Owner’s Manual
KF-T4.0
Customer Service
(800) 340-0482
Manufactured By:
Keys Fitness Products
4009 Distribution Drive
Suite 250
Garland, TX 75041
CAUTION
Read all precautions and
instructions in this manual
before using this equipment.
Model Name : KF-T4.0
Serial Number :____________
Serial number can be found at
the location specified above.
100051
08/27 Rev 4.0
Download from Www.Somanuals.com. All Manuals Search And Download.
www.keysfitness.com
WARNING!
Before using this treadmill or starting any exercise program, consult your physician. This is especially important for persons
over the age of 35 and or persons with pre-existing health problems. The manufacturer or distributor assumes no responsibility
for personal injury or property damage sustained by or through the use of this product. To reduce the risk of electrical shock,
burns, fire, or other possible injuries to the user, it is important to review this manual and the following precautions before operation.
SAFETY PRECAuTIONS AND TIPS:
1. Always secure Safety Key firmly to waistband.
2. It is the owner’s responsibility to ensure that all users of this treadmill have read the owner’s Manual and are familiar with
warnings and safety precautions.
3. This treadmill has a user maximum capacity of 300 pounds.
4. The treadmill should only be used on a level surface and is intended for indoor use only. The treadmill should not be placed in a
garage, patio, or near water and should never be used while you are wet. Keys recommends a treadmill mat be placed under the
treadmill to protect floor or carpet and for easier cleaning.
5. Follow safety information in regard to plugging in your treadmill. Keep the power cord away from the incline wheels and do not run
the power cord underneath your treadmill. Do not operate the treadmill with a damaged or frayed power cord.
6. Wear comfortable, good-quality walking or running shoes and appropriate clothing. Do not use the treadmill with bare feet, sandals,
socks or stockings.
7. Always straddle the belt and allow it to start moving before stepping onto the belt.
8. Hold on to handrail when adjusting speed or other controls.
9. Always examine your treadmill before using to ensure all parts are in working order.
10. Allow the belt to fully stop before dismounting.
11. Pets should never be allowed near or on the treadmill.
12. Close supervision is necessary when this appliance is used by or near children, invalids or disabled persons.
13. Never operate the treadmill where oxygen is being administered, or where aerosol products are being used.
14. Never insert any object or body parts into any opening.
15. For safety and to prevent damage to your treadmill, no more than one person should use the treadmill at a time.
16. Always unplug the treadmill before cleaning and/or servicing. Service to your treadmill should only be performed by an authorized
service representative, unless authorized and/or instructed by the manufacturer
17. Failure to follow these instructions will void the treadmill warranty.
18. Never leave the treadmill unattended when plugged in. Unplug from outlet when not in use and before service or maintenance.
19. Always unplug this appliance immediately after using and before cleaning. To disconnect, turn all controls to the off position, then
remove plug from outlet.
Safety Information 3
Download from Www.Somanuals.com. All Manuals Search And Download.
Prior to assembly, remove components from the box and verify
that all the listed parts were supplied.
www.keysfitness.com
FENDER
CONSOLE
RIGHT FENDER
LEFT FENDER
SAFETY KEY
6MM
TOOL
END CAP LEFT
END CAP RIGHT
MAIN FRAME
SCREW/MISC
ALLEN BOLTS M8*55
ALLEN BOLTS
M8*15*15
WASHER 9* 16* 1.6MM
PHILLIPS SCREW M6*30
WASHER 6.6* 12* 1.6MM
PHILLIPS SCREW M6*20
PHILLIPS SCREW ST4.2*16
WASHER 11* 20*2MM
PHILLIPS SCREW ST4.2*13
Parts Identifier 5
Download from Www.Somanuals.com. All Manuals Search And Download.
www.keysfitness.com
6MM
TOOL
1
WASHER 9*16*1.6mm
ASSEMBLY FOR uPRIGhT TuBES
Step 1:
After unpacking the box, lift up the upright
tubes so that the screw holes are aligned.
ALLEN BOLT M8*55
Step 2:
Secure the upright connection with allen
bolts M8*55 (Qty 6) and flat washers
9*16*1.6 mm (Qty 6) at the upright tubes.
In the same area you will need to use allen
bolts M8*15*15 (Qty 4) and flat washers
9*16*1.6 mm (Qty 4) to secure as well.
WASHER 9*16*1.6mm
ALLEN BOLT M8*15*15
ALLEN BOLT M8*55
Note: Be careful not to pinch the wire
harness.
Note: Hand tighten bolts until console
is attached and secure as indicated in
page 8. Then tighten with tool provided.
ALLEN BOLT M8*15*15
6 Assembly
Download from Www.Somanuals.com. All Manuals Search And Download.
RIGHT FENDER
www.keysfitness.com
LEFT FENDER
2
ASSEMBLY FOR FENDERS
Slide the right and left fenders down the upright
assembly.
ASSEMBLY FOR END CAPS
Slide the end caps onto the main frame
and secure them with screws ST4.2*16
(Qty 2).
SCREW ST4.2*16
Assembly 7
Download from Www.Somanuals.com. All Manuals Search And Download.
www.keysfitness.com
3
CONSOLE
HARNESS
ASSEMBLY FOR CONSOLE
Step 1:
WASHER 9* 16* 1.6MM
Attach console to the left and right uprights
using flat washers 9*16*1.6 mm (Qty 6) and
allen bolts M8*15*15 (Qty 6).
ALLEN BOLT
M8*15*15
Step 2:
Connect the console harness wire to the
console.
Step 3:
Attach safety key to the console.
Note: Be careful not to pinch the wire con-
nection during assembly.
6MM
TOOL
8 Assembly
Download from Www.Somanuals.com. All Manuals Search And Download.
www.keysfitness.com
4
SCREW ST4.2*13
ASSEMBLY FOR FENDERS
Step 1:
lift up the base of the treadmill until the
pop pin located on the left side engages.
6MM
TOOL
Step 2:
on the outer part of the fenders, secure the
right and left fenders with 2 phillips screws
M6*30 and 2 flat washers M6*12*1.6 mm.
Step 3:
on the inner part of the fender secure the
right and left fenders with 2 phillips screws
M6*20 and 2 flat washers M6*12*1.6.
WASHER 6.6* 12*1.6mm
ASSEMBLY FOR END CAPS
PHILLIPS SCREW M6*20
In the treadmill’s folded position, secure
the end caps with screws ST 4.2*13 (Qty
4).
PHILLIPS SCREW M6*30
9
Assembly
Download from Www.Somanuals.com. All Manuals Search And Download.
Congratulations!
You have completed the assembly of your
new Keys Fitness T4.0 Treadmill!
10
Download from Www.Somanuals.com. All Manuals Search And Download.
www.keysfitness.com
Moving Instructions
Caution! To avoid the risk of injury, never attempt to move the treadmill while it is in the unfolded operating position. To reduce the
possibility of injury while lifting, bend your legs and keep your back straight. As you raise the treadmill, lift using your legs, not your
back. In order to raise or lower the treadmill safely, you must be able to lift 45 pounds (20kg). It is suggested you always use the aid of
a second person when moving the treadmill.
