Hardware Replacement Guide
Lenovo 3000 J Series
Types 7387, 7388, 7389, 7393, 7394, 7395
Download from Www.Somanuals.com. All Manuals Search And Download.
Lenovo 3000 J Series
Download from Www.Somanuals.com. All Manuals Search And Download.
Second Edition (February 2007)
© Copyright Lenovo 2005, 2007.
Portions © Copyright International Business Machines Corporation 2005.
All rights reserved.
U.S. GOVERNMENT USERS – RESTRICTED RIGHTS: Our products and/or services are provided with
RESTRICTED RIGHTS. Use, duplication or disclosure by the Government is subject to the GSA ADP Schedule
contract with Lenovo Group Limited, if any, or the standard terms of this commercial license, or if the agency is
unable to accept this Program under these terms, then we provide this Program under the provisions set forth in
Commercial Computer Software–Restricted Rights at FAR 52.227-19, when applicable, or under Rights in
Data-General, FAR 52.227.14 (Alternate III).
Download from Www.Somanuals.com. All Manuals Search And Download.
Contents
© Lenovo 2005, 2007. Portions © IBM Corp. 2005.
Download from Www.Somanuals.com. All Manuals Search And Download.
iii
iv Hardware Replacement Guide
Download from Www.Somanuals.com. All Manuals Search And Download.
Overview
This guide is intended to be used by customers who are replacing Customer
Replaceable Units (CRUs). In this document, CRUs will be referred to as parts.
This guide does not include procedures for all parts. It is expected that cables,
switches, and certain mechanical parts can be replaced by trained service personnel
without the need for step-by-step procedures.
This guide contains instructions for replacing the following parts:
Note: Use only the parts provided by Lenovo™.
v Memory module
v PCI adapter card
v Keyboard
v Mouse
Safety information
Do not open your computer or attempt any repair before reading the “Important
safety information” in the Safety and Warranty Guide that was included with your
computer. To obtain a copy of the Safety and Warranty Guide, go to the World Wide
Additional information resources
If you have Internet access, the most up-to-date information for your computer is
available from the World Wide Web.
You can find the following information:
v CRU removal and installation instructions
v CRU removal and installation videos
v Publications
v Troubleshooting information
v Parts information
v Downloads and drivers
v Links to other useful sources of information
v Support phone list
Tools required
To replace some parts in your computer, you might need a flat-blade or Phillips
screwdriver. Additional tools might be needed for certain parts.
Handling static-sensitive devices
Static electricity, although harmless to you, can seriously damage computer
components and parts.
© Lenovo 2005, 2007. Portions © IBM Corp. 2005.
Download from Www.Somanuals.com. All Manuals Search And Download.
v
When replacing a part, do not open the static-protective package containing the
new part until the defective part has been removed from the computer and you are
ready to install the new part.
When you handle parts and other computer components, take these precautions to
avoid static-electricity damage:
v Limit your movement. Movement can cause static electricity to build up around
you.
v Always handle parts and other computer components carefully. Handle
adapters, memory modules, system boards, and microprocessors by the edges.
Never touch any exposed circuitry.
v Prevent others from touching the parts and other computer components.
v Before you replace a new part, touch the static-protective package containing the
part to a metal expansion-slot cover or other unpainted metal surface on the
computer for at least two seconds. This reduces static electricity in the package
and your body.
v When possible, remove the new part from the static-protective packaging and
install it directly in the computer without setting the part down. When this is
not possible, place the static-protective package that the part came in on a
smooth, level surface and place the part on it.
v Do not place the part on the computer cover or other metal surface.
vi Hardware Replacement Guide
Download from Www.Somanuals.com. All Manuals Search And Download.
Chapter 1. Locations
This chapter provides illustrations to help locate the various connectors, controls
and components of the computer. To remove the computer cover, see “Removing
Locating the connectors on the front of your computer
The following illustration shows the location of connectors on the front of the
computer.
ꢀ1ꢁ
ꢀ2ꢁ
Headphone connector
Microphone connector
ꢀ3ꢁ
ꢀ4ꢁ
USB connector
USB connector
© Lenovo 2005, 2007. Portions © IBM Corp. 2005.
Download from Www.Somanuals.com. All Manuals Search And Download.
1
Locating the connectors on the rear of your computer
The following illustration shows the location of connectors on the rear of the
computer.
