INFRARED WOODEN SAUNA ROOM INSTRUCTION MANUAL
Read all instructions carefully before using the wooden infrared sauna room
IG-570G
P R E C A U T I O N S F O R U S E . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
R E A D B E F O R E I NS TA L L AT I O N . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
PA RT S N A M E S . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
INSTALLATION OF SAUNA ROOM BODY ........................................3-7
CONTROL PANEL INSTRUCTION ...............................................8
WARNINGS AND SUGGESTIONS FOR USE..........................................9
C L E A N I N G A N D S TO R A G E . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
S P E C I F I C AT I O N . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
S A U N A C I R C U I T D I A G R A M . .. . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . 1 0
IG-570G-1
0
25/10/2007
Download from Www.Somanuals.com. All Manuals Search And Download.
PARTS NAMES
IG-570G-1
2
25/10/2007
Download from Www.Somanuals.com. All Manuals Search And Download.
INSTALLATION OF SAUNA ROOM BODY
1. Place the floor panel in the desired location on a level surface (Note: The floor panel must be
level before installing wall and ceiling panels. If the surface is not level you may need to
shim the bottom panel to get level.)
※ Make sure lines of the flooring of the floor panel are parallel with the front wall.
2. Place the right back panel on the floor panel.
※ The right back panel must be held by people.
3. Place the left back panel on the floor panel.
※ The right back panel must be held by people.
※ Push the left back panel tight to the back panel.
IG-570G-1
3
25/10/2007
Download from Www.Somanuals.com. All Manuals Search And Download.
4. Place the right side panel and the left side panel on the floor panel.
※ Make sure the left/right side panels and left/ right back panels are tightly fixed.
5. Place the bench support panel first and then place the bench surface panel into the sauna
room.
※ On larger sauna rooms with more than one bench, rotate the wooden bench supports
away from the side walls.
※ The side with Heating Film should be faced outside.
※ Make sure the two side slots of the long & short bench support panel are inserted into
the corresponding groove at both sides smoothly and completely. (Refer to picture 1
& picture 2)
※ Put the connector of the short sitting surport panel through the hole in the long short
sitting surport panel (please refer to the picture 3)
※ Put the two connectors connected to the connector in the back side panel, please ensure
it is fastened fully (please refer to the picture 4)
※ Place the Bench Surface Panel on the Bench Support Panel and slide toward the Back
Wall until flush to the Back Wall.
Picture 1
Picture 2
Picture 3/4
Picture 5
Picture 6
IG-570G-1
4
25/10/2007
Download from Www.Somanuals.com. All Manuals Search And Download.
6. Place the front panel on the floor panel, then lock the two inside latches between front and
right side panel and between front and left side panel.
※Place the front panel on the floor panel, then lock the two inside latches between front and
right side panel and between front and left side panel (Refer to picture 1 ).
picture 1
7. Place the top panel on the five side panels. Make sure the connection wires of three side
panels(left back, right back )protrudes through the corresponding holes of the top
panel.
※ Make sure the wire is through each hole smoothly and completely.
※ Make sure the trim of the top panel fits completely around the five side panels.
8. Make sure each of the lead wires on the top of the left back and right back is
protruding through the top panel; then plug each of the three lead wires into the three
connectors of the top panel.
IG-570G-1
5
25/10/2007
Download from Www.Somanuals.com. All Manuals Search And Download.
9. The power cord has been connected and installed in the corner place of the ceiling. You can
put it out of the cover for using. (Please see Picture 1 & Picture 2)
Picture 1
Picture 2
10．The power cord is located at the corner of the ceiling panel. Simply plug into appropriate
household outlet when ready to use the sauna. Notice the plug type of your sauna room:
Sauna models IG-510 & 520 & 570 have a 15 amp/120-volt plug.
IG-570G-1
6
25/10/2007
Download from Www.Somanuals.com. All Manuals Search And Download.
IG-570G-1
7
25/10/2007
Download from Www.Somanuals.com. All Manuals Search And Download.
CONTROL PANEL INSTRUCTION
1.Press “POWER”to switch on or off.
2.“TIME”refers to control of operating time and indicates the amount of time remaining.
※Once power is on, the default amount of operating time is at 45 minutes.
※Press “UP” and “DOWN” to adjust and set time of use; pressing once will increase
or reduce in 5 minute increments. The maximum operating time is 60 minutes.
※After time of use is set, the number will flash for about three seconds.
※After the set “Time” stops flashing , the number indicated will show operating time
remaining.
3.“TEMP”refers to control of the “set temperature” and also indicates the “actual
temperature” inside sauna room.
※“°C/°F”refer to the switching of“°C”and“°F”.
※Once the control is turned on, the indicated temperature of use defaults to 120 degrees
F (50°C).
※Press“HIGH”or“LOW”to adjust and set temperature in sauna room; pressing once
will increase or reduce in one degree increments. The maximum set temperature is 150°
F/65°C.
※After temperature of use is set, the number of temperature will flash for about 5
minutes.
※After the numbers of the set temperature stop flashing, the number indicated will show
actual temperature inside sauna room.
4. Press “Internal Light” to switch on or off.
IG-570G-1
8
25/10/2007
Download from Www.Somanuals.com. All Manuals Search And Download.
WARNINGS AND SUGGESTIONS FOR USE
Please read carefully the following warnings, to reduce the risk of burns, fire, electric shock, or
injury to persons:
※Do not put the sauna room in a moist environment.
※Place room on level surface.
※Do not repair the product by yourself. Contact the Saunatec National Customer Service
Center toll-free at 1-888-780-4427, or email at [email protected].
※Do not disassemble the product by yourself except as indicated in the manual.
※Do not spray the heater with water.
※Do not use any sharp tools on or near the heaters (severe damage may result).
※Do not use the product for any other purpose than originally designed and intended.
※Do not directly touch the heater with hands or body for extended periods of time.
※Do not use continuously for more than one hour.
SUGGESTIONS FOR USE
※When enjoying a sauna room bath, it is suggested to turn power on at least 15 minutes
beforehand. After 15 minutes of preheating, the temperature inside the sauna room should
reach about 105 degrees F (40°C) ; at this stage most people find the sauna a comfortable
temperature to begin the sauna bath. The temperature will continue to rise to the set
temperature.
※If it feels too hot during use, adjust the temperature down, open the vent or open the door
for fresh air.
CLEANING
Clean the outside and inside with a damp cloth, or clean with a small amount of hand-soap
mixed with warm water if necessary. Do not use benzene, alcohol, or strong cleaning chemicals
on sauna.
Note: Some chemicals can damage wood material and the protection layer that is on the outside
wood surface.
STORAGE
Do not store product in a moist environment or in direct sunlight.
SPECIFICATION
Product Name
Product No.
Product Size
Weight
Infrared Wooden Sauna Room
IG-570G
126×64.7/89.7/64.7×190(H)cm(49.6“
ca. 175 kg
×25.5“/35.3“/25.5“×74.8“)
Power Supply
AC120V
Power Consumption 1620W
Wooden Material
Canadian Hemlock
IG-570G-1
9
25/10/2007
Download from Www.Somanuals.com. All Manuals Search And Download.
IG-570G-1
25/10/2007
10
Download from Www.Somanuals.com. All Manuals Search And Download.
IG-570G-1
25/10/2007
11
Download from Www.Somanuals.com. All Manuals Search And Download.
|