With the treadmill in the folded locked position (safety latch is engaged) carefully tilt the treadmill back until it rolls freely on the wheels. Using
extreme caution, move the treadmill to the desired location. To set the treadmill down, carefully lower treadmill onto base in resting position. Do
not attempt to move the treadmill over an uneven or rough surface.
Note: The treadmill pictured below may not be identical to your particular model.
11
Moving Instructions
Download from Www.Somanuals.com. All Manuals Search And Download.
www.keysfitness.com
Power Requirements
Improper connection of the equipment grounding connector can result in a risk of an electric shock. Check with a qualified electrician
or service man if you are in doubt as to whether the product is properly grounded. Do not modify the plug provided with the product. If
plug will not fit the outlet, have a proper outlet installed by a qualified electrician.
This treadmill can be seriously damaged by sudden voltage changes in your home’s electrical power. Voltage spikes, surges, and noise interfer-
ence can result from weather conditions or from other appliances being turned on or off. To reduce the possibility of treadmill damage, always use
a dedicated surge protector (not included) with your treadmill.
Surge protectors can be purchased at most hardware stores. The manufacturer recommends a single outlet surge protector with Ul 1449 rating as
a Transient Voltage Surge Suppressor (TVSS) with Ul suppressed voltage rating of 400V or less and an electrical rating of 120VAC, 15 amps.
This treadmill must be grounded to reduce the risk of electrical shock. Grounding provides a path of least resistance for electric current should the
treadmill malfunction. This treadmill comes with an electrical cord with an equipment-grounding conductor and a grounding plug. Always plug the
power cord into a surge protector, and plug the surge protector into an appropriate outlet that is properly installed and grounded in accordance with
all local codes and ordinances. Do not connect other equipment to the surge protector or this could cause permanent damage to your treadmill.
This product is for use on a nominal 120-volt circuit and has a grounding plug that looks like the plug illustrated in the drawing below.
Power Requirements
12
Download from Www.Somanuals.com. All Manuals Search And Download.
Console Information
13
Download from Www.Somanuals.com. All Manuals Search And Download.
www.keysfitness.com
CONSOLE FuNCTIONS
INCLINE WINDOW
Indicates incline in percent of grade 0-12% in 0.5 increments.
P U L S E
PuLSE WINDOW
Displays user’s current heart rate.
Note: User must have both on hands on the pulse grips.
C A L O R I E S
I N C L I N E
L A P P A C E
S P E E D
K
M /H
K
M
M P
H
T I M E
P R O G R A M
DI S T A N C E
TIME WINDOW
Indicates elapsed time after pressing start in minutes and sec-
onds (0-99 minutes, 0-59 seconds).
PACE WINDOW
Indicates estimated amount of time needed to complete 1 Mile
based on current speed.
CALORIES WINDOW
Indicates estimated calories used based on 150 lb. person at
the indicated speed, incline, and time.
INCLINE
ENTER
SPEED
ENTER
2
3
4
5
6
7
8
ONE TOUCH
DISTANCE WINDOW
PA USE
Indicates Miles or Kilometers traveled in .01 increments up to
9.99 and .1 increments starting at 10.0.
PROGRAM
ENTER
POWER
START /
STOP
SPEED WINDOW
Indicates MPH (miles per hour) or KPH (kilometer per hour) in
.1 increments.
LAP WINDOW
Indicates the lap count and displays which lap you are on
CONSOLE BuTTONS
POWER
This button is used to turn the treadmill on and off.
14
Console Information
Download from Www.Somanuals.com. All Manuals Search And Download.
www.keysfitness.com
START/STOP
This button is used to start or stop the current program.
PAuSE
This button is used to stop your workout temporarily and continue from where you left off when you are ready.
WARNING: ThE TREADMILL BELT WILL RESuME AT ThE SPEED ThE TREADMILL WAS MOVING AT BEFORE PAuSING.
ENTER
This button is used to confirm selection settings, such as time, distance, calories, and pulse.
PROGRAM uP AND DOWN
These buttons are used to cycle through to the desired program.
INCLINE + and -
These buttons are used to adjust the incline value during the workout.
SPEED + and -
These buttons are used to adjust the speed of the treadmill during workout. These buttons are also used to adjust the values when setting up your
workout.
PROGRAM INSTRuCTIONS
QuICK START / MANuAL MODE (P1)
1. Plug into a surge protector outlet. Attach the Safety Key to the treadmill console.
2. Stand on the treadmill and straddle belt. Attach safety key clip to your clothes.
3. Press PoWER button. There will be an eight (8) second delay after pressing the PoWER button before data can be entered.
4. Press START/SToP button. Belt will begin to move after 4 seconds. Step on belt slowly after the belt starts moving. Speed or incline may be
adjusted by using the appropriate + (increase) or – (decrease) button.
5. To end your workout, press START/SToP button. Belt will gradually slow down to zero.
6. To pause your workout, press PAUSE.
7. To re-start after pausing: Press the PAUSE button.
PROGRAM MODE
Plug treadmill into a surge protector outlet. Attach the Safety Key on to the treadmill console.
1. Stand on the treadmill and straddle belt. Attach safety key clip to your clothes.
2. Press PoWER button. There will be an eight (8) second delay before data can be entered.
15
Console Information
Download from Www.Somanuals.com. All Manuals Search And Download.
www.keysfitness.com
3. There are thirteen (13) programs. Refer to next page for a program overview that includes Speed and Incline setting for each program. Press
the PRoGRAM UP or DoWN button to select which program you wish to use. Press ENTER PRoGRAM.
4. Press START/SToP button. Belt will begin to move after 4 seconds. Step on belt slowly after the belt starts moving.
COOL DOWN
At the end of the program, the unit will enter a Cool Down program with a fixed time of 2 minutes. At this time, the TIME window will continue to
show the entered Time. The Speed and Incline will go to 1/2 of their current settings. For example, If you are running at 5 MPH with an Incline of
4%, when the unit goes into Cool Down, Speed will decrease to 2.5 MPH and the Incline will decrease to 2%. After the 2 minute Cool Down, the
unit will self power down.
NOTE: If any button is pressed during the 2 minute Cool Down period, the unit will change to Manual Mode (see P1). At this time, full manual con-
trol of treadmill settings such as Speed and Incline are available to the User.
TIME GOAL (P2):
Program allows user to set desired TIME of workout. once the desired TIME is accomplished, the treadmill will enter Cool Down.
1. Press PRoGRAM UP button or PRoGRAM DoWN button until P2 is selected. Press ENTER. The TIME window will blink. Use the SPEED +
or – arrows or toggles to select your workout time. Press ENTER.
2. The SPEED window will then blink. Use the SPEED + or – arrows or toggle to select the speed for your workout. Press ENTER.
3. The INClINE window will then blink. Use the INClINE + or – arrows or incline toggles to set your workout incline. Press ENTER.
4. To start, press the START/SToP button.
DISTANCE GOAL (P3):
Program will allow user to set desired DISTANCE for workout. Distance will count up to desired Distance. once the desired DISTANCE is accom-
plished, the treadmill will enter Cool Down.
1. Press PRoGRAM UP button or PRoGRAM DoWN button until P3 is selected. Press ENTER. The DISTANCE/CAloRIE window will blink.
Use the SPEED + or – arrows or toggles to select your workout distance. Press ENTER.