ꢀ1ꢁ
ꢀ2ꢁ
Power connector
Voltage-selection switch (some ꢀ10ꢁ
ꢀ9ꢁ
Ethernet connector
USB connectors
models)
ꢀ3ꢁ
ꢀ4ꢁ
ꢀ5ꢁ
ꢀ6ꢁ
Mouse connector
Keyboard connector
Serial connector
ꢀ11ꢁ
ꢀ12ꢁ
ꢀ13ꢁ
ꢀ14ꢁ
Microphone connector
Audio line out connector
Audio line in connector
PCI Express x1 adapter or PCI Express x16
adapter connector (some models)
PCI Express x1 adapter or PCI Express x16
adapter connector (some models)
PCI adapter connectors
Parallel connector
ꢀ7ꢁ
ꢀ8ꢁ
VGA monitor connector
USB connectors
ꢀ15ꢁ
ꢀ16ꢁ
2
Hardware Replacement Guide
Download from Www.Somanuals.com. All Manuals Search And Download.
Locating components
The following illustration will help you locate the various components in your
computer.
ꢀ1ꢁ
ꢀ2ꢁ
ꢀ3ꢁ
Microprocessor and heat sink
Memory modules
PCI Express x1 adapter or PCI Express ꢀ7ꢁ
x16 graphics adapter connector (some
models)
ꢀ5ꢁ
ꢀ6ꢁ
PCI adapter connectors
PCI adapter
Power supply assembly
ꢀ4ꢁ
PCI Express x16 graphics adapter or
PCI Express x1 adapter connector
(some models)
Chapter 1. Locations
3
Download from Www.Somanuals.com. All Manuals Search And Download.
Identifying parts on the system board
The system board (sometimes called the planar or motherboard) is the main circuit
board in your computer. It provides basic computer functions and supports a
variety of devices.
The following illustration shows the locations of parts on the system board for
some computer models.
ꢀ1ꢁ
ꢀ2ꢁ
ꢀ3ꢁ
ꢀ4ꢁ
ꢀ5ꢁ
ꢀ6ꢁ
ꢀ7ꢁ
Microprocessor fan connector
Microprocessor and heat sink
Memory connector 1
Memory connector 2
Clear CMOS/Recovery jumper ꢀ15ꢁ
ꢀ11ꢁ
ꢀ12ꢁ
ꢀ13ꢁ
ꢀ14ꢁ
Front panel connector
SATA IDE connectors (2)
Front USB connectors (2)
Serial (COM) connector
PCI adapter connectors
Front audio connector
PCI Express x16 graphics adapter
connector
Power connector
Diskette drive connector
ꢀ16ꢁ
ꢀ17ꢁ
ꢀ8ꢁ
ꢀ9ꢁ
ꢀ10ꢁ
IDE connector 1
IDE connector 2
Battery
ꢀ18ꢁ
ꢀ19ꢁ
ꢀ20ꢁ
PCI Express x1 adapter connector
System fan connector
12v power connector
4
Hardware Replacement Guide
Download from Www.Somanuals.com. All Manuals Search And Download.
The following illustration shows the locations of parts on the system board for
some computer models.
ꢀ1ꢁ
ꢀ2ꢁ
ꢀ3ꢁ
ꢀ4ꢁ
ꢀ5ꢁ
ꢀ6ꢁ
ꢀ7ꢁ
Microprocessor and heat sink
Microprocessor fan connector
Memory connector 1
Memory connector 2
Power connector
ꢀ11ꢁ
ꢀ12ꢁ
ꢀ13ꢁ
ꢀ14ꢁ
ꢀ15ꢁ
ꢀ16ꢁ
ꢀ17ꢁ
Front USB connectors (2)
Serial (COM) connector
Front audio connector
PCI adapter connectors (2)
PCI Express x1 adapter connector
Battery
Diskette drive connector
IDE connector
PCI Express x16 graphics adapter
connector
ꢀ8ꢁ
ꢀ9ꢁ
SATA IDE connectors (2)
Front panel connector
ꢀ18ꢁ
ꢀ19ꢁ
System fan connector
12v power connector
ꢀ10ꢁ
Clear CMOS/Recovery jumper
Chapter 1. Locations
5
Download from Www.Somanuals.com. All Manuals Search And Download.
