  
1-216-835-11 METAL CHIP  
1-216-838-11 METAL CHIP  
1-216-801-11 METAL CHIP  
1-216-843-11 METAL CHIP  
1M  
15K  
27K  
22  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
R551  
R552  
R553  
1-216-841-11 METAL CHIP  
1-216-841-11 METAL CHIP  
1-216-845-11 METAL CHIP  
47K  
47K  
100K  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
68K  
75  
Download from Www.Somanuals.com. All Manuals Search And Download.  
       
CDX-M620/M670  
SERVO SUB (CD) SW  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
R554  
R555  
R558  
R560  
R563  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-864-11 SHORT  
1-216-809-11 METAL CHIP  
1-216-809-11 METAL CHIP  
100K  
100K  
0
100  
100  
5%  
5%  
1/16W  
1/16W  
< TRANSISTOR >  
Q901  
Q902  
8-729-216-22 TRANSISTOR 2SA1037K-T-146-S  
8-729-038-67 TRANSISTOR KRC102S  
5%  
5%  
1/16W  
1/16W  
< RESISTOR >  
R564  
R568  
R569  
R570  
R572  
1-216-845-11 METAL CHIP  
1-216-837-11 METAL CHIP  
1-216-809-11 METAL CHIP  
1-216-821-11 METAL CHIP  
1-216-809-11 METAL CHIP  
100K  
22K  
100  
1K  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
1/16W  
R901  
R902  
R903  
R904  
R906  
1-216-833-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-825-11 METAL CHIP  
1-216-035-00 METAL CHIP  
1-216-811-11 METAL CHIP  
10K  
100K  
2.2K  
270  
5%  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/10W  
1/16W  
100  
150  
R590  
R594  
R595  
R599  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-845-11 METAL CHIP  
1-216-821-11 METAL CHIP  
100K  
100K  
100K  
1K  
5%  
5%  
5%  
5%  
1/16W  
1/16W  
1/16W  
1/16W  
R907  
R908  
R909  
1-216-864-11 SHORT  
1-216-850-11 METAL CHIP  
1-216-846-11 METAL CHIP  
0
270K  
120K  
5%  
5%  
1/16W  
1/16W  
< SWITCH >  
< SWITCH >  
SW1  
1-762-944-12 SWITCH, DETECTION (SMALL TYPE) (DOWN)  
< VIBRATOR >  
SW901 1-692-135-21 SWITCH, KEYBOARD (RESET)  
*************************************************************  
*
1-681-375-11 SW BOARD  
X1  
X2  
1-781-758-21 VIBRATOR, CERAMIC (CHIP TYPE) (10MHz)  
1-781-759-21 VIBRATOR, CERAMIC (CHIP TYPE) (16MHz)  
**********  
*************************************************************  
< SWITCH >  
*
1-681-373-11 SUB (CD) BOARD  
SW1001 1-771-937-21 SWITCH, DETECTION (OPEN/CLOSE)  
SW1002 1-529-566-31 SWITCH, PUSH (1 KEY) (CENTER)  
**************  
*************************************************************  
< CAPACITOR >  
MISCELLANEOUS  
C903  
C904  
C905  
C906  
C907  
1-164-156-11 CERAMIC CHIP 0.1uF  
1-164-156-11 CERAMIC CHIP 0.1uF  
25V  
25V  
6.3V  
25V  
6.3V  
***************  
1-124-778-00 ELECT CHIP  
22uF  
20%  
10%  
10%  
2
2
1-776-207-72 CORD (WITH CONNECTOR) (POWER) (US)  
1-776-527-71 CORD (WITH CONNECTOR) (ISO) (POWER)  
1-162-970-11 CERAMIC CHIP 0.01uF  
1-125-837-11 CERAMIC CHIP 1uF  
(AEP,UK,E)  
113  
114  
115  
1-777-246-41 CORD (WITH CONNECTOR) (ANT)  
1-790-375-21 CORD (WITH CONNECTOR) (SUB OUT (MONO))  
1-757-775-11 CORD (WITH CONNECTOR) (AUX-IN (AUDIO))  
C908  
1-164-388-11 CERAMIC CHIP 270PF  
< FLAT CABLE >  
5%  
50V  
177  
351  
356  
357  
0360  
1-681-390-11 FLEXIBLE BOARD  
CN901 1-783-268-11 CABLE, FLAT 11P  
< DIODE >  
X-3378-480-1 CHASSIS (OP) ASSY (including M901)  
1-676-707-11 PICK-UP FLEXIBLE BOARD  
1-677-182-11 MOTOR FLEXIBLE BOARD  
8-820-103-03 PICK-UP, OPTICAL KSS-720A/K1RP  
D901  
D902  
D903  
D906  
D907  
8-719-988-61 DIODE 1SS355TE-17  
8-719-017-95 DIODE KDZ18V  
8-719-079-10 LED CL-220UB-X-TS (DISC IN)  
8-719-422-41 DIODE MA8051-L-TX  
8-719-977-12 DIODE MA8068-M-TX  
F901  
1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A  
X-3378-769-1 MOTOR ASSY (OPEN/CLOSE)  
A-3301-985-A MOTOR ASSY, SLED (SLED)  
M601  
M902  
M903  
A-3315-039-A MOTOR SUB ASSY, LO (LOADING)  
*************************************************************  
D908  
8-719-083-14 DIODE RRX9000-0501  
< FERRITE BEAD >  
FB903 1-500-329-21 INDUCTOR, FERRITE BEAD  
< IC >  
IC901  
8-759-830-18 IC RRX9000-0601#1  
The components identified by  
mark 0 or dotted line with mark  
0 are critical for safety.  
Replace only with part number  
specified.  
76  
Download from Www.Somanuals.com. All Manuals Search And Download.  
 