2. The SPEED window will then blink. Use the SPEED + or – arrows or toggle to select the speed for your workout. Press ENTER.
3. The INClINE window will then blink. Use the INClINE + or – arrows or incline toggles to set your workout incline. Press ENTER.
4. To start, press the START/SToP button.
CALORIES GOAL (P4):
Program allows user to set desired CAloRIES of workout. once the desired CAloRIES is accomplished, the treadmill will enter Cool Down.
1. Press PRoGRAM UP button or PRoGRAM DoWN button until P4 is selected. Press ENTER. The DISTANCE/CAloRIES window will blink.
Use the SPEED + or – arrows or toggles to select your workout CAloRIES. Press ENTER.
2. The SPEED window will then blink. Use the SPEED + or – arrows or toggle to select the speed for your workout. Press ENTER.
3. The INClINE window will then blink. Use the INClINE + or – arrows or incline toggles to set your workout incline. Press ENTER.
4. To start, press the START/SToP button.
16
Console Information
Download from Www.Somanuals.com. All Manuals Search And Download.
www.keysfitness.com
5K RuN AND 10K RuN (P5 - P6)
Pre-set programs will allow user to workout for a preset DISTANCE of 5K (3.1 Miles) and 10K (6.2 Miles). once the pre-set DISTANCE is reached,
the treadmill will enter Cool Down.
1. Press PRoGRAM UP button or PRoGRAM DoWN button until P5 or P6 is selected. Press ENTER. The SPEED window will blink. Use the
SPEED + or – arrows or toggles to select your workout SPEED. Press ENTER.
2. The INClINE window will then blink. Use the INClINE + or – arrows or incline toggles to set your workout incline. Press ENTER.
3. To start, press the START/SToP button.
PROGRAMS (P7 - P13)
These are pre-set programs with predefined values.
1. Press PRoGRAM UP or PRoGRAM DoWN until desired program is selected.
2. The TIME window will blink. Use the SPEED + or - arrows or toggles to select your workout TIME. Press ENTER.
3. The SPEED window will then blink. Use the SPEED + or – arrows or toggle to select the speed for your workout. Press ENTER.
4. To start, press the START/SToP button. Please refer to pages 17-18 for Program Profiles.
Program profiles
HILLS
INTERVAL 1
MOUNTAIN
MOUNTAIN CLIMB
10
9
8
7
6
5
4
3
2
1
0
10
9
8
7
6
5
4
3
2
1
0
10
9
8
7
6
5
4
3
2
1
0
10
9
8
7
6
5
4
3
2
1
0
P7 - Each time segment will last 1 minute, and
will either increase or decrease the incline.
This program will repeat this cycle until pro-
grammed time is accomplished.
P8 - Each time segment will last 1 minute, and will
increase incline. This program will repeat this cycle
until programmed time is accomplished.
P11 - Each time segment will last 1 minute, and
will increase or decrease incline. This will alter-
nate between 5% and 0% Incline. This program
will repeat this cycle until programmed time is
accomplished.
P9 - Each time segment will last 1 minute, and will
increase or decrease incline. This program will
repeat this cycle until programmed time is accom-
plished.
17
Console Information
Download from Www.Somanuals.com. All Manuals Search And Download.
www.keysfitness.com
INTERVAL 2
INTERVAL HILL
10
9
8
7
6
5
4
3
2
1
0
10
9
8
7
6
5
4
3
2
1
0
Frequency, Intensity, Time, Target heart Rate Zone
The exercise practices include four major variables: frequency, intensity,
time, target heart rate zone. A continuous workout will help to improve
your cardiovascular functions and increase the ability of your muscles
to obtain the oxygen and nutrition. A good workout provides a greater
advantage to extend the endurance of muscle and body flexibility.
Frequency: how Often Should You Exercise
Three to five times a week is highly suggested to improve your cardiovas-
cular and muscle fitness.
Intensity: how hard Should You Exercise
The intensity of an exercise is reflected in your heart rate. Exercise must
be sufficient to strengthen your heart muscle and condition your cardio-
vascular system. only your doctor or an authorized coach can prescribe
the target training heart range appropriate for your particular needs and
physical condition. Start with exercise that stimulates you to breathe more deeply. Alternate periods of moderate and easy exercise to help your body
adapt to new levels of exertion without unnecessary strain. The inability to maintain a smooth, rhythmic motion is a sign that your speed or elevation
is too high. If you feel out of breath before you have exercised 12 minutes, you are probably overdoing it.
As your fitness level improves, you will need to increase your workload to reach your target heart rate. The first increase may be necessary after two
to four weeks of regular exercise. Never exceed your target heart rate zone.
Weight Management
Consistent aerobic exercise will help you change your body composition by lowering your percentage of body fat. For weight control, how long and
how often you exercise is more important than how hard you exercise.
•
•
•
Exercise at least four to five times a week.
Reach and maintain 60-75% of your maximum heart rate with moderate exercise.
Exercise for 30-45 minutes at 60-65% of your target heart rate.
here are some tips to achieve your weight management goal.
•
•
•
•
Consume most of your dietary calories at breakfast and lunch, and eat a light dinner.
Do not eat anything near the bedtime.
Moderate exercise will help suppress your appetite.
Take regular breaks and rests to help increase metabolism.
18
Console Information
Download from Www.Somanuals.com. All Manuals Search And Download.
www.keysfitness.com
Warning!
If you have any questions or concerns about your target heart rate consult your physician. Medications may affect your heart rate. Stop exercise if:
you feel faint or dizzy, acute illness (cold or fever), any pain or tightness in your chest, an irregular heartbeat, of if you exceed your maximum heart
rate set by your physician.
Exercise Practice Procedures
Warm-up
Workout
Cool Down
A good warm-up will help you perform better and will decrease the aches and pains. The warm-up prepares your muscles for exercise and allows
your oxygen supply to ready itself for what is to come. Experience tells us that muscles perform best when they are warmer than normal body tem-
perature. This normally takes about 5-10 minutes when you begin to perspire on your brow and breathe more deeply.
Note: The older you are, the longer your warm-up period should be.
Workout: Brisk and Rhythmic Exercise
A workout trains your heart, lungs, and muscles to be more efficient. Increase exercise in response to your heart rate to train and strengthen your
cardiovascular system. Concentrate on moving your arms and legs smoothly. Walking naturally and avoid jerking motions like pulled muscles,
sprained joints, and loss of balance.
If you cannot sustain 12 continuous minutes in your target heart rate zone, then, exercise several times a day to get into habit. Try to reach and main-
tain 60-65% of your maximum heart rate. Alternate exercise with periods of rest until you can sustain 12 continuous minutes of exercise at 60-65%
of your maximum heart rate. Best start with a target of 3-4 minutes, then, increase it gradually.
If you can sustain 12 but not 20 continuous minutes of exercise in your target heart rate zone:
• Exercise 3-5 days a week. Rest at least two days per week.
• Try to reach and maintain 65-70% of your maximum heart rate
with moderate rhythmic exercises.
• Begin with 12 continuous minutes. Increase your time by
(MHR) = Maximum Heart Rate
(THR) = Target Heart Rate
one to two minutes per week until you can sustain 20
continuous minutes.