6
Hardware Replacement Guide
Download from Www.Somanuals.com. All Manuals Search And Download.
Chapter 2. Replacing hardware
Attention
Do not open your computer or attempt any repair before reading the “Important safety
information” in the Safety and Warranty Guide that was included with your computer. To
Note: Use only the parts provided by Lenovo.
Removing the cover
Important
Turn off the computer and wait 3 to 5 minutes to let the computer cool
before opening the computer cover.
To remove the computer cover, do the following:
1. Shut down your operating system, remove any media (diskettes, CDs, or tapes)
from the drives, and turn off all attached devices and the computer.
2. Unplug all power cords from electrical outlets.
3. Disconnect all cables attached to the computer. This includes power cords,
input/output (I/O) cables, and any other cables that are connected to the
computer.
© Lenovo 2005, 2007. Portions © IBM Corp. 2005.
Download from Www.Somanuals.com. All Manuals Search And Download.
7
4. Remove the two screws at the rear of the left side cover and slide the cover to
the rear to remove.
Replacing a memory module
Attention
Do not open your computer or attempt any repair before reading the “Important safety
information” in the Safety and Warranty Guide that was included with your computer. To
This section provides instructions on how to replace a memory module.
Note: Your computer has support for two memory modules.
8
Hardware Replacement Guide
Download from Www.Somanuals.com. All Manuals Search And Download.
2. Remove the memory module being replaced by opening the retaining clips as
shown.
3. Position the replacement memory module over the memory connector. Make
sure that the notch ꢀ1ꢁon the memory module aligns correctly with the
connector keyꢀ2ꢁ on the system board. Push the memory module straight
down into the memory connector until the retaining clips close.
Replacing a PCI adapter
Attention
Do not open your computer or attempt any repair before reading the “Important safety
information” in the Safety and Warranty Guide that was included with your computer. To
Chapter 2. Replacing hardware
9
Download from Www.Somanuals.com. All Manuals Search And Download.
This section provides instructions on how to replace a PCI adapter.
2. Remove the screw securing the adapter in the connector.
3. Remove the adapter being replaced.
4. Remove the new adapter from its static-protective package.
5. Install the new adapter into the appropriate slot on the system board.
6. Install the screw to secure the new adapter.
10 Hardware Replacement Guide
Download from Www.Somanuals.com. All Manuals Search And Download.
Replacing a keyboard
Attention
Do not open your computer or attempt any repair before reading the “Important safety
information” in the Safety and Warranty Guide that was included with your computer. To
This section provides instructions on how to replace a keyboard.
1. Remove any media (diskettes, CDs, or tapes) from the drives, shut down your
operating system, and turn off all attached devices.
2. Unplug all power cords from electrical outlets.
3. Locate the keyboard connector.
Note: Your keyboard might be connected to a standard keyboard connector
ꢀ1ꢁor a USB connector ꢀ2ꢁ. Depending on where your keyboard is
connected, see “Locating the connectors on the rear of your computer”
4. Disconnect the failing keyboard cable from the computer.
5. Connect the new keyboard to the appropriate connector on the computer.
Replacing a mouse
Attention
Do not open your computer or attempt any repair before reading the “Important safety
information” in the Safety and Warranty Guide that was included with your computer. To
This section provides instructions on how to replace a mouse.
1. Remove any media (diskettes, CDs, or tapes) from the drives, shut down your
operating system, and turn off all attached devices.
2. Unplug all power cords from electrical outlets.
Chapter 2. Replacing hardware 11
Download from Www.Somanuals.com. All Manuals Search And Download.
3. Locate the mouse connector.
Note: Your mouse might be connected to a standard mouse connector ꢀ1ꢁor a
4. Disconnect the failing mouse cable from the computer.
5. Connect the new mouse to the appropriate connector on the computer.
Completing the parts replacement
After working with parts, you need to replace the computer cover and reconnect
any cables, including telephone lines and power cords. Also, depending on the
part that was replaced, you might need to confirm the updated information in the
Setup Utility program.
1. Ensure that all components have been reassembled correctly and that no tools
or loose screws are left inside your computer.
2. Reposition any cables that might impede the replacement of the cover.
12 Hardware Replacement Guide
Download from Www.Somanuals.com. All Manuals Search And Download.
3. Position the computer cover on the chassis so that the rail guides on the bottom
of the cover engage the rails and push the cover to the closed position. Install
the two screws that secure the computer cover.