CDX-M620/M670  
Ref. No.  
Part No.  
Description  
Remark  
Ref. No.  
Part No.  
Description  
Remark  
ACCESSORIES & PACKING MATERIALS  
PARTS FOR INSTALLATION AND CONNECTIONS  
********************************  
**************************************  
1-476-546-11 REMOTE COMMANDER (RM-X111) (AEP,UK,E)  
1-476-546-21 REMOTE COMMANDER (RM-X110) (US)  
3-230-446-11 MANUAL, INSTRUCTION (ENGLISH,FRENCH,  
SPANISH) (US)  
3-230-447-11 MANUAL, INSTRUCTION, INSTALL (ENGLISH,  
FRENCH,SPANISH) (US)  
401  
402  
403  
404  
405  
3-014-370-21 FRAME, FITTING  
3-916-012-01 BRACKET (ND), FITTING ASSIST (US)  
7-682-160-01 SCREW +P 4X6 (US)  
X-3368-725-1 SCREW ASSY, FITTING (US)  
3-386-828-01 SCREW, FITTING (AEP,UK,E)  
3-230-448-11 MANUAL, INSTRUCTION (ENGLISH,SPANISH,  
406  
407  
408  
409  
410  
3-349-410-01 BUSHING (AEP,UK,E)  
X-3366-405-1 SCREW ASSY (EXP), FITTING (AEP,UK,E)  
3-230-445-01 COLLAR  
3-934-325-01 SCREW (+K 5X8 TP)  
1-465-459-21 ADAPTOR, ANTENNA (AEP,UK,E)  
SWEDISH,PORTUGUESE,GREEK,  
RUSSIAN) (AEP,UK,E)  
3-230-449-11 MANUAL, INSTRUCTION, INSTALL (ENGLISH,  
GERMAN,FRENCH,ITALIAN,  
DUTCH) (AEP,UK,E)  
3-230-549-01 LID, BATTERY CASE (for RM-X110/X111)  
X-3378-390-1 CASE ASSY (for FRONT PANEL)  
411  
412  
413  
3-030-929-01 SPRING, FITTING  
1-776-207-72 CORD (WITH CONNECTOR) (POWER) (US)  
1-776-527-71 CORD (WITH CONNECTOR) (ISO) (POWER)  
*************************************************************  
(AEP,UK,E)  
414  
3-231-993-01 KEY (01)  
**************  
HARDWARE LIST  
**************  
401  
402  
404  
403  
#1  
#2  
#3  
#4  
#5  
7-685-790-09 SCREW +PTT 2.6X4 (S)  
7-685-792-09 SCREW +PTT 2.6X6 (S)  
7-685-794-09 SCREW +PTT 2.6X10 (S)  
7-627-553-28 SCREW, PRECISION +P 2X2.5  
7-624-102-04 STOP RING 1.5, TYPE -E  
407  
405  
408  
409  
412  
406  
#6  
#7  
#8  
#9  
#10  
7-627-552-88 SCREW, PRECISION +P 1.7X2.2  
7-685-105-19 SCREW +P 2X8 TYPE2 NON-SLIT  
7-627-553-37 SCREW, PRECISION +P 2X3 TYPE3  
7-628-253-00 SCREW, SPECIAL  
410  
413  
411  
414  
7-627-553-17 SCREW, PRECISION +P 2X2 TYPE3  
#11  
#12  
7-627-850-28 SCREW, PRECISION +P 1.4X3  
7-621-255-25 SCREW +P 2X4  
*************************************************************  
77  
Download from Www.Somanuals.com. All Manuals Search And Download.  
CDX-M620/M670  
REVISION HISTORY  
Clicking the version allows you to jump to the revised page.  
Also, clicking the version at the upper right on the revised page allows you to jump to the next revised  
page.  
Ver.  
Date  
Description of Revision  
1.0  
2001. 03  
New  
Download from Www.Somanuals.com. All Manuals Search And Download.  

Sennheiser Pacemaker SK 100 User Manual
Shark Saw NV752 User Manual
Sharp Cell Phone GT I9000 User Manual
Sherwood Scuba Diving Equipment CW6600 User Manual
Soleus Air Electric Heater HM4 15E 01 User Manual
Sony Computer Monitor LMD 1410 1420 User Manual
Sony Digital Camera SNC RX530P User Manual
Sony Headphones SRF HM03V User Manual
Sony Stereo System TA E9000ES User Manual
Tappan Range 318200505 User Manual