220 - age = maximum heart rate (MHR)
MHR x .60 = 60% of your maximum heart rate.
MHR x .75 = 75% of your maximum heart rate.
For example, if you are 30 years old, your calculations will be as follows:
220 - 30 = 190
If you can sustain 20 minutes continuously in your target heart rate zone,
begin to increase the length and intensity of your workout.
• Exercise 4-6 days a week or on alternate days.
• Try to reach and maintain 70~85% of your maximum heart
rate with moderate to somewhat hard exercise.
• Exercise 20-30 minutes.
190 x .60 = 114 (low end or 60% of MHR)
190 x .75 = 142 (high end or 75% of MHR)
30 year-old (THR) Target Heart Rate would be 114-142
See Heart Rate Table (on next page) for additional calculations.
WARNING:
19
Console Information
These strategies are intended for average healthy adults. If you have pain
Download from Www.Somanuals.com. All Manuals Search And Download.
www.keysfitness.com
or tightness in your chest, an irregular heartbeat, shortness of breath or you feel faint or have any discomfort when you exercise SToP. Consult your
physician before continuing. Remember every workout should begin with warm-up and finished with cool-down.
Cool down: Slow and Relaxed Exercise
The cool-down allows your body’s cardiovascular system to gradually return to normal and should be roughly 5-10 minutes. lower your exercise
intensity gradually, and when your heart rate has returned below 110 beats per minutes, you can end your workout.
Monitoring Your Heart Rate
To obtain the greatest cardiovascular benefits from your exercise workout, it is important to work within your target heart rate zone. The American
Heart Association (AHA) defines this target as 60%-75% percent of your maximum heart rate.
Your maximum heart rate may be roughly calculated by subtracting your age from 220. Your maximum heart rate and aerobic capacity naturally
decreases as you age. This may vary from one person to another, but use this number to find your approximate effective target zone. For exam-
ple, the maximum heart rate for an average 40 year-old is 180 bpm. The target heart rate zone is 60%-75% of 180 or 108-135 bpm.
See Fitness Safety on the next page.
Console Information
20
Download from Www.Somanuals.com. All Manuals Search And Download.
www.keysfitness.com
Before beginning your workout, check your normal
resting heart rate. Place your fingers lightly against
your neck, or against your wrist over the main
artery. After finding your pulse, count the number of
beats in 10 seconds. Multiply the number of beats
by six to determine your pulse rate per minute. We
recommend taking your heart rate at these times;
at rest, after warming up, during your workout and
two minutes into your cool down, to accurately
track your progress as it relates to better fitness.
TARGET HEART RATE ZONE
200
195
100%
190
185
180
175
170
165
160
Serious
athletic
training range
155
132
During your first several months of exercising, the
AHA recommends aiming for the lower part of the
target heart rate zone-60%, then gradually pro-
gressing up to 75%. According to the AHA, exercis-
ing above 75% of your maximum heart rate may
be too strenuous unless you are in top physical
condition. Exercising below 60% of your maximum
will result in minimal cardiovascular conditioning.
85%
170
166
162
157
153
149
145
140
136
Cardiovascular
conditioning
range
75%
Fat burning
range
150
120
146
117
143
139
111
135
108
Check your pulse recovery rate – If your pulse is
over 100 bpm five minutes after you stop exercis-
ing, or if it’s higher than normal the morning after
exercising, your exertion may have been too stren-
uous for your current fitness level. Rest and reduce
the intensity next time.
131
105
128
102
124
99
120
96
116
93
60%
114
Fitness Safety The target heart rate chart indi-
cates average rate zones for different ages. A
variety of different factors (including medication,
emotional state, temperature and other conditions)
can affect the target heart rate zone that is best for
you. Your physician or health care professional can
help you determine the exercise intensity that is
appropriate for your age and condition.
20 25 30 35
40 45 50 55 60 65
AGE
21
Console Information
Download from Www.Somanuals.com. All Manuals Search And Download.
Workout Information
22
Download from Www.Somanuals.com. All Manuals Search And Download.
www.keysfitness.com
EXERCISE GuIDELINES
WARNING! Before beginning this or any exercise program, you should consult your physician. This is especially important for individuals over the
age of 35 or individuals with pre-existing health problems.
Flexibility is a key to fitness. Stretch all major muscle groups at least two to three times per week after a 5 to 10 minute warmup. Stretch just to
the point of a gentle tug. If you have back, joint, or other health problems, talk to your doctor first.
Prone on Elbows
Knees to Chest
lie on your stomach with your
feet together. Rest on your fore-
arms with your elbows directly
under your shoulders. Relax
lower back and abdomen into
floor. Hold for 30-60 seconds or
until muscles feel looser.
lie on your back. Bend your knees,
and lift your feet off the floor. Grasp
your knees with your arms and pull
your knees toward your chest. Hold
for 20 seconds. Repeat three to five
times.
Shoulder Circles
Cat and Camel
In a smooth, continuous motion, make
a circle with your shoulders: Raise
them up towards your ears, pull them
together behind you, lower them to a
resting position, then roll them for-
ward. Repeat 10 times.
Rest on your hands and knees.
Round your back by contract-
ing your abdominal muscles and
tucking in your pelvis; hold for five
seconds. Then allow your back
to sag toward the floor as you lift
your chest and head; hold for five
seconds. Repeat the combination
10 times
Supline Lumbar Rotation
Cervical Side Bends
lie on your back with your knees
bent. Keeping your knees together
and your shoulders against the floor,
roll your knees to one side until you
feel a stretch in your back or hip. Hold
for 30-60 seconds or until muscles
feel looser. Repeat on opposite side.
Tilt your head gently toward one
shoulder, keeping your shoulders level
and your face pointed straight ahead.
Hold for five seconds, then tilt your
head toward the other shoulder and
hold for five seconds. Repeat five
times on each side.
23
Workout Information
Download from Www.Somanuals.com. All Manuals Search And Download.
www.keysfitness.com
WARNING! Before beginning this or any exercise program, you should consult your physician. This is
especially important for individuals over the age of 35 or individuals with pre-existing health problems.
Wrist Extensor
One-Arm Pectoralis Stretch
Extend your right arm in front of you
with your palm up and your elbow
straight. Point your fingertips toward
the floor by bending at the wrist. Us-
ing your left hand, pull the back of
your right hand toward you gently.
Hold for 20 seconds; repeat three to
five times with each arm.
Stand against an immobile structure like a
wall or a tree. While facing the wall, raise
your right hand out to your side at chest
height, palm against the wall. Turn your
body toward the left, away from the wall
and your extended arm, until you feel a
stretch. Hold for 20 seconds; repeat three
to five times with each arm.
Wrist Flexor
Groin (Adductors) Stretch
Extend your right arm in front of you,
palm down, elbow straight. Point
your fingertips toward the floor by
bending at the wrist. Using your left
hand, pull your right palm toward you
gently. Hold for 20 seconds; repeat
three to five times with each arm.
Sitting with your back straight, bring the
soles of your feet together. let your knees
lower toward the floor. Hold for 30-60 sec-
onds or until muscles feel looser.
Piriformis Stretch
Triceps Stretch
lie on your back. Bend your right knee
and lift it halfway to your chest. Grasp
your knee with your left hand and pull it
toward your left shoulder, keeping both
buttocks against the floor. Hold for 20
seconds; repeat three to five times with
each leg.