4. Install any locking devices such as a padlock as necessary.
6. To update the configuration, see ″Using the Setup Utility″ in the User Guide that
was included with your computer.
Note: In most areas of the world, Lenovo requires the return of the defective CRU.
Information about this will come with the CRU or will come a few days
after the CRU arrives.
Chapter 2. Replacing hardware 13
Download from Www.Somanuals.com. All Manuals Search And Download.
14 Hardware Replacement Guide
Download from Www.Somanuals.com. All Manuals Search And Download.
Appendix. Notices
Lenovo may not offer the products, services, or features discussed in this
document in all countries. Consult your local Lenovo representative for
information on the products and services currently available in your area. Any
reference to a Lenovo product, program, or service is not intended to state or
imply that only that Lenovo product, program, or service may be used. Any
functionally equivalent product, program, or service that does not infringe any
Lenovo intellectual property right may be used instead. However, it is the user’s
responsibility to evaluate and verify the operation of any other product, program,
or service.
Lenovo may have patents or pending patent applications covering subject matter
described in this document. The furnishing of this document does not give you
any license to these patents. You can send license inquiries, in writing, to:
Lenovo (United States), Inc.
500 Park Offices Drive, Hwy. 54
Research Triangle Park, NC 27709
U.S.A.
Attention: Lenovo Director of Licensing
LENOVO GROUP LTD. PROVIDES THIS PUBLICATION “AS IS” WITHOUT
WARRANTY OF ANY KIND, EITHER EXPRESS OR IMPLIED, INCLUDING, BUT
NOT LIMITED TO, THE IMPLIED WARRANTIES OF NON-INFRINGEMENT,
MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE. Some
jurisdictions do not allow disclaimer of express or implied warranties in certain
transactions, therefore, this statement may not apply to you.
This information could include technical inaccuracies or typographical errors.
Changes are periodically made to the information herein; these changes will be
incorporated in new editions of the publication. Lenovo may make improvements
and/or changes in the product(s) and/or the program(s) described in this
publication at any time without notice.
The products described in this document are not intended for use in implantation
or other life support applications where malfunction may result in injury or death
to persons. The information contained in this document does not affect or change
Lenovo product specifications or warranties. Nothing in this document shall
operate as an express or implied license or indemnity under the intellectual
property rights of Lenovo or third parties. All information contained in this
document was obtained in specific environments and is presented as an
illustration. The result obtained in other operating environments may vary.
Lenovo may use or distribute any of the information you supply in any way it
believes appropriate without incurring any obligation to you.
Any references in this publication to non-Lenovo Web sites are provided for
convenience only and do not in any manner serve as an endorsement of those Web
sites. The materials at those Web sites are not part of the materials for this Lenovo
product, and use of those Web sites is at your own risk.
Any performance data contained herein was determined in a controlled
environment. Therefore, the result obtained in other operating environments may
© Lenovo 2005, 2007. Portions © IBM Corp. 2005.
Download from Www.Somanuals.com. All Manuals Search And Download.
15
vary significantly. Some measurements may have been made on development-level
systems and there is no guarantee that these measurements will be the same on
generally available systems. Furthermore, some measurements may have been
estimated through extrapolation. Actual results may vary. Users of this document
should verify the applicable data for their specific environment.
Television output notice
The following notice applies to models that have the factory-installed
television-output feature.
This product incorporates copyright protection technology that is protected by
method claims of certain U.S. patents and other intellectual property rights owned
by Macrovision Corporation and other rights owners. Use of this copyright
protection technology must be authorized by Macrovision Corporation, and is
intended for home and other limited viewing uses only unless otherwise
authorized by Macrovision Corporation. Reverse engineering or disassembly is
prohibited.
Trademarks
Lenovo and the Lenovo logo are trademarks of Lenovo in the United States, other
countries, or both.
IBM is a trademark of the International Business Machines Corporation in the
United States, other countries, or both.
Other company, product, or service names may be trademarks or service marks of
others.
16 Hardware Replacement Guide
Download from Www.Somanuals.com. All Manuals Search And Download.
Download from Www.Somanuals.com. All Manuals Search And Download.
Part Number: 41X8111
Printed in USA
(1P) P/N: 41X8111
Download from Www.Somanuals.com. All Manuals Search And Download.
|