Place your right hand behind your head, palm facing your
head. With your left hand, grasp your right elbow and pull
downward until you feel a stretch in the back of your right
arm. Hold for 20 seconds; repeat three to five times with
each arm.
Workout Information
24
Download from Www.Somanuals.com. All Manuals Search And Download.
www.keysfitness.com
WARNING! Before beginning this or any exercise program, you should consult your physician. This is especially important for individuals over the
age of 35 or individuals with pre-existing health problems.
Calf Stretch
Face a solid structure such as a wall with your left
foot ahead of your right, toes straight ahead. Bend
your left knee, press your hips forward, and lean
into the wall. Keep both heels down, your right leg
straight, and you left knee over your ankle. Hold
for 20 seconds; repeat three to five times with
each leg.
Achilles Stretch
Face the wall with your left foot ahead of your right, toes
straight ahead. Bend both knees, press your hips forward,
and lean into the wall. Keep both heels down and both knees
in line with your feet. Hold for 20 seconds; repeat three to five
times with each leg.
Standing Quadriceps Stretch
Steady yourself with one hand. With the other, grab outside
leg at ankle, keeping body straight from knee to hip. Gently
pull foot up and towards the buttocks until you feel a stretch
along the front of the thigh. Thigh should be pulled straight
back and not drift to outside. Hold 20-30 seconds. For
variation, grab opposite ankle (i.e., grab right ankle with left
hand). Do two to three repetitions per leg.
25
Workout Information
Download from Www.Somanuals.com. All Manuals Search And Download.
Troubleshooting
26
Download from Www.Somanuals.com. All Manuals Search And Download.
www.keysfitness.com
Calibrating Treadmill
Do not attempt to calibrate the treadmill unless an Error Code is present.
our treadmill is equipped with a software package that will perform a calibration sequence unique to your specific model number.
Please perform the following steps to calibrate the Keys T4.0 Treadmill.
1. Unplug power cord from outlet strip.
2. Attach Safety Key to console.
3. Plug power cord into outlet strip.
4. Initiate calibration sequence. locate the hole on the back of the console (indicated by sticker) and insert eraser end of a pencil through hole
to adjust. Press the calibration switch twice. You will then hear a beep.
5. CL21 should appear in the Time window.
Note: During the calibration sequence, the Time window will display which step you are at in the process (C21, C22,
C23 and so on). The CAl/DIST window will display which key should be pressed next. For example, “E” for Enter,
“P” for Power, or “SS” for Start / Stop.
6. CL21: MPH or KPH will be flashing in the Speed window, pressing the Speed +/ - button will toggle options. Choose MPh (KPH), press Enter.
You may change this again if you would like to go by Kilometers.
7. CL22: 8, 10, or 12 (13, 16, or 20 in KPH mode) will be displayed in the Speed window, pressing the Speed +/ - button will toggle options.
Choose 10 (or 16 for KPH mode). Incline window will also display a value. This value needs to be 126, adjust with incline +/- button if neces-
sary to get to 126. Press Enter.
8. CL23: FFF or UUU will be displayed in the Speed window, pressing the Speed +/ - button will toggle options. Choose uuu, press Enter.
9. CL24: 111 or 222 will be displayed in the Speed window, pressing the Speed +/ - button will toggle options. Choose 111, press Enter.
10. CL25: nHU or HrU will be displayed in the Speed window, choose nhu by pressing the speed +/- button. Press Enter to confirm selection.
11. CL26: oPA or oPI will be displayed in the Speed window, pressing the Speed +/ - button will toggle options. Choose OPA, press Enter.
12. CL27: Blank (nothing), “a”, “b”, “c”, “d” or “e” will be displayed in the Incline window, pressing the Speed +/ - button will toggle options. Choose
“a”, press Enter.
13. CAl/DIST window will display “55”. Press Start / Stop. “E” will display in CAl/DIST window.
14. At this time, make sure you are not standing on the walking belt, as the machine will automatically initiate belt movement and run through a
complete calibration and diagnostic routine.
Press Enter. Belt will begin to move. Unit will begin self-calibration.
15. When Speed and Incline calibration has finished, press Power button twice, display should be blank, and treadmill should be ready for use.
To avoid possible damage to the treadmill and the possibility of injury, do not operate the treadmill until the problem is corrected. Call
Keys Fitness Customer Service at (800) 340-0482 if problem persists.
27
Calibration Sequence
Download from Www.Somanuals.com. All Manuals Search And Download.
www.keysfitness.com
Treadmill Error Messages
Your treadmill is equipped with a software package that enables error messages to be displayed when there is a problem. The following error
codes will be displayed in the console display windows.
Safety Interlock Error Messages
SI 1 - Safety key missing, replace and try again.
SI 2 - over voltage protection trip. Notify Keys Fitness Customer Service.
Other Error Messages
E11 - lack of speed feedback data from belt motor. Attempt calibration. See Calibration Sequence section on page 27 of this owners Manual for
detailed information.
E22 - Under Speed condition detected from the belt motor. Attempt calibration. See Calibration Sequence section for detailed information.
E33 - over Speed condition detected from the belt motor. Attempt calibration. See Calibration Sequence section for detailed information.
E44 - Stuck key detected at power up, Notify Keys Fitness Customer Service.
E66 - Will blink on the incline window to indicate that treadmill belt needs to be re-lubricated. This message will be repeated every 30 hours.
To avoid possible damage to the treadmill and the possibility of injury, do not operate the treadmill until the problem is corrected. Call
Keys Customer Service at 800-340-0482.
Clearing E66 Message
once the belt has been properly lubricated (See maintenance instruction on page 30). You can clear the E66 treadmill belt lubrication reminder
with the following steps:
1. Unplug power cord from outlet strip.
2. Attach safety key to console.
3. Plug power cord into outlet strip.
4. Press the (Speed +, Speed -, and Pause) keys simultaneously, then you will hear a beep.
5. The message E66 appears in the incline window and the number 30 appears in the speed window.
6. Press the Speed + and the Speed - and pause keys simultaneously for 4 seconds, then you will hear a beep.
7. The characters “---” will appear in the incline/speed window, flashing for 3 seconds.
8. The console turns off after operation is completed.
28
Error code
Download from Www.Somanuals.com. All Manuals Search And Download.
www.keysfitness.com
Belt Adjustment
WARNING! Do not over-tighten rollers! This will cause premature roller bearing failure!
Belt adjustment and tension performs two functions: adjustment for tension and centering. Your new tread-
mill comes pre-adjusted from the factory for tension and centering. Please follow the procedures below if
the belt shifts to the left or right while walking:
WALKING BELT IS ShIFTING TO ThE LEFT
(Diagram 1)
First, turn treadmill on to run at 1 mph. Using the hex key provided, turn the left rear roller adjustment bolt
¼ turn in the clockwise direction. Next, run the treadmill at 2.5 mph. You should see the belt start to correct
itself by moving back toward the center. Repeat the above procedure until the walking belt is centered. It
may be necessary to set walking belt tension once you have completed this procedure if the belt feels like it
is slipping while walking. Refer below to the “Walking Belt Slipping” instructions.
WALKING BELT IS ShIFTING TO ThE RIGhT
(Diagram 2)
First, turn the treadmill on to run at 1 mph. Using the hex key provided, turn the right rear roller adjustment
bolt ¼ turn in the clockwise direction. Next, run the treadmill at 2.5 mph. You should see the belt start to cor-
rect itself, moving back toward the center. Repeat the above procedure until the walking belt is centered. It
may be necessary to set walking belt tension once you have completed this procedure if the belt feels like it
is slipping while walking. Refer below to the “Walking Belt Slipping” instructions.
WALKING BELT IS SLIPPING DuRING uSE (Diagram 3)
First, unplug the power cord from the surge protector. Using the hex key provided, turn both left and right
rear roller adjustment bolts the same distance, usually a ¼ turn, in the clockwise direction. Plug the power
cord back into the surge protector and run the treadmill at 2.5 mph. You should now walk on the belt to
determine if the belt is still slipping. Repeat the above procedure until the walking belt is not slipping. The
tension should be just tight enough not to slip.
Note: Turning the hex key clockwise brings the rear rollers and belt towards you.
Turning the hex key counter clockwise pushes the rear roller and belt away from you.
29
Belt Adjustment
Download from Www.Somanuals.com. All Manuals Search And Download.
www.keysfitness.com
Maintenance Instructions
WARNING! Before performing any maintenance to your treadmill, always unplug the power
cord from the surge protector.
CLEANING:
Routine cleaning of your unit will extend the life of your unit.
WARNING! To prevent electrical shock, be sure the power to the treadmill is oFF and the unit is
unplugged from the wall electrical outlet before attempting any cleaning or maintenance.
AFTER EACh WORKOuT:
Wipe off the console and other treadmill surfaces with a clean, water dampened soft cloth to remove
excess perspiration. USE No CHEMICAlS.
WARNING: Do not over-lubricate
the walking board. Excess lubricant
should be wiped off with a clean
towel.
WEEKLY:
Use of a treadmill mat is recommended for ease of cleaning. Dirt from your shoes contacts the belt and eventually makes it to underneath the
treadmill. Vacuum underneath treadmill once a week.
DECK LuBRICATION:
The walking belt has been pre-lubricated at the factory. However, it is recommended that the walking board be checked periodically for lubrica-
tion to ensure optimal treadmill performance. Every 30 days or 30 hours of operation, lift the sides of the walking belt and feel the top surface of
the walking board as far under as you can reach. If you feel signs of silicone, no further lubrication is required. If it feels dry to the touch, lubri-
cation is needed. Please note that this unit comes with an automated reminder to lubricate your treadmill once every 30 hours (E66 blinking in
your incline window). Keys Fitness recommends “lube N Walk” for cleaning and lubricating the treadmill belt and deck. Ask your retailer or call
Keys Fitness at 800-340-0482.
TO APPLY LuBRICANT TO ThE WALKING BOARD
1.) Take foam wand applicator, without lube, and insert it in between the walking belt and deck, exposing the two plastic tabs at either end of
the walking belt. Take both tabs and run the wand back and fort along the entire length of your deck. Remove the applicator and prepare for
lubrication.
2) Apply about a dime’s worth of lubrication onto the side of the applicator wand hat was not used for removing dirt and debris (step 1). You can
add more or less lubricant, depending on your lubrication schedule.
3) Insert the wand between the walking belt and deck, exposing the two white plastic tabs at either end of the walking belt.
4) Take both of the tabs and run the wand back and forth along the entire length of your deck. You are done until your next scheduled
lubrication date.
5) Allow the silicone to ‘set’ for one minute before using the treadmill.
30
Maintenance Instruction
Download from Www.Somanuals.com. All Manuals Search And Download.
Troubleshooting Guide
www.keysfitness.com
Treadmill will not start.
1. Is the Safety Key inserted into the treadmill Console?
2. Make sure the power cord is plugged into a surge protector, the surge protector is plugged into a properly grounded outlet, and the surge pro-
tector is turned on. (Refer to “Power Requirements” on page 10.)
3. Check the circuit breaker located on the front of the treadmill. If the switch protrudes, it has tripped. Wait five minutes and then press the
switch back in.
4. Check the house electrical breaker box and the circuit breaker for the room where the treadmill is located. If it has tripped, reset or have an
electrician replace the breaker in home.
5. Have an electrician check to insure there is adequate voltage at the outlet.
Treadmill loses power during use.
1. Check the circuit breaker located on the front of the treadmill. If the switch protrudes, it has tripped. Wait five minutes and then press the switch
back in.
2. Check the house electrical breaker box and the circuit breaker for the room where the treadmill is located. If it has tripped, reset or have an
electrician replace the breaker in home.
3. If the treadmill will not operate, please call Keys Fitness Customer Service at (800)-340-0482.
Treadmill walking belt slows during use.
1. Check to make sure the treadmill is securely plugged into an Ul-listed surge protector, rated at 15 amps, with a 14-gauge cord of five feet or
less and the surge protector is securely plugged into the outlet.
2. If treadmill will not operate, please call Keys Fitness Customer Service at (800)-340-0482.
Treadmill walking belt slips or is not centered on rear roller.
1. Refer to “Belt Adjustment” section on page 12.
2. Need help? Call Keys Fitness Customer Service at (800)-340-0482.
Treadmill belt is making noise
Treadmill belt may develop “belt memory” where the rollers are located due to packaging and storage. The noise goes away once the belt has
been stretched out properly from regular use.
Treadmill Error Messages.
Your treadmill is equipped with a software package that enables error messages to be displayed when there is a problem.
Treadmill Belt Reminder.
After 30 hours of use, the console will remind you to lubricate your belt.
To avoid possible damage to the treadmill and the possibility of injury, do not operate the treadmill until the problem is corrected.
Call Keys Fitness Customer Service at (800)-340-0482.
Troubleshooting guide 31
Download from Www.Somanuals.com. All Manuals Search And Download.
Parts Information
32
Download from Www.Somanuals.com. All Manuals Search And Download.
www.keysfitness.com
33
Exploded view
Download from Www.Somanuals.com. All Manuals Search And Download.
www.keysfitness.com
KF-T4.0 Parts List Rev A
Ref #
1
2
3
4
5
6
7
9
Part #
Description
BASE FRAME, KF TREADS FY2009
ELEVATION SUPPORT, KF TREADS FY2009
DECK FRAME, KF TREADS FY2009
UPRIGHT, LEFT KF TREADS FY2009
UPRIGHT, RIGHT KF TREADS FY2009
BELT, POLY-V 200J8
WALK BELT, 20X56 KF
BRACKET, MOTOR CONTROLLER
SUPPORT, WALK DECK
WALK BOARDͼKF TREADS FY2009
ROLLER, FRONT KF TREADS FY2009
ROLLER, REAR KF TREADS FY2009
HEX BOLT,
END CAP, LEFT
END CAP, RIGHT
COVER, MOTOR
COVER, BREAKER SWITCH
COVER MOTOR
FENDER, LEFT
FENDER, RIGHT
EXTRUSION, KF TREADS FY2009
BASE BUMPER, 48X35X8
GAS SHOCK, 250N
Qty
1
1
1
1
1
1
1
1
1
1
1
1
2
1
1
1
1
1
1
1
2
4
2
2
4
2
4
6
4
14
1
2
1
1
1
10
2
2
6
2
4
2
2
2
8
14
16
2
24
4
4
6
2
2
4
16
2
4
1
Ref #
62
67
68
69
70
71
72
73
74
75
77
78
100 100091
101 100092
102 100093
103 100094
104 100095
105 100096
106 100097
107 100098
108 410-00059
109 100099
110 402-00112
111 100100
112 100101
113 402-00098
115 100102
116 419-00009
117 100103
118 100121
119 100122
120 100113
Part #
408-00002
406-00072
100083
100084
100085
100086
100087
100088
100089
Description
Qty
2
2
1
1
2
2
2
4
4
6
2
6
1
1
1
1
1
1
1
2
4
2
35
6
2
36
4
1
1
6
1
1
1
1
2
1
1
1
2
2
1
1
1
1
1
1
1
1
1
1
2
1
1
1
3
1
1
1
1
-
-
-
PLATE, STATIC
WHEEL, FRONT
LATCH GUIDE, LEFT
LATCH GUIDE, RIGHT
100001
100002
100118
100126
100005
100006
100007
100008
100009
100010
100011
100012
100013
100053
100054
100055
100056
100057
METAL BUSHING
METAL BUSHING
SHOULDER ALLEN BOLT, M12X60
SHAFT, REAR WHEEL
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
49
50
51
52
53
54
55
56
57
58
59
60
61
COVER, BUMPER
100090
100119
100120
COVER, ISOLATOR
WASHER, 12X20X2
PHILLIPS SCREW, ST4.8X19
CROSSBAR, KF-T2.0
125
HOUSING, CONSOLE LEFT
HOUSING, CONSOLE RIGHT
HOUSING, CONSOLE MIDDLE
INSERT, CONSOLE B 4 WIND LCD
HOLDER, WATER BOTTLE LEFT
HOLDER, WATER BOTTLE RIGHT
PLUG, HANDLEBAR
RECEPTACLE, PULSE PLATE
RECEPTACLE, PULSE 184X36X23.3
PHILLIPS SCREW, ST4.2X13
PHILLIPS SCREW, ST4.2X70
PHILLIPS SCREW, ST4.2X45
PHILLIPS SCREW, ST2.9X6.5
PHILLIPS SCREW, ST2.9X13
PLATE, REED SWITCH
406-00079
100058
406-00008
100059
100060
100061
ADJUST SUPPORT
GROMMET, IRONMAN UPRIGHT
WHEEL, PU
BUMPER, LONG 47X32X21
BUMPER, DECK 25X20
BRACKET, SIDE MOTOR COVER
SPRING WASHER, 10X19X0.25
WRENCH, ALLEN 7/32"
SHOULDER ALLEN BOLT, M8X75
SHOULDER ALLEN BOLT, M8X55
HEX BOLT, M10X60
HEX BOLT, M10X40
ALLEN BOLT, M8X15X15
ALLEN BOLT, M8X40
ALLEN BOLT, M8X50
ALLEN BOLT, M8X55
126
100062
139
419-00028
402-00198
410-00024
100063
100064
202-00159
100065
202-00039
100066
100067
100068
100127
402-00106
100070
100071
100072
100073
100074
100075
100076
402-00112
100128
SAFETY KEY, KF TREADS FY2009
CHAMFER BOLT, ST4.2X70
PLUG, MOTOR COVER
124
PCB, UPPER 1 WINDOW BLUE/WHITE LCD
PCB, CONSOLE BUTTONS
EKG MODULE, 07-0092H HAI ZHEN
REMOTE PCB, ENVISION
WIRE HARNESS, MAIN TOP
WIRE HARNESS, MAIN BOTTOM
WIRE HARNESS, ENCODER
WIRE HARNESS, REMOTE TOGGLE
WIRE HARNESS, EKG
WIRE HARNESS, PULSE
REED SWITCH
MOTOR CONTROLLER, 08-0158H HAI ZHEN
TRANSFORMER, W/ FAN
FUSE
121 100114
122 407-00111
123 407-00036
124 100106
143
125
125 100107
134
126 413-00068
127 413-00069
128 413-00070
129 413-00066
130 413-00067
131 407-00107
132 408-00016
133 408-00023
134 413-00017
135 402-00086
136 402-00044
137 402-00045
138 100123
139 100109
140 408-00004
141
142 100110
143 408-00005
144 407-00122
145 100111
146 406-00200
#
ALLEN BOLT, M10X55
CHAMFER BOLT, M6X25
CHAMFER BOLT, M6X30
PHILLIPS SCREW, M6X20
PHILLIPS SCREW, M6X30
PHILLIPS SCREW, M5X10
PHILLIPS SCREW, M4X8
PHILLIPS SCREW, ST4.2X13
PHILLIPS SCREW, ST4.2X16
PHILLIPS SCREW, ST4.2X13
JAM NUT, M8
NYLON LOCK NUT, M10
NYLON LOCK NUT, M8
NYLON LOCK NUT, M6
WASHER, 6.6X12X1.6
WASHER, 6.6X12X1.6
WASHER, 9X16X1.6
128
WIRE HARNESS, JUMP
PHILLIPS SCREW, ENVISION
PHILLIPS SCREW,
WASHER,
PHILLIPS SCREW, ST4.0X20
FERRITE, ENVISION
CIRCUIT BREAKER, ENVISION
DRIVE MOTOR, 12-0057
FAN, DRIVE MOTOR
402-00023
202-00204
100078
100079
100080
202-00224
100081
100082
412-00008
FERRITE, ENVISION
ENCODER,
ACTUATOR,
WASHER, 12X20X2
WASHER, 12X24X2.5
LATCH SET
POWER CORD, ENVISION
BOLT PACK, KF TREADS FY2009
100112
410-00060
129
140
34 Exploded View / Parts List
Download from Www.Somanuals.com. All Manuals Search And Download.
www.keysfitness.com
Conditions and Restrictions
Residential and Personal Use Limited Warranty
This warranty DOES NOT (A) cover shipping and handling charges, export taxes, custom duties and taxes, or
any other charges associated with transportation of the parts or Product, beyond the initial courtesy period of
60 days from original date of purchase of the Product; (B) extend to Products not purchased from Keys Fitness
Products or from an authorized Keys Fitness Products reseller; (C) extend to Products purchased from online auc-
tion sites; (D) cover any extended, additional, or third party warranties if not offered exclusively by Keys Fitness
Products in writing; (E) cover Products installed at fee based facilities/commercial environments (gyms, homes
used as wellness centers, etc.); (F) cover Products installed in light institutional environments (non fee-based facili-
ties include for example, and not be way of limitation, fire houses, police departments, rehab centers, hospitals,
clinics, apartment complexes, club houses, etc.); (G) cover service calls to correct installation, perform mainte-
nance, or instruct owners on how to use the equipment; or (H) cover a Product on which the serial number has
been purposefully or accidentally defaced or removed and there is no proof of purchase available (if serial num-
ber is applicable), unless authorized by Keys Fitness Products in writing or otherwise stated on this warranty.
PLEASE READ THESE WARRANTY TERMS AND CONDITIONS FULLY AND CAREFULLY
BEFORE USING YOUR Keys Fitness EQUIPMENT. BY USING THE EQUIPMENT, YOU ARE
CONSENTING TO BE BOUND BY THE FOLLOWING TERMS AND CONDITIONS.
Frame: Lifetime Parts: 3 years
Labor: 1 year Motor: Lifetime
Limited Warranty
This Limited Warranty applies in the United States and Canada to Products manufactured or distributed by
Keys Fitness , L.P. under the Keys Fitness (“Keys Fitness Products”) brand name (as used herein, the “Product” or
“Products”). The warranty period to the original purchaser is listed above, and commences on the date of origi-
nal purchase of the product, unless otherwise authorized by Keys Fitness Products. Keys Fitness Products warrants
that the Product purchased from Keys Fitness Products or from an authorized Keys Fitness reseller “dealer” (for
residential or personal use only, unless otherwise authorized by Keys Fitness Products in writing), is free from
defects in Materials and Workmanship relevant to the functionality of the Product at initial startup, under normal
use, and during the applicable warranty period, unless otherwise determined by Keys Fitness Products.
This Limited Warranty becomes void for Products that have been damaged or rendered defective as a result of
(a) accident, misuse, or abuse (including but not limited to exceeding the Keys Fitness Products listed, maximum
weight limit); (b) use of parts not manufactured or sold by Keys Fitness Products; (c) modification of the Product;
(d) normal wear and tear; (e) operation on incorrect power supplies; (f) ***failure to perform (or performing
improper) maintenance; (g) service by anyone other than Keys Fitness Products, or an authorized Keys Fitness
Products warranty service provider; (h) floods, fires, earthquakes, lightning strikes, power surges, and other
unavoidable acts of nature; (j) residential mis-wires; or (k) incorrect setup, installation, or assembly. Should any
Product (submitted for warranty parts replacement) be found ineligible under the terms outlined on this warranty,
an estimate for parts purchase (if available) can be furnished at your request.
This warranty excludes expendable parts if primary cause for warranty claim is wear. Expendable parts pertain
to components on the Product that are prone to normal wear and tear. These items vary by Product, and can
include (but not limited to) hand grips, skid pads, pedals, pedal straps, poly-v belts, console overlays, toggle
switch/button overlays, (luster free or dull) ekg plates, decals, and any other items that are not essential to the
operation of the Product, unless otherwise determined by Keys Fitness Products.
* Parts is herein defined exclusively, for all intents and purposes, and pertaining to this Limited Manufacturer Warranty, as
components or Materials essential to the functionality of the Product.
This warranty extends only to you, the original purchaser. It is not transferable to anyone who subsequently
purchases (or receives as a gift) the Product from you. Your sales receipt, showing the date/place of purchase
and serial number (if applicable) of the Product, is your proof of purchase, and may be required by Keys Fitness
Products any time a warranty parts (or service) claim is made or if no warranty record exists for the product.
**Lifetime of a Product, is herein defined exclusively, for all intents and purposes, and pertaining to this Limited
Manufacturer Warranty, as the time period 7 years beyond the end of production cycle of a Product in question.
Disclaimer and Release
Exclusive Remedies
EXCEPT AS EXPRESSLY SET FORTH IN THIS WARRANTY, Keys Fitness Products MAKES NO OTHER WARRANTIES,
EXPRESSED OR IMPLIED, INCLUDING ANY IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A
PARTICULAR PURPOSE. Keys Fitness Products EXPRESSLY DISCLAIMS ALL WARRANTIES NOT STATED IN THIS LIMITED
WARRANTY. ANY IMPLIED WARRANTIES THAT MAY BE IMPOSED BY LAW ARE LIMITED TO THE TERMS OF THIS LIMITED
WARRANTY. NEITHER Keys Fitness Products NOR ANY OF ITS AFFILIATES SHALL BE RESPONSIBLE FOR INCIDENTAL
OR CONSEQUENTIAL DAMAGES. SOME STATES DO NOT ALLOW LIMITATIONS ON IMPLIED WARRANTIES OR THE
EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES, SO THE ABOVE LIMITATIONS OR
EXCLUSIONS MAY NOT APPLY TO YOU. THIS LIMITED WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS AND YOU
MAY ALSO HAVE OTHER RIGHTS THAT MAY VARY FROM STATE TO STATE. THIS IS THE ONLY EXPRESS WARRANTY
APPLICABLE TO Keys Fitness Products-BRANDED PRODUCTS. Keys Fitness Products NEITHER ASSUMES NOR AUTHORIZES
ANYONE TO ASSUME FOR IT ANY OTHER EXPRESS WARRANTY.
During the warranty period listed above, Keys Fitness Products will repair a Product by correcting any minor
issues (either by phone or online support) that might be causing the Product failure. Should a technical service
and support representative be unable to correct the issue, Keys Fitness Products may replace the parts (with new
parts or at the option of Keys Fitness Products, with serviceable used parts, that are equivalent to new parts in
performance) that become defective, malfunction, or otherwise fail
to conform to this Limited Warranty under normal use.
Replacement parts shall be warranted for 30 days from the shipment reception date or through the end of the
‘replaced’ part warranty period, whichever is longer. Any replacement parts, required past the warranty period
listed above, shall be subject to purchase at retail price, plus any added shipping and handling charges associat-
ed to the delivery of the part. Note that replacement parts may be available only through the lifetime (as defined)
of the Product. In conforming to this warranty, Keys Fitness Products (as the manufacturer) reserves the right to
change manufacturers or vendors of any part to cover the existing warranty.
Keys Fitness Products may also provide service (if deemed necessary and if applicable) at no charge to you dur-
ing (and not to exceed) the service warranty period listed above, in an attempt to repair the Product. Should the
Product require service at your request or out of the limited warranty period, Keys Fitness Products can furnish
contact information for local (to your area) Keys Fitness Products authorized service providers. Service quotes,
costs, and scheduling will be strictly dependent on service provider rates and mutual (consumer/provider) service
agreements. Keys Fitness Products is not responsible for any service repair costs accrued through the use of
authorized Keys Fitness Products service providers at your request or out of the limited warranty period (without
written consent from Keys Fitness Products), beyond the limitations outlined on this warranty.
Replacements and Returns
If after a reasonable number of attempts, a defect has not been repaired (or the Product is deemed non-repair-
able by Keys Fitness Products technical service and support staff), Keys Fitness Products, based on a case by
case review, may opt to replace the Product, or recommend an alternate resolution, such as a warranty buy-out
(Product cost, subject to deduction of a reasonable charge for usage) or a credit. Keys Fitness Products, as a
manufacturer, reserves the right to replace the Product with a Factory-Reconditioned Product that meets or exceed
standards comparable to those of the replaced Product.
The warranty covering the replacement Product shall expire on the date the original warranty for the replaced
Product would have expired, unless otherwise determined by Keys Fitness Products.
35
Warranty Information
Download from Www.Somanuals.com. All Manuals Search And Download.
Keys Fitness Products, L.P.
4009 Distribution Drive, Suite 250
Garland, Texas 75041
Customer Service: 1-800-340-0482
Download from Www.Somanuals.com. All Manuals Search And Download.
|